1. DL manuals
  2. Volvo
  3. Other
  4. S80 -
  5. Operation Manual

Volvo S80 - Operation Manual

Summary of S80 -

  • Page 2: Contents

    2005 volvo s80 driving in your volvo, an automobile designed with your safety and comfort in mind. To help ensure your satisfaction with this vehicle, we encourage you to familiarize yourself with the equipment descriptions, operating instructions and maintenance requirements/recommendations in this...

  • Page 3

    2005 volvo s80 chapter 9 - specifications chapter 10 - audio systems homelink® universal transceiver (option) index back cover © 2004 volvo cars of north america llc. General information shiftlock when your car is parked, the gear selector is locked in the (p)ark position. To release the selector fr...

  • Page 4

    2005 volvo s80 warning! If your vehicle is involved in an accident, unseen damage may affect your vehicle's driveability and safety. Important before you operate your car for the first time, please familiarize yourself with the new-engine oil consumption information on page 136 . You should also be ...

  • Page 5

    2005 volvo s80 volvo's environmental activities are based on a holistic view, which means we consider the overall environmental impact of a product throughout its complete life cycle. In this context, design, production, product use, and recycling are all important considerations. In production, vol...

  • Page 6

    2005 volvo s80 premair® on the surface of the radiator in the engine compartment, there is a special coating called premair®. Premair® works as a catalytic converter, converting most of the ozone passing through the radiator into oxygen, thereby reducing harmful ground-level ozone. Premair is a regi...

  • Page 7: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 1 - safety pg. 1 safety not wearing a seat belt is like believing "it'll never happen to me!" volvo, the inventor of the three-point seat belt, urges you and all adult occupants of your car to wear seat belts and ensure that children are properly restrained, ...

  • Page 8

    2005 volvo s80 stability traction control (stc) 20 dynamic stability and traction control (dstc) 20 pg. 2 seat belts seat belts always fasten the seat belts before you drive or ride. A chime will sound several times if the driver has not fastened his seat belt. To buckle: pull the belt out far enoug...

  • Page 9

    2005 volvo s80 lap portion of the belt should sit low child seats: please refer to page 16 for information on securing child seats with the seat belts. During pregnancy pregnant women should always wear seat belts. Remember that the belt should always be positioned in such a way as to avoid any poss...

  • Page 10

    2005 volvo s80 warning! ● never use a seat belt for more than one occupant. ● never wear the shoulder portion of the belt under the arm, behind the back or otherwise out of position. Such use could cause injury in the event of an accident. ● as the seat belts lose much of their strength when exposed...

  • Page 11

    2005 volvo s80 warning! ● please note that the lowest head restraint position is only intended for use when the backrest is to be folded down, or when the seat is not occupied. ● the head restraint is intended to help protect the head/neck in a collision. Ensure that it is properly adjusted for the ...

  • Page 12

    2005 volvo s80 the entire process, including inflation and deflation of the airbags, takes approximately two-tenths of a second. Warning! ● as its name implies, srs is designed to be a supplement to - not a replacement for - the three- point belt system. For maximum protection, wear seat belts at al...

  • Page 13

    2005 volvo s80 started. Check that this light is functioning properly every time the vehicle is started. Warning! ● never drive an srs equipped car with your hands on the steering wheel pad / airbag housing. ● no objects, accessory equipment or stickers may be placed on, attached to or installed nea...

  • Page 15

    2005 volvo s80 warning! Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We also recommend that children under 4 feet 7 inches (140 cm) in height who have outgrown these devices sit in the rear seat with the seat belt fastened. Note: deployment of srs ...

  • Page 16

    2005 volvo s80 note: the information on this page does not pertain to the side impact protection system airbags. When are the airbags deployed? The srs system is designed to deploy during certain frontal or front-angular collisions, impacts, or decelerations, depending on the crash severity, angle, ...

  • Page 17

    2005 volvo s80 warning! If your car has been subjected to flood conditions (e.G. Soaked carpeting/standing water on the floor of the vehicle) or if your car has become flood-damaged in any way, do not attempt to start the vehicle or put the key in the ignition before disconnecting the battery (see b...

