1. DL manuals
  2. Volvo
  3. GPS
  4. 2003 S60
  5. Manual

Volvo 2003 S60 Manual

Other manuals for 2003 S60: Wiring Diagram, Operating Manual

Summary of 2003 S60

  • Page 1

    2 0 0 3 volvo s60 introduction welcome to the world-wide family of volvo owners. We trust that you will enjoy many years of safe driving in your volvo, an automobile designed with your safety and comfort in mind. To help ensure your satisfaction with this vehicle, we encourage you to familiarize you...

  • Page 2

    Customer relations p.O. Box 914 rockleigh, new jersey 07647-0914 800-458-1552 in canada: volvo canada ltd. 175 gordon baker road north york, ontario m2h 2n7 800-663-8255 general information shiftlock (automatic transmission) when your car is parked, the gear selector is locked in the (p)ark position...

  • Page 3

    Volvo reserves the right to make model changes at any time, or to change specifications or design without notice and without incurring obligation. Warning! California proposition 65 warning! Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to t...

  • Page 4

    Reducing harmful ground-level ozone. Instruments, switches and controls page 1. Front fog lights 30 2. Headlights/parking lights/switch for unlocking fuel filler door 30 3. Rear fog light 30 4. Turn signals/high/low beams 32 5. Cruise control 36 6. Horn iv 7. Instrument panel 22 8. Audio controls in...

  • Page 5: Contents

    20. Odometer/ trip odometer/cruise control indicator 22 / 36 21. Speedometer 22 22. Turn signal indicators 22 23. Tachometer 22 24. Ambient temperature/clock/selected gear indicator 22 25. Fuel gauge 22 26. Indicator and warning symbols 23 27. - - 28. Panel vents 45 29. Instrument lighting 30 30. Li...

  • Page 7: 2 0 0 3

    2 0 0 3 volvo s60 safety pg. 1 safety seat belts 2 airbags (supplemental restraint system) 4 side airbags (sips airbags) 10 inflatable curtain (ic) 12 inspection of airbags, inflatable curtains and seat belt tensioners 13 whips 14 child safety 16 occupant safety, reporting safety defects 20 pg. 2 sa...

  • Page 8

    To buckle a seat belt: pull the belt out far enough to insert the latch plate into the receptacle until a distinct click is heard. The seat belt retractor is normally "unlocked" and you can move freely, provided that the shoulder belt is not pulled out too far. The retractor will lock up as follows:...

  • Page 9

    Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We also recommend that children who have outgrown these devices sit in the rear seat with the seat belt properly fastened. Sample label found on all seat belts with tensioners pg. 4 safety airbags (suppl...

  • Page 10

    Passenger side airbag the airbag on the front passenger side is folded up in a compartment above the glove compartment. The panel is embossed srs. Warning! No objects, accessory equipment or stickers may be placed on, attached to, or installed near the srs cover in the center of the steering wheel, ...

  • Page 11

    Note: deployment of srs components occurs only one time during an accident. In a collision where deployment occurs, the airbags and seat belt tensioners activate. Some noise occurs and a small amount of powder is released. The release of the powder may appear as smoke-like matter. This is a normal c...

  • Page 12

    Warning light in the instrument panel a self-diagnostic system incorporated in the sensor monitors the srs. This system does not, however, monitor the side impact protection system (sips) airbags. If a fault is detected, the warning light will illuminate. The light is included in the warning/indicat...

  • Page 13

    Supplement to the seat belts. Warning! Never drive with the airbags deployed. The fact that they hang out can impair the steering of your car. Other safety systems can also be damaged. The smoke and dust formed when the airbags are deployed can cause skin and eye irritation in the event of prolonged...

  • Page 14

    Front airbag (srs) system as an enhancement to the three-point seat belt system, your volvo is equipped with a supplemental restraint system (srs). The volvo srs consists of an airbag (2) on both the driver's and passenger's sides and seat belt tensioners in both front door pillars. The system is de...

  • Page 15

    Sips airbag* sips airbag (front seats only) as an enhancement to the structural side impact protection system built into your car, the car is also equipped with side impact protection system (sips) airbags. The sips airbag system consists of airbag modules built into the sides of both front seat bac...

