Vauxhall Cavalier Service And Repair Manual - Brake Fluid Level
Screenwash additives not only keep the
winscreen clean during foul weather, they also
prevent the washer system freezing in cold
weather - which is when you are likely to need
it most. Don’t top up using plain water as the
screenwash will become too diluted, and will
freeze during cold weather. On no account use
engine antifreeze in the washer system - this
could discolour or damage paintwork.
Warning:Brake hydraulic fluid
can harm your eyes and
damage painted surfaces, so
use extreme caution when
handling and pouring it.
l Do not use fluid that has been
standing open for some time, as it
absorbs moisture from the air
which can cause a dangerous loss
of braking effectiveness.
Safety first
l If the reservoir requires repeated topping-
up this is an indication of a fluid leak
somewhere in the system, which should be
investigated immediately.
l If a leak is suspected, the car should not be
driven until the braking system has been
checked. Never take any risks where brakes
are concerned.
Brake fluid level
0•13
Carefully add fluid avoiding spilling it on
surrounding paintwork. Use only the
specified hydraulic fluid; mixing different types
of fluid can cause damage to the system. After
filling to the correct level, refit the cap
securely, to prevent leaks and the entry of
foreign matter. Wipe off any spilt fluid.
When adding fluid, it’s a good idea to
inspect the reservoir. The system should
be drained and refilled if dirt is seen in the fluid
(see Chapter 9 for details).
The “MAX” and “MIN” marks are
indicated on the side of the reservoir. The
fluid level must be kept between the marks.
1
If topping-up is necessary, first wipe the
area around the filler cap with a clean rag
before removing the cap.
2
3
4
Screen washer fluid level
The windscreen washer fluid reservoir is
located in the rear left-hand corner of the
engine compartment. The washer level can be
seen through the reservoir body. If topping-up
is necessary, open the cap.
When topping-up the reservoir, add a
screenwash additive in the quantities
recommended on the bottle.
1
2
• Make sure that your car is
on level ground.
• The fluid level in the
master cylinder reservoir will
drop slightly as the brake pads wear
down, but the fluid level must never be
allowed to drop below the ‘MIN’ mark.
Weekly checks