  • Page 18

    2005 volvo s80 sips airbag * sips airbag (front seats only) as an enhancement to the structural side impact protection system built into your car, the car is also equipped with side impact protection system (sips) airbags. The sips airbag system consists of airbag modules built into the sides of bot...

  • Page 19

    2005 volvo s80 warning! ● never drive with the airbags deployed. The fact that they hang out can impair the steering of your car. Other safety systems can also be damaged. The smoke and dust formed when the airbags are deployed can cause skin and eye irritation in the event of prolonged exposure. ● ...

  • Page 20

    2005 volvo s80 if the inflatable curtain deploys, it remains inflated for approximately 3 seconds. Warning! ● the ic system is a supplement to the side impact protection system. It is not designed to deploy during collisions from the front or rear of the car or in rollover situations. ● never try to...

  • Page 21

    2005 volvo s80 pg. 12 whiplash protection system (whips) whiplash protection system (whips) - front seats only the whips system consists of specially designed hinges and brackets on the front seat backrests and head restraints designed to help absorb some of the energy generated in a collision from ...

  • Page 22

    2005 volvo s80 warning! ● any contact between the front seat backrests and the folded rear seat could impede the function of the whips system. If the rear seat is folded down, the occupied front seats must be adjusted forward so that they do not touch the folded rear seat. ● boxes, suitcases, etc. W...

  • Page 23

    2005 volvo s80 ● your ability to concentrate. ● how quickly you make decisions under stress to avoid an accident. The tips listed below are suggestions to help you cope with the ever changing traffic environment. ● never drink and drive. ● if you are taking any medication, consult your physician abo...

  • Page 24

    2005 volvo s80 pg. 14 child safety child restraint anchorages volvo cars are fitted with child restraint top tether anchorages in the rear seat. Refer to the child seat manufacturer's instruction for information on securing the child seat. Warning! Child restraint anchorages are designed to withstan...

  • Page 25

    2005 volvo s80 isofix/latch anchors lower anchors for isofix-equipped child seats are located in the rear, outboard seats, hidden below the backrest cushions. Symbols on the seat back upholstery mark the anchor positions as shown. To access the anchors, kneel on the seat cushion and locate the ancho...

  • Page 26

    2005 volvo s80 volvo's own integrated booster cushion has been specially designed to help safeguard a child seated in the center position of the rear seat. When using the integrated booster cushion, the child must be secured with the vehicle's three-point seat belt. Use this booster cushion only wit...

  • Page 27

    2005 volvo s80 storing the booster cushion fold the seat up - it will lock automatically to the backrest. Note: canada only: this cushion may be referred to as a built-in booster cushion. Pg. 16 child safety keeping child seats in place (alr/elr*) to make child seat installation easier, each seat be...

  • Page 28

    2005 volvo s80 warning! Do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We also recommend that children who have outgrown these devices sit in the rear seat with the seat belt properly fastened. * automatic locking retractor/emergency locking retracto...

  • Page 29

    2005 volvo s80 restraint systems for children are designed to be secured in the vehicle by lap belts or the lap portion of a lap-shoulder belt. Such child restraint systems can help protect children in cars in the event of an accident only if they are used properly. However, children could be endang...

  • Page 30

    2005 volvo s80 warning! ● do not use child safety seats or child booster cushions/backrests in the front passenger's seat. We also recommend that children under 4 feet 7 inches (140 cm) in height who have outgrown these devices sit in the rear seat with the seat belt fastened. ● keep vehicle doors a...

  • Page 31

    2005 volvo s80 power brakes function only when the engine is running the power brakes utilize vacuum pressure which is only created when the engine is running. Never let the vehicle roll to a stop with the engine switched off. If the power brakes are not working, the brake pedal must be pressed appr...