  • Page 17: 2 0 0 3

    2 0 0 3 volvo s60 instruments and controls pg. 21 instruments and controls instrument panel 22 indicator and warning symbols 23 switches in the center console 27 steering wheel adjustment 29 lighting panel 30 manually unlocking the fuel filler door 31 turn signals 32 windshield wipers/washer 33 haza...

  • Page 18

    Coolant level - see page 121 . 4. Trip odometer the trip odometers are used for measuring shorter distances. The right-hand digit gives tenth of a mile/kilometer. Press the button for more than 2 seconds to reset. Change between trip odometers 1 and 2 using one short press on the button. 5. Odometer...

  • Page 19

    This symbol shines as a red or yellow light depending on the severity of the discovered fault. Red symbol - stop the car as soon as possible in a suitable location and read the message shown in the text window. Yellow symbol - follow the instructions shown in the text window. Anti-lock brake system ...

  • Page 20

    If the brake fluid level is above the min mark, drive carefully to an authorized volvo retailer and have the brake system inspected. Pg. 25 instruments and controls supplemental restraint system srs if the light comes on (or stays on after the vehicle has started), the srs diagnostic system has dete...

  • Page 21

    Messages in the text window when a warning light in the instrument panel comes on, a message is also displayed in the text window. After you have read the message, you can erase it by pressing button a (see illustration). Note: certain messages cannot be erased until the condition has been corrected...

  • Page 22

    This button is used to fold down the outboard rear head restraints. The ignition key must be in position i or ii or the engine must be running. Note: if the head restraints have been folded down, they must be returned to their original position manually. The head restraints should be in the upright ...

  • Page 23: Steering Wheel Adjustment

    This 12 volt socket can be used to plug in certain accessories such as cellular telephones, etc. The ignition key must be in position 1 (or higher) for the auxiliary socket to function. Note: the auxiliary sockets can also be used for cigarette lighters, which are available at your volvo retailer. P...

  • Page 24

    Headlights, parking lights, license plate lights and instrument panel illumination are on if the ignition key is in position ii. If the headlight switch is in this position, all lights will go out when the ignition is switched off. The headlight switch must be in this position before the high beams ...

  • Page 25: Turn Signals

    Pg. 31 instruments and controls manually unlocking the fuel filler door manually unlocking the fuel filler door note: cotton gloves are available in the tool kit located in the spare wheel well. The electric motor that controls the fuel filler door locking mechanism is located on the inside of the r...

  • Page 26: Windshield Wipers/washer

    3. Exterior courtesy lights home safe system when you leave your car at night, you can make use of the courtesy lighting function: remove the key from the ignition switch. Pull the direction indicator lever towards the steering wheel (as when using the headlight flasher function). Exit the car and l...

  • Page 27: Front Seats

    When washing the car in an automatic car wash, etc move the windshield wiper lever to position 0 or switch off the ignition completely to deactivate the rain sensor. If the sensor function is left on, the wipers will start inadvertently in the car wash and could be damaged. Wipers operate at "normal...

  • Page 28: Trip Computer (Option)

    The front seat heating can be switched on and off as required. Press the switch once for maximum seat heating. Both leds in the switch will be lit. Press the switch a second time for comfort heating. One led in the switch will be lit. Press the switch a third time to turn the heating off completely....

  • Page 29: Cruise Control

    4. Average speed this value indicates average speed since the last time the trip computer was reset (by pressing reset, button c). When the engine is switched off, information on average speed is stored and remains in system memory until the reset (button c) is pressed again. 5. Current speed in mil...

  • Page 30

    Note: cruise control is automatically disengaged if the engine is switched off, if the gear selector is placed in (n)eutral, if the car's speed drops to under 70% of the currently set speed or if the wheels start to spin. Temporarily disengaging cruise control press 0 to temporarily disengage cruise...

  • Page 31

    Auxiliary sockets these 12 volt sockets can be used to plug in certain accessories such as cellular telephones, etc. The key must be in position i (or higher) for the auxiliary socket to function. The auxiliary sockets can also be used for cigarette lighters, which are available at your volvo retail...

