1. DL manuals
  2. VAL Avionics
  3. Receiver
  4. NAV 2000
  5. Installation And Operator's Manual

VAL Avionics NAV 2000 Installation And Operator's Manual

Manual is about: ULTRA-THIN NAVIGATION RECEIVER

Summary of NAV 2000

  • Page 1

    Val avionics ltd nav 2000 ultra-thin navigation receiver installation and operator’s manual release issue oct. 2013 p/n 172203-0

  • Page 2

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 2 of 29 oct. 2013 this page intentionally left blank.

  • Page 3

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 3 of 29 oct. 2013 table of contents 1 section i - general information...........................................................................

  • Page 4

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 4 of 29 oct. 2013 1 section i - general information 1.1 introduction thank you for purchacing our nav 2000 navigation receiver . Here at val ...

  • Page 5

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 5 of 29 oct. 2013 1.4 specifications table 1: specifications specifications characteristics environmental rtca/do160d vor rtca/do-196 localiz...

  • Page 6

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 6 of 29 oct. 2013 1.5 equipment supplied table 2: equipment supplied part number qty description 0800120 1 nav 2000 navigation system 0651020...

  • Page 7: Section Ii -

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l 2 section ii - installation 2.1 general information 2.1.1 scope this section of the manual will provide the needed information to successfully complete the inst...

  • Page 8

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 8 of 29 oct. 2013 2.3.3 wire harness fabrication val avionics ltd. Recommends that a factory fabricated wire harness (vpn 0751020) be used fo...

  • Page 9

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 9 of 29 oct. 2013 2.3.4.3 audio the nav 2000 has one navigation audio output. Although the audio output levels of the receivers are capable o...

  • Page 10: Section Iii -

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 10 of 29 oct. 2013 3 section iii - operation 3.1 general information 3.1.1 scope this section will provide detailed operating instructions fo...

  • Page 11

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 11 of 29 oct. 2013 3.1.3.3 setting a bearing the bearing on the unit can be selected through one of three ways: using a mechanical resolver, ...

  • Page 12

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 12 of 29 oct. 2013 3.2.1.1 obs/resolver selection (rs i) selecting the obs input to the unit using the configuration pages has 3 options: ser...

  • Page 13: Section Iv -

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 13 of 29 oct. 2013 4 section iv - warranty and service 4.1 limited warranty the equipment delivered with this standard factory warranty is ma...

  • Page 14: Appendix A

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 14 of 29 oct. 2013 5 appendix a – installation drawings and connector layout figure 1: physical dimensions.

  • Page 15

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 15 of 29 oct. 2013 figure 2: p1 connector pin out (drawing not to scale) figure 3: panel cut out figure 4: mounting tray assembly exploded vi...

  • Page 16

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 16 of 29 oct. 2013 table 4: rear connector pin functions pin functoin i/o 1 main power input 2 airframe ground 3 serial ground 4 rs-232 input...

  • Page 17: Appendix B

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l release issue page 17 of 29 oct. 2013 6 appendix b – wiring diagrams figure 5: nav 2000 basic wiring diagram figure 6: nav 2000 to nav indicator figure 7: nav 2...

  • Page 18

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l this page intentionally left blank.

  • Page 19: Appendix C

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n r e c e i v e r i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l 7 appendix c – instructions for continued airworthiness 7.1 maintenance instructions maintenance of the nav 2000 navigation receiver is on condition only. No pe...

  • Page 20: Appendix D –

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 20 of 29 sept. 2013 8 appendix d – rs-232 instruction listing this appendix includes the interface specifications for the rs-232 serial port....

  • Page 21

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 21 of 29 sept. 2013 8.5 message formats all messages will conform to the nmea 0183 proprietary message format as follows. All characters will...

  • Page 22

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 22 of 29 sept. 2013 8.6 message definitions input messages request data output this input is used to request an output message to be sent by ...

  • Page 23

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 23 of 29 sept. 2013 message format: $pmrv27e4n this example command would set the active vor frequency to 117.100 mhz. This can be interprete...

  • Page 24

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 24 of 29 sept. 2013 a……………..Transceiver function: n = normal, 0 = unchanged. Example message: $pmrrv29g4m this example command would set the ...

  • Page 25

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 25 of 29 sept. 2013 $pmrrv34310 set the obs value to 310 degrees. Com v olume and s quelch control this message is used to adjust the volume ...

  • Page 26

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 26 of 29 sept. 2013 n avigation v olume control this message is used to adjust the volume level of the nav unit message format: "v" ............

  • Page 27

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 27 of 29 sept. 2013 100. –100 indicates full deflection upwards, 0 indicates no reflection, and 100 indicates full deflection downwards. Ff.....

  • Page 28

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 28 of 29 sept. 2013 communications error this message is used to indicate a communication error. Message format: “v” ..................... Me...

  • Page 29

    V a l a v i o n i c s l t d n a v 2 0 0 0 n a v i g a t i o n s y s t e m i n s t a l l a t i o n a n d o p e r a t o r ’ s m a n u a l pre-release issue page 29 of 29 sept. 2013 “v” ..................... Message class. This is a vhf nav message. “35”.................... Message identifier. Mk ........