  • Page 32

    2005 volvo s80 the switching of the abs modulator will be audible and the brake pedal will pulsate during braking. Please be aware that abs does not increase the absolute braking potential of the vehicle. While control will be enhanced, abs will not shorten stopping distances on slippery surfaces. A...

  • Page 33

    2005 volvo s80 wheel spin. This is quite normal. This is one of the stc/dstc's permanent functions and is not affected when the button on the center control panel is pressed. 2. Spin control (sc) the spin control function is designed to help prevent the drive wheels from spinning while the car is ac...

  • Page 34

    2005 volvo s80 * standard on certain models ** option pg. 21 stc/dstc the stc/dstc button the stc/dstc button in the center control panel (see page 31 ) is used to switch the spin control (sc) function on or off. Note: ayc (on models equipped with this function) will also be reduced, but not switche...

  • Page 36: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 2 - instruments, switches and controls pg. 23 instruments, switches and controls interior 24 exterior 25 instruments 26 instrument panel 27 indicator and warning lights 28 text information window 30 switches in center console 31 trip computer 32 cruise contro...

  • Page 37

    2005 volvo s80 electrically operated windows 41 rearview/sideview, vanity mirrors 42 power moonroof 43 sun visor, sun blinds 44 pg. 24 interior a locking and unlocking the car 63/65 alarm 67 electrically operated windows 41 sideview mirror controls 42 b glove compartment 57 c automatic transmission ...

  • Page 38

    2005 volvo s80 geartronic 80 parking brake 40 center console switches 31 d power seat adjustment 54 heated seats (option) 39 cleaning upholstery 129 e folding rear seat 60 panel for long loads 58 folding down head restraint 31 adjusting center head restraint 3 child safety locks 69 integrated booste...

  • Page 39

    2005 volvo s80 economical driving 84 c replacing a back-up light 121 replacing a brake light 121 replacing a tail light 121 replacing a turn signal 121 replacing a rear fog light 121 replacing license plate lights 123 d tires 98 wheels 98 brake system 18 spare tire 109 changing wheels 110 e replacin...

  • Page 40

    2005 volvo s80 a temperature gauge 27 speedometer 27 odometer 27 trip odometer 27 warning lights 27 text window 30 tachometer 27 clock 27 ambient temperature sensor 27 fuel gauge 27 b hazard warning flashers 39 c audio system 151 d electronic climate control 47 heated seats (option) 39 heated rear w...

  • Page 41

    2005 volvo s80 e steering wheel adjustment 38 airbag 4 cruise control 33 windshield wipers/washer 37 turn signal lever 36 trip computer 32 audio system controls 151 f high/low beam headlights 34 parking lights 34 fog lights 34 instrument panel lighting 34 button to unlock fuel filler door 34 pg. 27 ...

  • Page 42

    2005 volvo s80 the trip odometer is used for measuring shorter distances. The last digit indicates 1/10 mile/kilometer. Press the button quickly to toggle between trip odometers 1 and 2. Hold in the button for more than 2 seconds to reset. 5 odometer 6 speedometer 7 general warning light (see page 2...

  • Page 43

    2005 volvo s80 the indicator and warning lights described on pages 28 and 29 should never stay on when driving* when the ignition key is turned, all of the warning lights in the lower right-hand side of the instrument panel should go on to test the function of the bulbs. If a light does not go off a...

  • Page 44

    2005 volvo s80 park brake parking brake reminder light this light will be on when the parking brake (hand brake) is applied. The parking brake lever is situated between the front seats. Canadian models are equipped with this warning light: oil pressure warning light if the light comes on while drivi...

  • Page 45

    2005 volvo s80 canadian models are equipped with this warning light: note: if the fuel filler cap is not closed tightly or if the engine is running when the car is refueled, the malfunction indicator lamp may indicate a fault. However, your vehicle's performance will not be affected. Use only volvo ...

  • Page 47: Messages In The Text Window

    2005 volvo s80 pg. 30 text information window messages in the text window when a warning light in the instrument panel comes on, a message is also displayed in the text window. After you have read the message, you can erase it by pressing button a (see illustration above). Note: certain messages can...