  • Page 32

    Make sure that childrens' hands are clear before raising the windows. Never leave children unattended in the car. Cutout switch for rear windows cutout switch for rear windows the electrically operated rear door windows can be disabled by a switch located on the driver's door (see illustration). If ...

  • Page 33

    Rearview mirror/sideview mirrors rearview mirror a normal position b night position, reduces glare from following headlights autodim function (option) the autodim function reacts to headlights from following traffic and automatically reduces glare. Note: this function is automatically switched off w...

  • Page 34

    Not function if you lock your car with the key. Pg. 41 instruments and controls electrically operated sun roof (option) electrically operated sun roof to operate the sun roof, the ignition key must first be turned to the intermediate or drive position (position i, ii or the engine running). To slide...

  • Page 35

    Caution: remove ice and snow before opening the sun roof. Do not operate the sun roof if it is frozen closed. Never place heavy objects on the sun roof. Pg. 42 instruments and controls electrically operated sun roof (option) (contd) sun visor: the optional sun roof also features a sliding sun visor....

  • Page 36: 2 0 0 3

    2 0 0 3 volvo s60 climate control pg. 43 climate control climate control systems - general information 44 air distribution 45 electronic climate control, ecc (2.4t and t5) 46 manual climate control with air conditioning, (a/c) 50 pg. 44 climate control climate control systems - general information c...

  • Page 37: Air Distribution

    All maintenance on the climate control systems should be carried out by an authorized volvo service technician only. Refrigerant volvo cares about the environment. The air conditioning system in your car contains a cfc-free refrigerant - r134a. This substance will not deplete the ozone layer. The sy...

  • Page 38

    B closed c horizontal air flow d vertical air flow direct the outer air vents toward the side windows to defrost. In cold weather, close the air vents in the center of the dash to direct as much air as possible toward the windows. Pg. 46 climate control electronic climate control, ecc (2.4t and t5) ...

  • Page 39

    Please note that the compartment will not be heated or cooled faster by setting the temperature higher or lower than necessary. Set the control to the temperature you prefer. Defroster this function defrosts/ de-ices the windshield and front side windows. The led in the switch will light up to indic...

  • Page 40

    You have manually switched the air conditioning off. This will only function if the blower is not switched off. Recirculation press this switch to engage the recirculation function (air in the passenger compartment recirculates - no fresh air enters the compartment). The led in the switch will light...

  • Page 41

    2. No led lights. Recirculation is not activated unless needed to cool the passenger compartment in a warm climate. 3. The man led lights. Recirculation is now activated. Keep in mind the following: make it a rule to have the air quality sensor activated at all times. Recirculation is limited in col...

  • Page 42

    Blower blower speed can be increased or decreased by turning the knob. If the knob is set to 0, the air conditioning function is automatically disengaged. Temperature turn the control to set the temperature for the driver's and passenger's sides of the car. For cooler air, the air conditioning funct...

  • Page 44: 2 0 0 3

    2 0 0 3 volvo s60 interior pg. 53 interior front seats 54 interior lighting 58 floor mats 59 storage compartments 60 rear seat and trunk 63 spare wheel and tools 65 pg. 54 interior front seats manual height adjustment - front seat the front edges of the driver and passenger seat cushions can be adju...

  • Page 45: Front Seats (Contd)

    Pg. 55 interior folding the backrests in the front seat the front passenger seat backrest can be folded to a horizontal position to make room for a long load. Fold the backrest as follows: move the seat as far back as possible. Adjust the backrest to the upright position. Lift the catches on the rea...

  • Page 46

    1. Within 40 seconds of the ignition key being turned to position 0 or removed from the ignition switch. 2. After you have unlocked the driver's door with the key or remote control, the driver's seat can be adjusted during a 10 minute period if the door remains open. If the door is closed, the seat ...

  • Page 47: Interior Lighting

    Because the driver's seat can be adjusted with the ignition off, children should never be left unattended in the car. Movement of the seat can be stopped at any time by pressing any button on the power seat control panel. Do not adjust the seat while driving. The seat should be adjusted so that the ...

  • Page 48

    You unlock the car from the outside with the key or remote control. You switch off the ignition (turn the key to position 0). The courtesy light stays on for 10 minutes if one of the doors is left open after the car is unlocked. The courtesy light switches off if: the engine is started. The car is l...

