- DL manuals
- Valcom
- Clock
- V-A11012
- Installation Manual
Valcom V-A11012 Installation Manual - Check Your Wiring
1 2
3 4
6
Valcom, Inc.
5614 Hollins Road
Roanoke, VA 24019
USA
P. 540-563-2000
F. 540-362-9800
www.valcom.com
Wall Mount Installation
3) Attach the communication, power,
and grounding wires from your kit to the
communication and power wires in the gang box.
See the Wiring Guide included later in this manual
for additional details.
1) Install the single gang box in the wall. Leave at
least 17 inches between the bottom of the gang
box and ceiling. Confirm that the bottom of the
gang box is level with the floor.
CHECK YOUR WIRING
The voltage between the white and black wires
should measure 105-126 volts AC in the 110
volt model or 21.5-26.5 21.5-26.5 volts DC in
the 24 volt model.
If you are using the 24 volt model, make sure
that the wiring leading to the clock is from a
Valcom power supply or V-VCU.
2) Run power and communication wiring to the
gang box. See the sections of this manual labeled
“Wiring Information” for additional details,
depending on your system.
If you are using a 2-wire system, pull the
YELLOW and GREEN wires out of
the connector.
4) Use the #6-32x1/2 screws to attach the mounting
bracket to the gang box. The gang box should be at
the bottom of the mounting piece.
17” Minimum
43.2 cm
Summary of V-A11012
Page 1
Valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom wired analog clocks installation manual v2.0 current as of november 2016 v-a2412 / v-a2412b and v-a2416 / v-a2416b v-a11012 / v-a11012b and v-a11016 / v-a11016b.
Page 2
2 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom wired analog clocks table of contents table of contents 2 important safety instructions 3 identify your clock 4 wall mount installation - 5 - 8 flag mount installation - 9 - 15 double mount i...
Page 3: Very Important:
3 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com important safety instructions very important: know your communication protocol the valcom wired cl...
Page 4: Original Clocks
4 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com identify your clock a label containing the part number of your clock is attached to the clock movement. Original clocks v-a2412 v-a2416 v-a11012 v-a11016 b-model clocks v-a2412b v-a2416b v-a11012b v...
Page 5
5 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation included in package included in wiring kit (a-pk-12-2a) description valcom...
Page 6: Check Your Wiring
1 2 3 4 6 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 3) attach the communication, power, and grounding wires from your kit to the communication and power wires in the gang box. See the wiring guide included later in thi...
Page 7
5 6 7 8 7 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 5) use the pencil to mark the location of the large, circular hole...
Page 8
9 10 8 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wall mount installation 10) use the two m4-0.5x10 screws to attach the clock to the mounting bracket. The screws should pass through the top and bottom holes on the clock, followed by the top a...
Page 9
9 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com power/grounding wires and connector #6-32x1/2 screw m4-0.5x10 #8x1.5 self-tapping screw wall ancho...
Page 10
10 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com dual-mount pole, including mounting plate #10-32x3/8 green screw 1 1 description round clock adapter internal-tooth washer #8-32x7/16 screw quantity 1 4 4 picture flag mount installation included i...
Page 11: Check Your Wiring
1 2 3 4 11 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 1) install the double gang box in the wall or ceiling. If you are...
Page 12
5 6 7 8 12 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 5) remove the mounting plate and drill the four holes that were just traced. Insert the four wall anchors into the holes. 7) thread any wiring through the mounting p...
Page 13
9 11 10 13 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation adapter hole 10) thread at least fifteen inches (38.1cm) of wirin...
Page 14
12 13 14 14 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 12) attach the power connector to the wires you threaded through the pole. Consult the diagrams below for additional help, or see the sections of this manual labele...
Page 15
15 16 15 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com flag mount installation 15) remove the outer adapter screws, then slide the clock onto the ...
Page 16
16 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation dual-mount pole, including mounting plate and adapters #10-32x3/8 green screw 1 1 power/grounding wires and connector #6-32x1/2 screw m4-0.5x10 #8x1.5 self-tapping screw w...
Page 17: Check Your Wiring
1 2 3 4 17 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 1) install the double gang box in the wall or ceiling. If you a...
Page 18
5 6 7 8 18 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com 5) remove the mounting plate and drill the four holes that were just traced. Insert the four wall anchors into the holes. 7) thread any wiring through the mounting plate, and attach a groun...
Page 19
9 10 19 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com double mount installation 9) attach the base of the pole to the mounting plate so that the l...
Page 20
11 12 13 14 20 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com 11) remove the gearbox pin, then, if the case is made of metal, attach the grounding wire to the grounding tab below and to the right of the clock movement. 13) remove the outer adapter...
Page 21
21 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com v-a2412 or v-a2416 v-a2412b or v-a2416b wiring information - 2-wire digital communication valcom ...
Page 22
22 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com warranty valcom, inc. Warrants its products only to the original purchaser, for its own use, to be free from defects in materials and workmanship under conditions of normal use and service for a pe...
Page 23
23 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wiring information - 3-wire synchronous (sync-wire) communication 24vdc black black power power g...
Page 24
24 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com wiring information - 3-wire synchronous (sync-wire) communication 110vac black black power power green ground white white neutral neutral yellow reset reset 27 24 26 23 clock circuit 10 amp contact...
Page 25
25 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com frequently asked questions how do i know if the clock is receiving data? Perform diagnostic 2. Se...
Page 26
26 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com questions about protocols how do i set up the valcom wired clock to accept synchronization protocols from rauland, dukane, and other systems? If you are receiving the protocol directly from the mas...
Page 27
27 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com troubleshooting the clock is plugged into the power, but it is not running. What should i do? A) ...
Page 28
28 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com second hand position 2 seconds 4 seconds 6 seconds 8 seconds 10 seconds 12 seconds 14 seconds 16 seconds 18 seconds 20 seconds 22 seconds 24 seconds protocal and polarity detected 2-wire digital co...
Page 29
29 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com second hand position 2 seconds 4 seconds 6 seconds 8 seconds 10 seconds 12 seconds 14 seconds 16 ...
Page 30
30 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com the purpose of diagnostic #2 is to test the movement gearbox and electrical components of your clock. Diagnostic #2 may be enabled by holding down the diagnostic button for three seconds. If the va...
Page 31
31 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com diagnostic test #2 - comprehensive test (b-model only) the clock hands will remain on these numbe...
Page 32
32 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com number of red flashes 1,2 3,4,5 6,7,8 error message error detected in second hand. Confirm that hands are not hitting each other, then repeat the test. Error detected in the minute or hour hand. Co...
Page 33
33 valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com valcom, inc. 5614 hollins road roanoke, va 24019 usa p. 540-563-2000 f. 540-362-9800 www.Valcom.Com number of red flashes 1,2 3,4,5 6,7,8 error message error detected in second hand. Confirm that h...