  • Page 48

    2005 volvo s80 see manual: refer to your owner's manual. For additional information, please contact your volvo retailer. Service required: take your car to an authorized volvo retailer for inspection at your convenience (but preferably before the next scheduled maintenance service). Fix next service...

  • Page 49

    2005 volvo s80 four-c active chassis system (option) see page 82 for information on this function. Stability traction control (stc)/dynamic stability traction control (dstc) - option press this switch for at least half a second to turn the spin control (sc) function of the stc/dstc system on or off....

  • Page 50

    2005 volvo s80 warning! For safety reasons, no one should be allowed to sit in the outboard rear seat positions if the head restraints are folded down. If these positions are occupied, the head restraints should be in the upright (fixed) position. Park assist (option/accessory) see page 83 for infor...

  • Page 51

    2005 volvo s80 note: the auxiliary sockets can also be used for cigarette lighters, which are available at your volvo retailer. Pg. 32 trip computer trip computer the trip computer stores information gathered from several systems in your car and has five menus that can be displayed in the text windo...

  • Page 52

    2005 volvo s80 driving distance on current fuel reserve this function shows the approximate distance that can be driven on the fuel remaining in the tank. This calculation is based on average fuel consumption during the last 12 miles (20 km) of driving and the amount of fuel remaining in the tank wh...

  • Page 53

    2005 volvo s80 the cruise control panel is located on the left side of the steering wheel hub. Engaging cruise control press the cruise button. Cruise will be displayed in the information window in the instrument panel. Note: this does not set the vehicle's speed. Setting speed press + or - to set t...

  • Page 54

    2005 volvo s80 displayed in the information window in the instrument panel. Note: cruise control is automatically disengaged if: · the engine is switched off · the gear selector is placed in (n)eutral · the wheels start to spin or lock · if an increase in speed is maintained for more than one minute...

  • Page 55

    2005 volvo s80 note: bi-xenon headlights (option): turn the headlight switch to position 0 to activate a daylight sensor, which automatically switches the low beams on or off, depending on ambient light conditions. When driving in daylight, the headlights will switch off and the daytime running ligh...

  • Page 56

    2005 volvo s80 note : if the fuel filler door does not unlock after the button has been pressed, please see page 35 for information on manually unlocking this door. D - front fog lights (option) the front fog lights will only function in combination with the low beam headlights. An led in the switch...

  • Page 57

    2005 volvo s80 2. Fold down the cover panel to access the electric motor (c). 3. Press the catch (d) rearward to unlock the fuel filler door, or forward to lock the door. Pg. 36 turn signals turn signals 1 lane change position. In maneuvers such as lane changing, the driver can flash the turn signal...

  • Page 58

    2005 volvo s80 windshield wipers/washers 0 windshield wipers off "single sweep" position: move the lever slightly upward from the 0 position for one sweep of the wipers. The lever returns automatically to 0 when released. Intermittent wiper function. With the lever in this position, you can set the ...

  • Page 59

    2005 volvo s80 · move the windshield wiper lever down to another position. Moving the lever up will not deactivate the rain sensor. Doing so will cause the wipers to sweep the windshield until the lever is released, at which time the wipers return to rain sensor mode. Caution: the rain sensor should...

  • Page 60

    2005 volvo s80 steering wheel adjustment both the height and the reach of the steering wheel can be adjusted to a comfortable position for the driver. Pull down the lever on the left of the steering column. Adjust the steering wheel to a suitable position and press the lever back into place to lock ...

  • Page 61

    2005 volvo s80 opened. * the gear selector must be in the (p)ark position. ** please be aware that leaving the key in this position will increase battery drain. Steering wheel lock the steering wheel lock might be under tension when the car is parked. Turn the steering wheel slightly to free the ign...

  • Page 62

    2005 volvo s80 pg. 39 warning flashers, heated mirrors/rear window, heated front seats hazard warning flashers the four-way flasher should be used to indicate that the vehicle has become a traffic hazard. To activate the flashers, press the triangular button in the center dash. Press the button agai...

