- DL manuals
- Vari
- Engine
- xp-200
- User Manual
Vari xp-200 User Manual
Summary of xp-200
Page 1
Four stroke gasoline engine vari xp-200 user manual en english – original user manual for the original engine type zongshen xp200 (1p70f/p-h).
Page 3
Vari xp-200 content 1 basic notice 4 2 general information 4 3 components & principle 5 3.1 configuration..................................................................................5 3.1.1 fuel switch...........................................................................6 3.1.2 primer........
Page 4
Vari xp-200 1 basic notice read this manual carefully before operation. All rights reserved. Copy or transcribe this manual or any part of this manual is strict prohibited without written authorization. Please pay attention to the following safety labels that indicates personal safety is required. T...
Page 5
Vari xp-200 3 components & principle 3.1 configuration 1 starter 2 starter grip (only model with recoil startre) 3 fuel tank cap 4 fuel tank 5 oil drain plug 6 oil filler cap/dipstick 7 elektric starter (only model with el. Starter) 8 muffler 9 spark plug 10 cylinder head cover 11 air filter 12 thro...
Page 6
Vari xp-200 3.1.1 fuel switch the fuel switch the passage between the fuel tank and the carburetor. The fuel switch must be in the on position for the engine to run. When the engine is not in use, leave the fuel switch in the off position to prevent carburetor flooding and to reduce the possibility ...
Page 7
Vari xp-200 3.1.4 brake flywheel brake flywheel off the engine. In order to start the engine, the lever must brake the flywheel in position 1 . To stop the engine must be the flywheel brake lever in position 2 . 3.1.5 recoil starter grip pulling the starter grip operates the recoil starter to crank ...
Page 8
Vari xp-200 3.4 specifications of the engine description unit value engine type - xp200 (1p70f/p-h) bore x stroke mm 70 x 51 displacement cm 3 196 zapalovací systém - tranzistor magneto ignition system - recoil starter maximum outout power/speed kw/min -1 3,6/3800 maximum torque/speed nm/min -1 10/3...
Page 9
Vari xp-200 4.1.3 check the equipment powered by this engine review the instructions provided with the equipment powered by this engine for any precautions and procedures that should be followed before engine startup. 4.2 operation safe operating precautions safety operating the engine for the first...
Page 10
Vari xp-200 to help you properly care for your engine, the following pages include a maintenance schedule, routine inspection procedures, and simple maintenance procedures using basic hand tools. Other service tasks that are more difficult, or require special tools, are best handled by professionals...
Page 11
Vari xp-200 5.4 fuel 5.4.1 refueling fuel tank capacity: 1,3 l with the engine stopped, remove the fuel tank cap and check the fuel level, refill the tank if the fuel level is low. Gasoline is highly flammable and explosive you can be burned or seriously injured when handling fuel. • stop the engine...
Page 12
Vari xp-200 1 oil dipstick 2 lower oil level 3 upper oil level 4 oildrain 5.5.2 engine oil change drain the used oil while the engine is warm, warm oil drains quickly and completely. • place a suitable container below the engine to catch the used oil, then remove the filler cap/dipstick and the drai...
Page 13
Vari xp-200 5.6.2 air filter inspection 1 gasked plate 2 air filter base 3 foam filter element 4 air filter cover remove the air cleaner cover and inspect the filter, clean or replace dirty filter elements, always replace damaged filter elements, if equipped with an oil-bath air cleaner, also check ...
Page 14
Vari xp-200 5.6.5 spark plug service recommended spark plugs: f6rtc and f7rtc note: an incorrect spark plug can cause engine damage. Special spark plug wrench is provided and should be use • disconnect the spark plug cap, and remove any dirt from around the spark plug area. • remove the spark plug w...
Page 15
Vari xp-200 • turn the twos nut 1 from the exhaust deflector. • remove the muffler protector 2 . • remove the spark arrester 4 from the muffler 3 . Use a brush to remove carbon deposits from the spark arrester screen, be careful to avoid damaging the screen. Notice: the spark arrester must be free o...
Page 16
Vari xp-200 6.3 draining the fuel tank and carburetor • place an approved gasoline container below the carburetor, and use a funnel to avoid spilling fuel. • remove the carburetor drain bolt and sediment cup, them move the fuel valve lever to the on position - see chapter 3.1.1 • after all the fuel ...
Page 17
Vari xp-200 6.6 transporting if the engine has been running , allow it to cool for at least 15 minutes before loading the engine-powered equipment on the transport vehicle. A hot engine and exhaust system can burn you and can ignite some materials. Keep the engine level when transporting to reduce t...
Page 18
Vari xp-200 8.3 oxygenated fuels some conventional gasoline are being blended with alcohol or an ether compound, these gasoline are collectively referred to as oxygenated fuels, to meet clean air standard, some areas use oxygenated fuels to help reduce emissions. If you use an oxygenated fuel, be su...
Page 19
Vari xp-200 8.5.1.1 valve lash adjustment intake: 0,1-0,15 mm, exhaust: 0,15-0,2 mm. • grasp adjust nut 3 and release lock nut 4 . • turn adjust nut 3 to specified lash. • grasp adjust nut 3 and screw down lock nut 4 (torque 9-12 n.M). • after screw down lock, recheck valve gap. Unscrew adjust nut t...
Page 20
Vari xp-200 9 mounting dimensions 10 manufacturer's address on the back cover of the manual. 11 warranty dear consumer: thank you for choose the engine, the company must warranty following service upon you provide the receipts and warranty card. 11.1 subject of the warranty • the warranty period is ...
Page 21
Vari xp-200 12 declaration of incorporation ec declaration of incorporation name of manufacturer: chongqing zongshen general power machine co., ltd. Address of manufacturer : zongshen industrial zone, ba’nan district, chongqing 400054, p.R. China in accordance with the following directive: 2006/42/e...
Page 22
Vari xp-200 22 r ev is io n 1 2 /2 0 1 3 chongqing zongshen general power machine co.,ltd adresa: zongshen industry zone, ba nan district, chongqing 400054, p.R. China telefon: 023-66372578 fax: 023-66372566 hot line: 4007003088 023-66372519 standard: q/zs 1184-2010 q/zs 1185-2010 q/zs 1004-2010 q/z...