- DL manuals
- Valcom
- Clock
- V-2425B-6
- Installation Manual
Valcom V-2425B-6 Installation Manual - Check Your Wiring
1 2
3 4
5
Valcom, Inc.
5614 Hollins Road
Roanoke, VA 24019
USA
P. 540-563-2000
F. 540-362-9800
www.valcom.com
Valcom, Inc.
5614 Hollins Road
Roanoke, VA 24019
USA
P. 540-563-2000
F. 540-362-9800
www.valcom.com
3) Attach the communication and power wires from
your kit to the communication and power wires
in the gang box. See the sections of this manual
labeled “Communication Wiring Information”for
additional details, depending on your system.
Wall Mount Installation
1) If you are installing a new gang box in the wall,
leave at least 4 inches between the top of the gang
box and ceiling. Confirm that the bottom of the
gang box is level with the floor.
If you are using an existing gang box, the top of the
gang box must be a minimum of three inches away
from the ceiling.
4) If you do not wish to attach the housing to the
gang box, proceed to step 5A. Otherwise, go to
step 6.
Ceiling
4” Minimum
2) Run power and communication wiring to the
gang box. See the sections of this manual labeled
“Inputs - System Side” for additional details,
depending on your system.
CHECK YOUR WIRING
The voltage between the white and black wires
should measure 105-126 volts AC in the 110
volt model, or Yellow & orange wires for 21.5-
26.5 volts DC in the 24 volt model.
If you are using the 24 volt model, make sure
that the wiring leading to the clock is from a
Valcom power supply or V-VCU.
Summary of V-2425B-6
Page 1
Valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com installation manual v10.5 valcom wired digital clock current as of february 2017 v-d11025b, v-d11040b, v-2425b-6, and v-d2440b-6.
Page 2
2 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com manuals may change without prior notice valcom digital series 2-wire and 3-wire clocks table of contents table of contents 2 important safety instructions 3 wall mount installation 4 - 10 flag mount...
Page 4
4 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation included in package description valcom digital clock digital clock wall housing 6-19x1/2 screw 6-32x1 screw quantity 1 1 4 4 picture please note: a user will also have to pro...
Page 5: Check Your Wiring
1 2 3 4 5 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com 3) attach the communication and power wires from your kit to the communication and power w...
Page 6
5c 5a 5d 5b 6 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 5d) use the keyholes in the back of the housing to hang the clock onto the screws. 5a) if you do not wish to attach the housing to a gang box, place the mounting ...
Page 7
5g 5e 6 5f 7 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 6) perform step 5f, then attach the housing to the gang box usi...
Page 8
7 8a 8b 8 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 7) detach the filter from the clock display board by pressing inward on the red tabs. 8b) if you are installing a digital clock that uses sync-wire correction, attach...
Page 9
11 9 12 10 9 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 12) place the filter over the display board. You should hear a ...
Page 10
13 14 10 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 13) place the housing frame onto the housing. You should hear a snapping noise as the latches drop into place. 14) power the clock. After testing the led segments and ...
Page 11
11 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation description valcom digital clock digital clock wall housing 6-19x1/2 scre...
Page 12
12 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com #6-32x1 screw adapter tab screws 4 4 flag mount installation included in wiring kit (d-pk-3-110-s or d-pk-3-24-s) - 2 kits included power/grounding wires and connector 1 or 110v 24v please note: a ...
Page 13: Check Your Wiring
1 2 3 4 13 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 1) install the double gang box in the wall or ceiling. If you are...
Page 14
5 6 14 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 5) remove the mounting pole end cap and the plastic ring from one of the holes. 6) attach the flag-mount end cap to the pole. Confirm that the covering flap is attached ...
Page 15
7 8 9 10 15 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 7) remove the mounting plate and drill the four holes that were ...
Page 16
11 12 14 13 16 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 13) thread at least fifteen inches (38.1cm) of wiring from the gang box through the bottom of the pole until each wire exits through the hole in the adapter. 12)...
Page 17
15a 15b 16 17 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 16) use the m3/5-15x12 screws to attach the display board to t...
Page 18
19 17 20 18 18 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 20) place the housing frame onto the housing. You should hear a snapping noise as the latches drop into place. 17) use the 6-32x12 screws to attach the display b...
Page 19
21 22 19 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 21) hang the base of the pole on the mounting plate so that the lip...