  • Page 63

    2005 volvo s80 heated front seats (option) the front seat heating can be switched on and off as required. ● press the switch once for maximum seat heating. Both leds in the switch will be lit. ● press the switch a second time for comfort heating. One led in the switch will be lit. ● press the switch...

  • Page 64

    2005 volvo s80 warning! ● always use the parking brake (hand brake) when parking. On hills, also turn the front wheels toward the curb. ● the indicator light in the instrument panel will light up even if the parking brake is only applied slightly. Be sure to pull the lever up sufficiently. Auxiliary...

  • Page 65

    2005 volvo s80 electrically operated windows the electrically operated windows are controlled by buttons in the arm rests. The ignition switch must be on * (ignition key in position i or ii or the engine running) for the electrically operated windows to function. To lower: press down the front edge ...

  • Page 66

    2005 volvo s80 cutout switch for rear windows the electrically operated rear door windows can be disabled by a switch located on the driver's door (see illustration). If the led in the switch is off: the rear door windows can be raised or lowered with the buttons on the rear door armrests or with th...

  • Page 67

    2005 volvo s80 rearview mirror a normal position b night position, reduces glare from following headlights autodim function (option) the autodim function reacts to headlights from following traffic and automatically reduces glare. Note: this function is automatically switched off when the gear selec...

  • Page 68

    2005 volvo s80 sideview mirror controls remote control (central locking system) if you lock the car and later unlock it with the same remote control and open the driver's door, the sideview mirrors will automatically move to the position they were in when you left the car. This feature will work in ...

  • Page 69

    2005 volvo s80 power moonroof to operate the moonroof, turn the ignition key to position i or ii, or start the engine. The moonroof can be operated in two ways: a. Tilt position b. Sliding moonroof a. Tilt position open: with the moonroof closed, push up the rear edge of the switch (position 5 in th...

  • Page 70

    2005 volvo s80 manual close: push the switch to position 2 and hold it until the moonroof has closed completely or to the position of your choice. Auto close: push the switch forward as far as possible (position 1) and release it to automatically close the moonroof . Warning! ● never open/close the ...

  • Page 71

    2005 volvo s80 moonroof is opened. The visor must be closed manually. Sun blind - rear window pull up the blind from the rear parcel shelf and attach the two hooks in the fasteners in the roof liner above the rear window, as shown in the illustration above. Sun blind - rear side windows roll the win...

  • Page 72: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 3 - climate control system pg. 45 climate control system ventilation 46 electronic climate control (ecc) 47 climate control system - general information 50 interior air quality system (option) 51 pg. 46 ventilation air vents in dash air vents (dash) a open fi...

  • Page 73

    2005 volvo s80 b closed c horizontal air flow d vertical air flow direct the outer air vents toward the side windows to demist. In cold weather, close the air vents in the center of the dash to direct as much air as possible toward the windows. Air flow the air that is drawn into the passenger compa...

  • Page 74

    2005 volvo s80 direct the air vents toward the rear side windows to demist. Direct the air vents toward the rear seat for the best heating/cooling effect. Pg. 47 electronic climate control (ecc) pg. 48 electronic climate control (ecc) auto this function automatically regulates the electronic climate...

  • Page 75

    2005 volvo s80 temperature these controls are used to individually set the temperature for both sides of the passenger compartment. Please note that the compartment will not be heated or cooled faster by setting the temperature higher or lower than necessary. Set the control to the temperature you p...

  • Page 76

    2005 volvo s80 press this switch to engage the recirculation function (air in the passenger compartment recirculates - no fresh air enters the compartment). The led in the switch will light up to indicate that the function is engaged. ● use this function if the outside air is contaminated with exhau...

  • Page 77

    2005 volvo s80 air conditioning on/off press the switch to turn the air conditioning on or off. The "on" or "off" led will light up to indicate if the system is switched on or off. Other functions will still be regulated automatically (if the auto switch is on). ● the air conditioning functions only...