  • Page 49

    The light comes on when you open the cover. Floor mats volvo offers floor mats specially manufactured for your car. They must be properly placed and secured in the mat clips. Warning! An extra mat on the driver's floor can cause the accelerator pedal to catch. Check that the movement of the accelera...

  • Page 50: 2 0 0 3

    2 0 0 3 volvo s60 locks and alarm pg. 67 locks and alarm keys and remote controls 68 locking and unlocking 71 child safety lock 74 alarm 75 pg. 68 locks and alarm keys and remote controls keys two keys are provided with your car; a master key and a service (valet) key. The master key, the remote con...

  • Page 51

    Use the switch on the driver's door armrest to lock/unlock the car from the inside. Warning! If the doors are locked while driving, this may hinder rapid access to the occupants of the car in the event of an accident. (also see information on "child safety locks") note: to help prevent accidentally ...

  • Page 52

    Using the remote control press the lock button once to lock all doors and trunk. Press the unlock button once to unlock the driver's door and fuel filler door. Wait for at least 1 second and press this button again (within 10 seconds) to unlock all doors and the trunk. To pop open the trunk (without...

  • Page 53: Locking And Unlocking

    Doing so would activate: the break-in alarm, which would sound if one of the doors were opened the optional interior motion and inclination alarm sensors. Doing so would deactivate: the sunroof and interior courtesy light controls. The central locking buttons on the front door armrests, although the...

  • Page 54

    Locking and unlocking the car from the inside the switch on the driver's door armrest can be used to lock or unlock all doors and the trunk, and to set the alarm. Pg. 72 locks and alarm locking and unlocking (contd) opening/locking the trunk lid with the remote control do as follows to unlock the tr...

  • Page 55: Child Safety Lock

    Pg. 73 locks and alarm warning! Keep vehicle doors and trunk locked and keep keys out of a child's reach. Unsupervised children could lock themselves in an open trunk and risk injury. Children should be taught not to play in vehicles. On hot days, the temperature in the trunk or vehicle interior can...

  • Page 56: Alarm

    Buttons in position a pg. 75 locks and alarm alarm alarm the alarm is automatically armed whenever you lock your car. When armed, the alarm continuously monitors a number of points on the car. The following conditions will set off the alarm: the hood is forced open. The trunk is forced open. A door ...

  • Page 57

    Temporarily turning off the alarm sensor( s) - option this button will only be found in cars equipped with the optional inclination and/or movement sensors. In certain situations it may be desirable to turn off the optional inclination and movement alarm sensors if, for example, you drive your car o...

  • Page 58: 2 0 0 3

    2 0 0 3 volvo s60 starting and driving pg. 77 starting and driving refueling 78 starting the car 81 general information 83 manual transmission 85 automatic transmission (option) 86 geartronic (option) 88 all wheel drive (option) 90 brake system 91 stability system 93 towing 95 jump starting 97 towin...

  • Page 59

    Fuel economy. If you are not sure whether the gasoline contains deposit control additives, check with the service station operator. Note: volvo does not recommend the use of external fuel injector cleaning systems. Unleaded fuel each volvo has a three-way catalytic converter and must use only unlead...

  • Page 60: Refueling (Contd)

    Additives contain organically volatile chemicals. Do not needlessly expose yourself to these chemicals. Pg. 80 starting and driving refueling (contd) fuel filler door press the button on the light switch panel (see illustration on page 30 ) when the car is at a standstill to unlock the fuel filler d...

  • Page 61: Starting The Car

    Do not use gasolines containing methanol (methyl alcohol, wood alcohol). This practice can result in vehicle performance deterioration and can damage critical parts in the fuel system. Such damage may not be covered under the new vehicle limited warranty. * if the fuel filler cap is not closed tight...

  • Page 62: Starting The Car (Contd)

    Warning! Always place the gear selector in park and apply the parking brake before leaving the vehicle. Never leave the car unattended with the engine running. Always open garage doors fully before starting the engine inside a garage to ensure adequate ventilation. The exhaust gases contain carbon m...

