Summary of VeloPlus3
Page 1
User manual version 17.12 veloplus3 van raam bv aaltenseweg 56 7051 cm varsseveld the netherlands.
Page 2
User manual veloplus3 17.12 1 table of contents contact details manufacturer............................................................................................ 1 conformity .........................................................................................................................
Page 3
User manual veloplus3 17.12 2 introduction this user manual provides important and necessary information about the use of your tricycle. We ask you to read this manual thoroughly before using the tricycle. Always follow all the instructions given in this manual. Delivery - tricycle with packaging - ...
Page 4
User manual veloplus3 17.12 3 safety measures ensure the tricycle is in good condition each time before using it. Check before each ride that the brakes are in order. Check the lighting and make sure there is enough tyre pressure. Regularly check if the wheels, the handlebars and the saddle are prop...
Page 5
User manual veloplus3 17.12 4 in case of pregnancy, extra care is required owing to a higher risk of injury. Do not put the tricycle in direct sunlight: the temperature of some parts could reach above 41ºc resulting in possible hypersensitivity of the skin. In case that the tricycle is equipped with...
Page 6
User manual veloplus3 17.12 5 min insert adjustment of the tricycle before using the tricycle, adjust it to the measurements of the cyclist. This is of great importance, especially the saddle and the handlebars. If an optimal adjustment of the tricycle, as defined in the instructions, is not possibl...
Page 7
User manual veloplus3 17.12 6 min insert handlebars height the height of the handle bars affects the comfort of the ride. It determines the pressure on the hands and the position of the back. Determine your own most comfortable height by using the bike. To adjust the handlebars: 1. Slightly loosen t...
Page 8: “Click” !
User manual veloplus3 17.12 7 wheelchair transport if you want to transport a wheelchair on the veloplus3, follow the instructions below. 1. Attach the parking brake to the bike by squeezing the left brake [a] and lock it with the pin [b]. 2. Remove the safety pin. 3. Pull the handle up so the ramp ...
Page 9
User manual veloplus3 17.12 8 6. Next, turn the star knob to tighten the belts. 7. Finally fasten the safety belt of the passenger. 8. Replace the safety pin in the coupling. To remove the wheelchair from the bike, follow these steps in reverse order. Caution: stop the wheelchair when you release th...
Page 10
User manual veloplus3 17.12 9 before the first use parking brake always use the parking brake if you park the tricycle and leave it behind. To operate the parking brake, squeeze the left brake [a] and lock it with the pin [b]. By squeezing the brake again it will unlock itself. Lighting front light ...
Page 11
User manual veloplus3 17.12 10 battery indicator under the pressure switch on the top of the front light is a battery indicator that lights up when the batteries are low. Once the battery indicator starts lighting up red, replace the batteries as soon as possible. Replacing batteries the light comes...
Page 12
User manual veloplus3 17.12 11 1x = on 2x = auto 3x = off rear light the rear light has three options which you can choose by pressing the button repeatedly: on- auto-off. The setting is as follows: press 1x : light is on press 2x : lighting is automatic press 3x : light is off with the “on” or “off...
Page 13
User manual veloplus3 17.12 12 gears your tricycle has eight gears. The gears can be adjusted by turning the handle. Never pedal when changing gears. Please note: if your bike has an electric motor you must continue pedalling when changing gears. Check before every ride: the brakes (including the pa...
Page 14
User manual veloplus3 17.12 13 important safety points for the cyclist be very careful during the first ride. When riding the tricycle hold both hands firmly on the handlebars and feet on the pedals. Test the riding style of the tricycle on rough ground at moderate speed. This way the cyclist learns...
Page 15
User manual veloplus3 17.12 14 electro system silent the silent electric motor system is a special developed support system by van raam for the rehabilitation market. The system is characterized by: 1. A simplicity of operation 2. Individually adjustable support for cycling 3. Modern and efficient e...
Page 16
User manual veloplus3 17.12 15 2. Degree of support 1, 2 and 3 the desired support can be set by using one of the support levels 1, 2 or 3. 1. Light support, maximum range. 2. Average support, average range. 3. Maximum support, low range. You can change the level while cycling. 3. Start assist the s...
