1. DL manuals
  2. Variflex
  3. Fitness Equipment
  4. AirZone
  5. User Manual

Variflex AirZone User Manual - Frame Assembly

Manual is about: TRAMPOLINE

Summary of AirZone

  • Page 1

    Safety, use, placement, assembly, care, and maintenance materials enclosed. Warning! Read this manual and all materials furnished with your trampoline thoroughly before assembling and using this trampoline. Keep this manual so you can refer to it later. Not recommended for children under six years o...

  • Page 2: Warning:

    1 table of contents liability .......................................................................................................................1 initial warning ............................................................................................................1 installation instructio...

  • Page 3: Warning:

    2 • adequate overhead clearance is essential. A minimum of 24 ft from ground level is recommended. Provide clearance for wires, tree limbs, and other possible hazards. • lateral clearance is essential. Place the trampoline away from walls, structures, fences, and other play areas. Maintain a clear s...

  • Page 4: Warning:

    3 • do not attempt or allow somersaults. Landing on the head or neck can cause serious injury, paralysis, or death, even when landing in the middle of the bed. • do not allow more than one person on the trampoline. Use by more than one person at the same time can result in serious injuries. • keep o...

  • Page 5

    4 trampoline safety and accident prevention as in most recreational sport, participants may be injured. This section covers the most common accidents. Responsibilities of the supervisors and jumpers in accident prevention are also outlined. The following are reasons why accidents happen: • attemptin...

  • Page 6: Frame Assembly

    Set screw holes (facing up) plugged holes on this side only (facing down) 5 frame assembly refer to parts list for identification of parts. 1 connect two top rails together with set-screw. 2 align the holes, insert set-screw and tighten with provided screwdriver. 3 continue aligning the remaining te...

  • Page 7: Mat & Cover Assembly

    6 mat & cover assembly 12 lay jumping mat inside frame and attach a spring into one of the triangle rings on the mat. 13 attach spring with ring to frame. (warning) trampoline is under heavy tension, more effort may be required to attach springs to frame. Be careful not to pinch fingers or slip. Ser...

  • Page 8: Fundamental Bounces

    7 fundamental bounces standing bounce 1. Start in the center of bed, feet shoulder- width apart, arms at side, eyes on end of bed. 2. As you jump from trampoline, arms come up and forward, circling outward and back to side as you again contact bed. Bring feet together, toes pointed, in the air, feet...

  • Page 9

    8 back drop 1. Lie on your back on bed, spread your legs slightly and raise them about 45 degrees from the surface of the bed, raise your arms to corresponding angle, raise head and look at end of trampoline. This is your landing position. 2. Try cautiously from a low bounce, making sure you do not ...

  • Page 10: Parts List

    9 parts list top rail (12 identical pieces) u-shaped leg piece (6) leg extensions (12) jumping mat (1) frame cover (1) screws (37) screwdriver (1) trampoline safety tips placard (1) springs (96).

  • Page 11: 2 Year  Limited Warranty

    10 2 year limited warranty subject to the following limitations, in addition to any imposed by virtue of applicable law, variflex, inc. Warrants this airzone / ultraflex trampoline to be free of defects in material or workmanship for a period of two years from the date of original purchase. This war...