  • Page 63: General Information

    Steering wheel lock the steering wheel lock might be under tension when the car is parked. Turn the steering wheel slightly to free the ignition key. In order to help reduce car theft, make sure the steering wheel lock is engaged before leaving the car. * the gear selector must be in the (p)ark posi...

  • Page 64: Manual Transmission

    Caution: drive slowly and carefully if going through standing water (i.E. Flooded roadways, etc.). Damage to the engine could result if excess water is drawn in through the air intake system. Never drive the vehicle in water deeper than 1 foot (300 mm). Weight distribution affects handling at the sp...

  • Page 65

    Engaging reverse gear reverse gear should only be engaged from a complete stop. Caution: be careful to avoid inadvertently engaging reverse while moving forward. "sport shifter" gear selector (option on t5 models) the shift positions for the "sport shifter" are the same as for the standard manual ge...

  • Page 66

    The gear selector is mechanically locked in the p position (shiftlock). To release the gear selector from this position, the engine must be running (or the ignition key must be in position ii) and the brake pedal must be depressed. Warning! Never leave the car unattended when the engine is running. ...

  • Page 67: Geartronic (Option)

    Mode w will only function if the gear selector is in the (d)rive position. Press the button at the base of the gear selector to engage/disengage this driving mode (see illustration). When the w driving mode is engaged, this is displayed in the instrument panel (see page 22 ). This mode may be select...

  • Page 68

    P park use this position when starting the engine or parking the car. Never use p while the car is in motion. The parking brake should also be set whenever the car is parked. The gear selector is mechanically locked in the p position (shiftlock). To release the gear selector from this position, the ...

  • Page 69: All Wheel Drive (Option)

    You can move the gear selector freely between the (man)ual and (d)rive positions while driving. Gears 3, and 4 have a "lock-up" function which reduces engine speed and helps save fuel. The currently selected gear will be displayed in the instrument panel (see page 22 ). To access the (man)ual shifti...

  • Page 70: Brake System

    Your volvo can be equipped with permanent all wheel drive, which means that power is distributed automatically between the front and rear wheels. Under normal driving conditions, most engine's power is directed to the front wheels. However, if there is any tendency for the front wheels to spin, an e...

  • Page 71: Brake System (Contd)

    If the power brakes are not working, the brake pedal must be pressed approximately four times harder than usual to make up for the lack of power assistance. This can happen for example when towing your vehicle or if the engine is switched off when the vehicle is rolling. The brake pedal feels harder...

  • Page 73: 2 0 0 3

    2 0 0 3 volvo s60 wheels and tires pg. 105 wheels and tires general information 106 tire pressure 108 tread wear indicators 109 changing wheels 110 uniform tire quality grading 112 pg. 106 wheels and tires general information general information about wheels and tires your vehicle is equipped with t...

  • Page 74

    New tires remember that tires are perishable goods. This tire was manufactured week 15 in 1998! (158). As of 2000, manufacturing year and week will be indicated with 4 digits (e.G. 0015 means that the tire is manufactured year 2000, week 15). Improving tire economy: maintain correct tire pressure. S...

  • Page 75: Tire Pressure

    The handling of the vehicle can be adversely affected when driving with chains. Avoid fast or sharp turns as well as locked wheel braking. Snow tires, studded tires * tires for winter use: owners who live in or regularly commute through areas with sustained periods of snow or icy driving conditions ...

  • Page 76: Tread Wear Indicators

    Vehicle loading the tires on your volvo will perform to specifications at all normal loads when inflated as recommended on the tire information label located on the inside of the fuel filler door. This label lists both tire and vehicle design limits. Do not load your car beyond the load limits indic...

  • Page 77: Changing Wheels

    Vehicle. Pg. 110 wheels and tires changing wheels insert flat end of lug wrench and turn/pull straight out changing wheels the spare wheel is located under the carpet on the trunk floor. The jack and crank are secured in the wheel recess. There are two jack attachment points on each side of the car ...

  • Page 78

    Attaching the jack position the jack correctly on the bar in the attachment (see illustration above) and crank while simultaneously guiding the base of the jack to the ground. The base of the jack must be flat on a level, firm, non-slippery surface. Before raising the car, check that the jack is sti...