  • Page 78

    2005 volvo s80 panel should not be covered in any way as this could cause incorrect information to be sent to the ecc system. Parking the car in warm weather if your car has been parked in the sun in warm weather, opening the windows and sun roof (option) for several minutes before driving will help...

  • Page 79

    2005 volvo s80 operation: press to activate the air quality sensor (normal setting). Or select one of three functions by pressing 1. Press the led aut comes on. The air quality sensor is now activated. 2. Press no led is lighted. Recirculation not activated. 3. Press the led man comes on. Recirculat...

  • Page 81

    2005 volvo s80 1. Power seat control panel, 2. Lumbar support: turn for softer or firmer support electrically operated seats operation driver's seat: the seat can be adjusted if the ignition key is in position i, ii or if the engine is running. It can also be adjusted as follows with the ignition of...

  • Page 82

    2005 volvo s80 warning! ● because the driver's seat can be adjusted with the ignition off, children should never be left unattended in the car. ● movement of the seat can be stopped at any time by pressing any button on the power seat control panel. ● do not adjust the seat while driving. The seat s...

  • Page 83

    2005 volvo s80 remote keyless entry system and the driver's seat the remote control transmitter also controls the position of the electrically operated driver's seat in the following way: 1. Adjust the seat to your preferences. 2. When you leave your vehicle, lock it using the remote control. The po...

  • Page 84

    2005 volvo s80 down the backrest: ● move the seat as far rearward as possible ● adjust the backrest tilt to the most upright position ● lift the catches on the lower rear side of the backrest ● without releasing the catches, push the backrest forward ● move the seat as far forward as possible so tha...

  • Page 85

    2005 volvo s80 front reading lights courtesy light the courtesy light can be turned on or off by pressing the button. The light also has a timer function which turns the light (in dark conditions) on for 30 seconds if: ● you unlock the car from the outside with the key or remote control. ● you switc...

  • Page 86

    2005 volvo s80 to switch off the interior and trunk courtesy lights indefinitely, press and hold the center button in the panel above the rearview mirror for 3 seconds.The courtesy lights will go off and remain off until the center button is pressed again. Rear reading lights reading lights - front/...

  • Page 87

    2005 volvo s80 warning! Packages on the rear window shelf can obscure vision and may become dangerous projectiles in the event of a sudden stop or an accident. Anchor any heavy objects to help prevent them from moving during sudden stops. Pg. 58 storage compartment in center console, long loads file...

  • Page 88

    2005 volvo s80 storage compartment in center console/cup holders ● press button a to pop open the cup holder. ● press button b to open the storage space in the center console for cassettes, accessory coin holder, etc. Secure long loads with the seat belt carry long loads the center backrest cushion ...

  • Page 89

    2005 volvo s80 ● release the flap by pushing the catch (located on the rear side of the backrest) upward and pulling the flap forward. ● return the backrest to the upright position. * if your car is equipped with the optional integrated child booster cushion, this cushion must be folded down before ...

  • Page 90

    2005 volvo s80 cargo net in the trunk the cargo net in the trunk can be used to secure light objects. Pull the net out and slide the runner in the handle down into one of the two slots provided at the rear edge of the trunk. Use the release tab to release tension on the net while it is being placed ...

  • Page 91

    2005 volvo s80 backrest controls (on opposite sides of trunk) folding rear seat backrest the rear seat backrest is split into two sections. Each section can be folded independently to allow you to transport long objects. To fold down the backrest(s): ● pull the release control handle(s) in the trunk...

  • Page 92

    2005 volvo s80 warning! ● keep vehicle doors and the luggage compartment locked and keep keys out of a child's reach. Unsupervised children could lock themselves in an open trunk and risk injury. Children should be taught not to play in vehicles. ● on hot days, the temperature in the trunk or vehicl...

  • Page 93: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 5 - keys, locks, alarm pg. 61 keys, locks, alarm keys, exterior courtesy lights, locking and unlocking the car 62 remote keyless entry system 63 locking and unlocking the car 65 alarm 67 child safety locks - rear doors 69 pg. 62 keys, exterior courtesy lights...