Page 20
20 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation description valcom digital clock digital clock wall housing 6-19x1/2 screw 6-32x1 screw quantity 1 1 8 8 picture included in package included in pole kit (v-dmkit) if any ...
Page 21
21 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation #6-32x1 screw adapter tab screws 4 4 included in wiring kit (d-pk-3-110...
Page 22: Check Your Wiring
1 2 3 4 22 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 1) install the double gang box in the wall or ceiling. If you are installing the gang box in the wall, leave at least eleven inches between the top of the gang box...
Page 23
5 6 7 8 23 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 5) remove the mounting plate and drill the four holes that were...
Page 24
9 10 11 12 24 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 12) thread at least fifteen inches (38.1cm) of wiring from the gang box through the bottom of the pole until each wire exits through the hole in each adapter. S...
Page 25
13 25 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 13) attach the signal and power wires from your kit to the wires you...
Page 26
14a14b 15 26 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 15) use the m3/5-15x12 screws to attach each display board to the housing. Note: for 2.5” digit clocks, the holes for the screws will be on the left and right in...
Page 27
18 16 19 17 27 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 19) place a housing frame onto each housing. You should hea...
Page 28
20 21 28 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 20) hang the base of the pole on the mounting plate so that the lip is on top of the base, and the holes for the screws are on the bottom of the base. Attach the wir...
Page 29
29 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com adjustable jumper settings every version of the digital clock contains a set of jumpers which can...
Page 30
30 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com inputs - system-side - 2-wire digital v-a2412 or v-a2416 v-a2412b or v-a2416b valcom master clock v-d2425b-6 or v-d2440b-6 *v-c6124p and the v-ccu are ordered as a v-vcu. Data in 2 wire digital out...
Page 31
31 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com inputs - system-side - sync-wire 110vac (v-d110xxb only) black black black j1-2 power power power...
Page 32
32 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com 32 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com inputs - clock-side - sync-wire (v-d110xxb only) inputs for sync-wire protocols are located on...
Page 33
33 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com p. 540-563-2000 f. 540-362-9800 www.Valcom.Com inputs - clock-side - sync-wire (v-d110xxb only) 5...
Page 34
34 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com 110vac interface inputs - clock-side - sync-wire (v-d110xxb only) national time/rauland j1- 1 2 3 4 5 6 7 9 8 neutral reset j1- 1 2 3 4 5 6 7 8 9 j2- 1 2 relay n.O. Com dry contact closure rauland ...
Page 35
35 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com inputs - clock-side - sync-wire (v-d110xxb only) dukane j1- 1 2 3 4 5 6 7 8 9 j2- 1 2 reset minut...
Page 36
36 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com outputs (v-d110xxb only) output relays ( important: detach clock from power source before installing new circuitry. Do not add new circuitry while the clock is operating) the port block on bottom l...
Page 37
37 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the purpose of this section is to get a new digital clock up and running using the manual control...
Page 38
38 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the numbers shown on the left are examples. Going down the list and entering every one of the examples exactly as shown will cause the clock to malfunction or use incorrect data. Program your clock...
Page 39
39 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the numbers shown on the left are examples. Going down the list and entering every one of the exa...
Page 40
40 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the numbers shown on the left are examples. Going down the list and entering every one of the examples exactly as shown will cause the clock to malfunction or use incorrect data. Program your clock...
Page 41
41 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the numbers shown on the left are examples. Going down the list and entering every one of the exa...
Page 42
42 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the numbers shown on the left are examples. Going down the list and entering every one of the examples exactly as shown will cause the clock to malfunction or use incorrect data. Program your clock...
Page 43
43 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com manual controls (v-d110xxb only) the numbers shown on the left are examples. Going down the list ...
Page 44
44 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the digital clock is designed to display time in either a 12-hour or 24-hour format. When the display is set to the 12-hour format, a circular light will appear in the top left corner of the displa...
Page 45
45 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com frequently asked questions can this digital clock be used as a standalone clock? The valcom digit...
Page 46
46 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com troubleshooting the clock is not running. What do i do? 1. Measure the input voltage to the clock. The voltage should measure 85-135 volts in the 120vac model or 240vac model or 10-28 volts in the ...
Page 47
47 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com warranty valcom, inc. Warrants its products only to the original purchaser, for its own use, to b...