  • Page 79

    Pg. 112 wheels and tires uniform tire quality grading all passenger car tires must conform to federal safety requirements in addition to these grades quality grades can be found, where applicable, on the tire sidewall between the tread shoulder and maximum section width. For example: treadwear 200 t...

  • Page 80: 2 0 0 3

    2 0 0 3 volvo s60 car care pg. 113 car care washing and cleaning the car 114 paint touch up 116 pg. 114 car care washing and cleaning the car the car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the paint and may cause damage. It is particularly important t...

  • Page 81

    Bumpers: wash the bumpers with the same cleaning agent used on the rest of the car. Never clean the bumpers with gasoline or paint thinner. Difficult spots can be removed with denatured alcohol. To avoid scratches, do not dry the bumpers with paper. Note: when washing the car, remember to remove dir...

  • Page 82: Paint Touch Up

    Cleaning floor mats the floor mats should be vacuumed or brushed clean regularly, especially during winter when they should be taken out for drying. Spots on textile mats can be removed with a mild detergent. Bear in mind take extra care when removing stains such as ink or lipstick since the colorin...

  • Page 84: 2 0 0 3

    2 0 0 3 volvo s60 maintenance and service pg. 117 volvo service 118 working on your car 120 hood and engine compartment 122 oils and fluids 123 wiper blades 127 battery 128 bulbs 131 fuses 138 pg. 118 maintenance and service volvo service maintenance service volvo advises you to follow the service p...

  • Page 85

    New car limited warranty parts and accessories limited warranty corrosion protection limited warranty seat belt and supplemental restraint systems limited warranty emission design and defect warranty emission performance warranty these are the federal warranties; other warranties are provided as req...

  • Page 86: Working On Your Car

    Working on your car note the following before you begin working on your car: battery ensure that the battery cables are correctly connected and tightened. Never disconnect the battery when the engine is running (e.G. When replacing the battery). Never use a fast charger to charge the battery. The ba...

  • Page 87

    Pg. 121 maintenance and service belt check check the belt regularly to make sure it is in good condition and is clean. A worn or dirty belt can cause poor cooling and low alternator output as well as impair the operation of the power steering and the air conditioning unit. Note: the drive belt is eq...

  • Page 88: Oils And Fluids

    Opening the hood pull the lever located under the left side of the dash to release the hood lock. Lift the hood slightly. Press up the release control located under the front edge of the hood (at the center) and lift. Warning! Check that the hood locks properly when closed! Engine compartment 1. Exp...

  • Page 89

    Engine protection. Volvo cars recommends castrol. Depending on your driving habits, premium or synthetic oils may provide superior fuel economy and engine protection. Consult your volvo retailer for recommendations on premium or synthetic oils. Oil additives must not be used. Note: synthetic oil is ...

  • Page 90: Oils And Fluids (Contd)

    Oils and fluids (contd) checking the oil level the oil level should be checked every time the car is refueled. This is especially important during the period up to the first service. Caution: not checking the oil level regularly can result in serious engine damage if the oil level becomes too low. P...

  • Page 91: Oils And Fluids (Contd)

    During cold weather, the reservoir should be filled with windshield washer solvent containing antifreeze. Coolant reservoir changing coolant normally, the coolant does not need to be changed. If the system must be drained, consult your volvo retailer. Note: do not top off with water only. This reduc...

  • Page 92

    The clutch and brake fluid should always be above the min mark on the side of the reservoir. Check, without removing the cap, that there is sufficient fluid in the reservoir. Fluid type: dot 4+ boiling point > 536° f (280° c), p/n 9437433 replace: every second year or 30,000 miles (48,000 km). The f...

  • Page 93: 2 0 0 3

    2 0 0 3 volvo s60 specifications pg. 143 specifications label information 144 dimensions, weights 145 capacities 147 lubricants 148 cooling system 148 three way catalytic converter 149 suspension 150 bulbs 151 electrical system 152 engine specifications 153 transmission 154 pg. 144 specifications la...

  • Page 94: Dimensions, Weights

    7 child safety latch label *the vehicle identification number (vin) should always be quoted in all correspondence concerning your vehicle with the retailer and when ordering parts. Pg. 145 specifications dimensions, weights dimensions length 180 in. (458 cm) width 71 in. (180 cm) height 56.2 in. (14...

