User's guide wind vane wav151 m210294en-a.
Published by vaisala oyj phone (int.):+358 9 8949 1 p.O. Box 26 fax: +358 9 8949 2227 fin-00421 helsinki finland visit our internet pages at http://www.Vaisala.Com/ © vaisala 2002 no part of this manual may be reproduced in any form or by any means, electronic or mechanical (including photocopying),...
___________________________________________________________________ vaisala___________________________________________________________1 table of contents chapter 1 general information .......................................................3 about this manual.............................................
User's guide ________________________________________________________ 2 ______________________________________________________ m210294en-a chapter 5 troubleshooting............................................................ 21 common problems .............................................. 21 gettin...
Chapter 1 ___________________________________________ general information vaisala___________________________________________________________3 chapter 1 general information about this manual this manual provides information for installing, operating, and maintaining the wav151 wind vane. Contents of ...
User's guide ________________________________________________________ 4 ______________________________________________________ m210294en-a version information table 1 manual revisions manual code description m210294en-a this manual, the first version of the wav151 wind vane user's guide. Related man...
Chapter 1 ___________________________________________ general information vaisala___________________________________________________________5 product related safety precautions the wav151 wind vane delivered to you has been tested for safety and approved as shipped from the factory. Note the followi...
User's guide ________________________________________________________ 6 ______________________________________________________ m210294en-a - always hold the boards by the edges and avoid touching the component contacts. Regulatory compliances the wav151 complies with the following performance and en...
Chapter 2 ____________________________________________ product overview vaisala___________________________________________________________7 chapter 2 product overview this chapter introduces the wav151 wind vane features and advantages. Introduction to wav151 wind vane the wav151 wind vane is a coun...
User's guide ________________________________________________________ 8 ______________________________________________________ m210294en-a 0204-044 figure 1 wav151 wind vane the following numbers refer to figure 1 above: 1 = vane assembly 2 = sensor shaft 3 = lower body.
Chapter 3 __________________________________________________ installation vaisala___________________________________________________________9 chapter 3 installation this chapter provides you with information that is intended to help you install this product. Selecting location allow sufficient clear...
User's guide ________________________________________________________ 10 _____________________________________________________ m210294en-a in general, any object of height (h) will not remarkably disturb wind measurement at a minimum distance of 10 × h. There should be at least 150 m open area in al...
Chapter 3 __________________________________________________ installation vaisala__________________________________________________________11 always mount the wav151 wind vane to the northern end of the cross arm. 1. It is recommended that you remove the vane assembly to ease installation. 2. Fit th...
User's guide ________________________________________________________ 12 _____________________________________________________ m210294en-a alignment the wind vane does not need any alignment after mounting when a vaisala cross arm is used. The mounting screws are located at the bottom of the sensor ...
Chapter 3 __________________________________________________ installation vaisala__________________________________________________________13 the following letters refer to figure 5 on page 12. A = d+, power input from 9.5 to 15.5 vdc b = gnd, common ground c = g5, signal output d = g4, signal outpu...
User's guide ________________________________________________________ 14 _____________________________________________________ m210294en-a this page intentionally left blank..
Chapter 4 ________________________________________________ maintenance vaisala__________________________________________________________15 chapter 4 maintenance this chapter provides information that is needed in the basic maintenance of the wav151 wind vane. Periodic maintenance cleaning heavy cont...
User's guide ________________________________________________________ 16 _____________________________________________________ m210294en-a replacing consumables replacement of the bearings should only be done by a trained technician. To replace the ball bearings, follow the procedure below and refer...
Chapter 4 ________________________________________________ maintenance vaisala__________________________________________________________17 10. Remove the internal retaining ring at the bottom of the shaft (using narrow-pointed pliers). 11. Remove the lower bearing. 12. Push out the shaft downwards t...
User's guide ________________________________________________________ 18 _____________________________________________________ m210294en-a note when placing the lower body assembly, make sure that the o-ring is correctly positioned between the upper and lower bodies. It is recommended to replace the...
Chapter 4 ________________________________________________ maintenance vaisala__________________________________________________________19 0204-045 figure 6 wav151 assembly.
User's guide ________________________________________________________ 20 _____________________________________________________ m210294en-a the wind vane has been counter-balanced at the factory but can be readjusted, if necessary. To do this, loosen the vane assembly and place it on its side on the ...
Chapter 5 ______________________________________________ troubleshooting vaisala__________________________________________________________21 chapter 5 troubleshooting this chapter describes common problems, their probable causes and remedies, and contact information. Common problems table 4 some com...
User's guide ________________________________________________________ 22 _____________________________________________________ m210294en-a problem probable cause remedy the heating element does not function. Send the sensor to vaisala for repair. See section return instructions on page 23 for detail...
Chapter 5 ______________________________________________ troubleshooting vaisala__________________________________________________________23 return instructions if the product needs repair, please follow the instructions below to speed up the process and avoid extra costs. 1. Read the warranty infor...
User's guide ________________________________________________________ 24 _____________________________________________________ m210294en-a this page intentionally left blank..
Chapter 6 _______________________________________________technical data vaisala__________________________________________________________25 chapter 6 technical data this chapter provides the technical data of the wav151 wind vane. Specifications table 5 wav151 wind vane specifications property descr...
User's guide ________________________________________________________ 26 _____________________________________________________ m210294en-a property description/value housing material almgsi, gray anodized vane material alsi 12, anodized dimensions 300 (h) × 90 (Ø) mm swept radius of vane: 172 mm wei...
Chapter 6 _______________________________________________technical data vaisala__________________________________________________________27 mttr mean time to repair is 0.3 h..
Www.Vaisala.Com *m210294en*.