Page 17
User manual veloplus3 17.12 16 reverse mode the reverse mode is activated by pedalling backwards from a standing position. Within a few seconds the motor is activated and the tricycle cycles at a speed of about 2 km/h backwards (when you start to pedal backwards). Do not be startled by an unexpected...
Page 18
User manual veloplus3 17.12 17 charging the battery for the best performance and to prolong the life of the battery, we recommend that you charge the battery at home at room temperature. To charge the battery: 1. Unlock the battery by turning the key a quarter. 2. Pull the handle forward. 3. Take th...
Page 19: 11.
User manual veloplus3 17.12 18 9. Put the battery back in the holder of the cycle. Slide it behind bar [a] and press it firmly on strip [b]. 10. Pull the handle backwards and push the top of the battery to connect as shown in the drawing and close the lock. 11. Push the handle forward and close the ...
Page 20
User manual veloplus3 17.12 19 make sure that the switch is set to the side the battery is placed. Backup battery (optional) the bike can be supplied with a second battery. To activate the second battery (when the first battery is empty) turn the switch under the luggage carrier to the right sight. ...
Page 21
User manual veloplus3 17.12 20 beware: never leave the bike with an empty battery! We advise you charge the battery as soon as possible before it’s totally empty. The best storage-charge of the battery is when three to five led lights burn. Check the battery every month in the winter. If fewer than ...
Page 22
User manual veloplus3 17.12 21 accessories depending on your order, you can use the accessories as described below. Dividable frame the ramp can be disconnected from the bike, which can be convenient if, for example, you want to store the bike. To disconnect the ramp: 1. Use the parking brake by pre...
Page 23
User manual veloplus3 17.12 22 5. Remove the safety pin. 6. Hold the rear part (tricycle part) with one hand and then use your other hand to pull the lever backwards [a], allowing the tricycle to detach. The wheelchair element will now stand on the support wheel. 7. Remove the bike apart from the co...
Page 24
User manual veloplus3 17.12 23 intergrated lighting contol the tricycle can be fitted with a different headlight. This lighting is connected to the electrical system. Adjust the angle of the headlamp. Make sure that the centre of the beam is approximately ten meters in front of the bike. The headlig...
Page 25
User manual veloplus3 17.12 24 technical details length (cm) 253 width (cm) 110 height (cm) 114 boarding height (cm) 28 length of inner leg (cm) 80 - 95 front wheel 20“ back wheel 26“ weight (kg) approx 64 max. Load luggage rack (kg) 20 max. Weight rider (kg) 110 max. Weight passenger incl. Wheelcha...
Page 26
User manual veloplus3 17.12 25 in the event of technical trouble or faults, the tricycle should be taken to the dealer for repairs immediately . The replacing of safety-related components (especially frame, brakes, lighting, handlebars, front fork and actuation) should be performed by the dealer. If...
Page 27
User manual veloplus3 17.12 26 adjustments by dealer the correct tension of the chains several chains are present on the tricycle these must have enough room for movement. Without any real effort, the chain must be able to be moved about half a centimetre up and down. In order to keep tension on the...
Page 28
User manual veloplus3 17.12 27 disposal if you want to dispose your tricycle, contact your dealer. You can also contact the local waste disposal company. They will dispose the tricycle according to the regulations of your town. Handover/sale to a new owner when you hand over your tricycle to a new o...
Page 29
User manual veloplus3 17.12 28 frame number the frame number is printed on the sticker. This sticker is located on the frame, see the image below. Example sticker: position of sticker: behind the seat tube.
Page 30
User manual veloplus3 17.12 29 form service, maintenance, modifications and guarantee claims to maintain guarantee on the van raam tricycle, follow this service schedule. Service: carried out (date): signature dealer: service after the first 200 km or two months. Service 1 year after delivery. Servi...
Page 31
User manual veloplus3 17.12 30 here you have space to take notes or write down the maintenance on your bike:.
Page 32
User manual veloplus3 17.12 31 here you have space to take notes or write down the maintenance on your bike:.
Page 33
User manual veloplus3 17.12 32 here you have space to take notes or write down the maintenance on your bike:.
Page 34: Delivery And Service Form
User manual veloplus3 17.12 33 delivery and service form congratulations on your purchase of your van raam tricycle. This bike is produced with utmost care. To guarantee the quality as much as possible van raam produces the cycles according to the iso 9001: 2008 quality standards. Van raam has been ...