  • Page 95

    5 cyl. Turbo (manual transmission) usa 4430 lbs canada 2010 kg 5 cyl. Turbo (automatic transmission) usa 4470 lbs canada 2030 kg 5 cyl. Turbo (automatic transmission) awd usa 4540 lbs canada 2060 kg capacity weight 5 cyl./5 cyl. Turbo usa 890 lbs canada 400 kg 5 cyl. Turbo awd usa 860 lbs canada 390...

  • Page 96: Dimensions, Weights

    5 cyl. Turbo awd usa 3535- 3570 lbs canada 1605- 1625 kg * permissible axle weight or gross vehicle weight must never be exceeded. Pg. 146 specifications dimensions, weights max. Loads, max. Roof load 220 lbs 100 kg max. Trailer weight without brakes 1100 lbs (500 kg) with brakes 2" ball 3300 lbs (1...

  • Page 97: Lubricants

    * 19 us gals (72 liters) on models equipped with all wheel drive. Minimum octane requirement - aki 87 (ron 91) unleaded fuel (see also page 78 ) pg. 148 specifications lubricants engine oil meeting minimum ilsac specification gf- 2, including acea a1, api sj, sj/ cf and sj/energy conserving. Volvo d...

  • Page 98: Bulbs

    Way catalytic converter or exhaust system overheating. Remember that tampering or unauthorized modifications to the engine, the electronic control module, or the vehicle may be illegal and can cause three-way catalytic converter or exhaust system overheating. This includes: - altering fuel injection...

  • Page 99: Electrical System

    Individual rear wheel suspension with longitudinal support arms, double link arms and track rods. Front suspension spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Power-assisted rack and pinion steering. Safety type steering column. Pg. 152 speci...

  • Page 100: Transmission

    Stroke (mm) 90 90 90 93.2 cylinder displacement,1 2.44 (148.6 cu. In.) 2.3 (141.5 cu. In.) 2.44 (148.6 cu. In.) 2.52 (153.8 cu. In.) compression ratio 10.3:1 8.5:1 9.0:1 9.0:1 charge air cooler (intercooler) turbocharged engines employ a turbo-compressor to force air into the engine inlet manifold a...

  • Page 101: 2 0 0 3

    2 0 0 3 volvo s60 audio pg. 157 audio audio system hu-613 - overview 158 audio system hu-803 - overview 159 audio systems hu-613/hu-803 160 program types (hu-803 only) 165 aum (advanced user mode) 166 audio system hu-613 - cassette deck 167 audio system hu-613/hu-803 - cd player 169 audio system hu-...

  • Page 102

    Cd changer (option) 4. Fader - press and turn balance - press, pull and turn 5. Radio - station seek up/down cassette - selecting next/previous track cd - selecting next/previous track 6. Radio - manual station selection cassette - fast winding forward/backward cd - fast forwards/backward 7. Cd ejec...

  • Page 103

    Station scan - press external cd changer (option) 7. Radio - station seek up/down cd - selecting next/previous track 8. Radio - manual station selection cd - fast forward/backward 9. Cd eject 10. Dolby pro logic - switching on 11. 2 channel stereo 12. 3 channel stereo 13. Cd slot 14. Cd random play ...

  • Page 104

    The advanced user mode on the hu-803 equipped with this feature. "asc on" or "asc off" will be shown in the display for several seconds. Bass adjust the bass by pressing the button to extend the control and turning it to the left (less bass) or to the right (more bass). A "detent" indicates "equaliz...

  • Page 105

    Seeks the next audible station and tunes it in. Repeat the procedure to continue the seek function. Pg. 162 audio audio systems hu-613/hu-803 (contd) station setting press the left button to select a lower frequency and the right button for a higher frequency. The set frequency is shown in the displ...

  • Page 106

    Another auto-stored station is selected with each turn. Programming stations 1. Tune in the desired frequency. 2. Press the "1-20/disc" knob. Select a number by turning forwards or backwards. Press again to store the selected frequency and station. Preset to choose a pre-set station, turn "1-20/disc...

  • Page 107

    If only tp is displayed, it means that no traffic information is being broadcast from the current transmitter. If you do not wish to listen to an ongoing traffic bulletin, press the tp button. The tp function, however, is still connected and the radio waits for the next traffic bulletin. Press the t...

