1. DL manuals
  2. Veloteq
  3. Bicycle
  4. Cavalier-GT
  5. Owner's Manual

Veloteq Cavalier-GT Owner's Manual

Summary of Cavalier-GT

  • Page 1

    Veloteq owner manual 2008 veloteq corporation 2151 richmond avenue shepherd square houston, tx 77098 www.Veloteq.Com (713 524-1175 printed in china.

  • Page 2: Electric Bicycle Manual

    Veloteq owner manual 2008 p. 1 of 15 2/18/2008 veloteq 2008 electric bicycle owner manual forward to our customers, thank you for choosing veloteq as your alternate energy vehicle for recreation and local commuting. We specialize in the design and manufacture of electric bicycles that incorporate th...

  • Page 3

    Veloteq owner manual 2008 p. 2 of 15 2/18/2008 electric bicycle manual contents forward….……………………………………………………………………………...1 features and operation ........................................................................... 3 notice and warning: (pay particular attention to any text highlighted in red...

  • Page 4

    Veloteq owner manual 2008 p. 3 of 15 2/18/2008 features and operation veloteq electric bicycles are equipped with a brushless dc, pulse wave modulated, 3 -phase electric motor powered by four vrsl colloided, sealed lead acid mainte- nance-free batteries enclosed in a heavy duty polypropolene case wi...

  • Page 5

    Veloteq owner manual 2008 p. 4 of 15 2/18/2008 protect both the charger and the power supply unit against overcharging and does not require supervision. It may be used over an input range of 110v/60hz to 220v/50hz. And carry ccc, ce, and cul or ctuv safety certification. The charger, power supply, m...

  • Page 6

    Veloteq owner manual 2008 p. 5 of 15 2/18/2008 and other electrical components to be submerged resulting in short circuiting and failure of the electrical system. The vehicle weight range of veloteq electric bicycles is 132lbs (60kg) to 172lbs (78kg) depending on the model, with the psu installed. T...

  • Page 7

    Veloteq owner manual 2008 p. 6 of 15 2/18/2008 after insuring that the ignition key is removed, 1) connect the charger output plug to the input plug on the vehicle. 2) then connect the charger input plug to the ac electric source. The red indicator light will glow showing that the unit is properly a...

  • Page 8

    Veloteq owner manual 2008 p. 7 of 15 2/18/2008 wheel will spin freely without a brake damping effect. (see fig. 2) rear drum brake adjustment: to adjust the rear drum brake turn the adjustment screw located at the end of the brake line forward of the brake assembly as above, test the travel of the b...

  • Page 9

    Veloteq owner manual 2008 p. 8 of 15 2/18/2008  operational check: before riding, check that there is an adequate charge level available in the power supply. Recharge as required before using. The power supply unit must be installed in the psu well in the lower deck and locked securely in place. Se...

  • Page 10

    Veloteq owner manual 2008 p. 9 of 15 2/18/2008 the cavalier rsv-gt (500!-gt), challenger rsv-gt (500c-gt) , commander sho-gt (500d-gt) and commuter rsv-gt (500zx-gt), cougar xr8 (500xr) and sorrento-gt (500b-gt) are equipped with both a speedometer and an odometer. Parking your electric bicycle: whe...

  • Page 11

    Veloteq owner manual 2008 p. 10 of 15 2/18/2008 vice immediately. Pedal installation: insert the pedals in the pedal insertion holes as shown in the example below. The insertion hole is cut out at the factory. Take care to install the pedals cor- rectly as marked left and right to the pedal arm and ...

  • Page 12

    Veloteq owner manual 2008 p. 11 of 15 2/18/2008 troubleshooting guide number fault cause effect/repair 1 governor failure or unable to attain maxi- mum speed. 1. Battery voltage is too low. 2. Governor switch connec- tions are loose. 3. Governor spring catches or fails. 1. Battery level insufficient...

  • Page 13

    Veloteq owner manual 2008 p. 12 of 15 2/18/2008 product warranty for new vehicles in order to protect your warranty rights and privileges, retain a copy of your original sales receipt with your serial number and date of purchase. Verify that the vehicle has been properly prepared and in- spected for...

  • Page 14

    Veloteq owner manual 2008 p. 13 of 15 2/18/2008 quality control and after-sale warranty commitment. One year for vehicles sold in accordance with schedule 1, above, breakdown or failure due to manu- facturing defect in parts or materials, repair only by authorized dealers or warranty repair stations...

  • Page 15

    Veloteq owner manual 2008 p. 14 of 15 2/18/2008 owner record of service date location service performed note: it is a good idea to note when you have taken your electric bicycle out of seasonal service and in- sure that the power supply and charger are stored at above freezing temperatures. The powe...

  • Page 16

    Veloteq owner manual 2008 p. 15 of 15 2/18/2008 lube-injection auto-geared electric motor installation and oil maintenance gear oil replacement after the first 300km of use, subsequently replace the gear oil after every 3000km. Use approximately 150ml of no.26 universal gear oil, hq-10 lubricating o...