  • Page 94

    2005 volvo s80 keys two types of keys are provided with your car; master keys and a service key. The master key, the remote control, and the central locking button may all be used to lock and unlock all of your car's locks. The service key will operate only the driver's door and the ignition switch....

  • Page 95

    2005 volvo s80 ● remove the key from the ignition switch. ● pull the turn signal lever towards the steering wheel (as when using the headlight flasher function). ● exit the car and lock the doors. The headlights, parking lights, license plate lights and the lights in the sideview mirrors will now co...

  • Page 96

    2005 volvo s80 1 - fold key in/out, 2 - lock, 3 - approach lighting, 4 - "panic" function, 5 - open trunk, 6- unlock using the remote control button 1: press to extend the key. This button must also be pressed when the key is folded back into the slot in the side of the remote control unit. Button 2...

  • Page 97

    2005 volvo s80 canadian 2306104388 model 504 2927 by donnelly operation is subject to the following conditions: (1) this device may not cause interference, and (2) this device must accept any interference, including interference that may cause undesired operation of the device. Canadian 2306104388a ...

  • Page 98

    2005 volvo s80 remote keyless entry system - replacing batteries if the range of the transmitter is noticeably reduced, this indicates that the battery is weak and should be replaced. To replace the battery ● remove the cover by carefully prying up its rear edge with a small screwdriver ● replace th...

  • Page 99

    2005 volvo s80 normally, the trunk should be locked and unlocked via the central locking system using the remote control or by using the key in the driver's door lock. The master key should be used only if it is not possible to unlock the trunk via the central locking system. Note: unlocking the tru...

  • Page 100

    2005 volvo s80 warning! ● keep vehicle doors and trunk locked and keep keys out of a child's reach. Unsupervised children could lock themselves in an open trunk and risk injury. Children should be taught not to play in vehicles. ● on hot days, the temperature in the trunk or vehicle interior can ris...

  • Page 101

    2005 volvo s80 trunk lock button* valet security locking the security locking feature of your car allow you to prevent unwanted access to your trunk and glove compartment, while still allowing a parking attendant to unlock, start, and relock the rest of your car. To prevent unwanted access to the tr...

  • Page 102

    2005 volvo s80 ● the hood is forced opened. ● the trunk is forced opened. ● a door is forced opened. ● the ignition switch is tampered with. ● if there is movement in the passenger compartment (if the car is equipped with the optional movement sensor). ● the car is lifted or towed (if the car is equ...

  • Page 103

    2005 volvo s80 the position of this button may vary, depending on the specifications of your car. Temporarily turning off the inclination and movement alarm sensor(s) - accessory this button will only be found in cars equipped with the accessory inclination and/or movement sensors. Fcc id: mayda5823...

  • Page 104

    2005 volvo s80 note: ● this function will not turn off the vehicle's standard alarm. ● the optional sensors are automatically reconnected to the alarm system the next time the car is unlocked and then locked again. Led alarm status signals the status of the alarm system is indicated by the red led a...

  • Page 106: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 6 - starting and driving pg. 71 starting and driving fuel requirements 72 refueling 74 starting the engine 75 automatic transmission 76 four-c active chassis system 82 front/rear park assist 83 driving economy 84 points to remember 85 roof racks/load carriers...

  • Page 107: Fuel Requirements

    2005 volvo s80 three-way catalytic converter 95 all wheel drive (awd) 96 pg. 72 fuel requirements fuel requirements octane rating volvo engines are designed for optimum performance on unleaded premium gasoline with an octane rating aki of 91, or above. Aki (anti knock index) is an average of the res...

  • Page 108

    2005 volvo s80 some fuel suppliers sell gasoline containing "oxygenates" which are usually alcohols or ethers. In some areas, state or local laws require that the service pump be marked indicating use of alcohols or ethers. However, there are areas in which the pumps are unmarked. If you are not sur...