  • Page 108

    Program type - hu-803 only the pty function enables you to select specific types of programs. To search for a particular program type: 1. Press "pty" button to initiate the function. The currently tuned station's program type is displayed. 2. Scroll through the list of program types by turning the "...

  • Page 109: 2 0 0 3

    2 0 0 3 volvo s60 index pg. 207 index a a/c (air conditioning) 48 , 51 abs 11 , 23 , 92 accessory bracket 62 adjustable steering wheel 29 advanced user mode (aum) - radio 166 air bags - dual threshold/stage 5 air distribution 45 , 48 , 52 air quality sensor 49 air vents 45 airbag - side impact (sips...

  • Page 110

    B back up light 135 backrest 63 bass 160 battery 120 , 128 , 152 battery - replacing 129 belt check 121 blower (fan) 47 , 51 booster cushion 16 brake circuit 91 brake fluid 126 brake light 135 brake system 23 , 91 bulbs 131 , 150 c capacities 147 carbon monoxide - important warning 79 cargo compartm...

  • Page 111

    Cruise control 36 cup holder 61 cup holder in rear seat 61 current fuel consumption 35 d defroster 47 dimension designation (tires) 106 direction indicator 135 direction indicators 32 dolby surround pro logic 172 door mirror defroster 34 door mirrors 27 driving economically 83 dstc 28 dual- threshol...

  • Page 112

    Fuel gauge 22 fuel tank, capacity 147 fuses 138 g gasoline 78 gear position 85 geartronic 88 geartronic - kickdown 89 geartronic - manual shifting 89 general information ii generator 152 generator warning light 25 glove compartment 62 grocery bag holder 64 h handling 84 hazard warning flashers 34 he...

  • Page 113

    J jack 65 , 111 jump starting 97 k keylock ii , 81 keys 68 kickdown 87 l led illumination 32 lighting panel 30 load carriers 102 locking 71 locking steering wheel 82 locks 67 long distance trips 104 long loads - carrying 64 low beam bulb 132 lubricants 148 m maintenance schedule 118 malfunction indi...

  • Page 114

    Power seat 56 power steering fluid 126 power sun roof 41 premair iii programme type pt 165 proposition 65 warning 97 r radiator 122 radio 160 rain sensor 33 rain sensor - windshield wipers 33 reading lamps 58 rear fog lights 30 rear seat 63 rear suspension 151 rear window defroster 34 , 51 rearview ...

  • Page 115

    Snow chains 107 snow tires 107 spare tires 108 spare wheel 65 spark plugs 152 specifications 143 speedometer 22 spoiler lamps 30 sport shifter 85 srs 4 stability system 93 stability systems 93 stability traction control (stc) 93 start inhibitor (immobilizer) 68 starting the car 81 stc 27 steering 82...

  • Page 116

    Trailer indicator lamp 25 trailer towing 98 transmission - automatic 86 transmission - geartronic 88 transmission - manual 85 transmission - sport shifter 85 trip computer 35 trip odometer 22 trunk - opening from the inside 72 trunk - unlocking 72 turn signals - normal turns 32 turn signals - lane c...

  • Page 118: 2 0 0 3

    2 0 0 3 volvo s60 back cover back cover accessory installation - important warning we strongly recommend that volvo owners install only genuine, volvo-approved accessories, and that accessory installations be performed only by the factory-trained technicians at your authorized volvo retailer. Genuin...

  • Page 119

    The following should be checked regularly: * 1 washer fluid reservoir should be filled with water and solvent (wintertime: windshield washer anti-freeze). See page 125. 2 power steering- when cold, the level must not be above the cold mark and when hot it must not be above the hot mark. Top up if th...

  • Page 120

    Bulb no. Name designation/power 1 direction indicator/parking light py 21 w 2 low beam h7 55 w 3 high beam hb3 55 w 4 fog light (option) h1 55w 5 fog light ba 5s 21 w 6 tail/parking light ba 15s 5 w 7 brake light ba 15s 21 w 8 side marker light p 10 w 9 direction indicator py 21 w 10 backup light ba...