  • Page 109

    2005 volvo s80 pg. 74 refueling refueling the fuel tank holds approximately 21.1 us gal. (80 liters) on t6 models, or 18 us gal. (68 liters) on the s80 all wheel drive and the s80 2.5t front wheel drive with sufficient volume left over to accommodate possible expansion of the fuel in hot weather. Be...

  • Page 110

    2005 volvo s80 warning! Never carry a cell phone that is switched on while refueling your vehicle. If the phone rings, this may cause a spark that could ignite gasoline fumes, resulting in fire and injury. Caution: ● do not refuel with the engine running *. Turn the ignition off or to position i. If...

  • Page 111

    2005 volvo s80 note: on certain models, when the car is started, idle speed may be noticeably higher than normal for a short period, depending on the temperature of the engine. This has been done to help bring components in the emission control system to their normal operating temperature as quickly...

  • Page 112

    2005 volvo s80 pg. 85 points to remember speed-sensitive power steering with this feature, the steering is most responsive at lower speeds to make parking, driving in city traffic, etc., easier. The effect of the power steering diminishes as you accelerate for greater stability at highway speeds. We...

  • Page 113

    2005 volvo s80 may be used at one time. Electrical system when replacing the battery or when carrying out work involving the electrical system, the following should be observed: ● a battery connection to the wrong terminal will damage the electrical system. Be sure to connect the positive battery ca...

  • Page 114

    2005 volvo s80 3 carefully lower the opposite side of the load carrier to the roof. 4 loosen the tightening wheel slightly. Slide the hook on the load carrier attachment into the attachment bracket under the roof molding. 5 turn the tightening wheel to secure the load carrier in the attachment brack...

  • Page 115

    2005 volvo s80 front towing eyelet emergency towing the towing eyelet is located in the tool bag, under the floor of the trunk, with the spare tire. This eyelet must be screwed into the positions provided on the right sides of either the front or rear bumper (see illustration). To attach the towing ...

  • Page 116

    2005 volvo s80 ● maximum distance with front wheels on ground: 50 miles (80 km). ● while the car is being towed, try to keep the tow rope taut at all times. ● the cars should only be towed in forward direction. Caution: ● please check with state and local authorities before attempting this type of t...

  • Page 117

    2005 volvo s80 caution: ● sling-type equipment applied at the front will damage radiator and air conditioning lines. ● it is equally important not to use sling-type equipment at the rear or apply lifting equipment inside the rear wheels; serious damage to the rear axle may result. ● if the car is be...

  • Page 118

    2005 volvo s80 ● maximum speed when towing a trailer: 50 mph (80 km/h). ● engine and transmission are subject to increased loads. Therefore, engine coolant temperature should be closely watched when driving in hot climates or hilly terrain. Use a lower gear and turn off the air conditioner if the te...

  • Page 120

    2005 volvo s80 pg. 92 jump starting jump starting follow these instructions to jump start your car's dead battery or to jump start another car's dead battery using your car. Although your car's battery is located under the floor of the cargo area, jumper cables should be connected in the engine comp...

  • Page 121

    2005 volvo s80 start the engine in the assisting car, then start the engine in the car with dead battery. ● after the engine has started, first remove the negative (-) terminal jumper cable. Then remove the positive (+) terminal jumper cable. Caution: improper hookup of jumper cables or use of other...

  • Page 122

    2005 volvo s80 addition, in extremely cold weather conditions it is worthwhile to add fuel line de-icer before refueling. ● the viscosity of the engine oil is important. Oil with low viscosity (thinner oil) improves cold- weather starting as well as decreasing fuel consumption while the engine is wa...

  • Page 123

    2005 volvo s80 as a minimum, the following items should be checked before any long trip: ● check that engine runs smoothly and that fuel consumption is normal. ● check for fuel, oil, and fluid leakage. ● check condition of accessory drive belts. ● check condition of drive belts. ● check state of the...

  • Page 124

    2005 volvo s80 ● excessive starter cranking (in excess of one minute), with an intermittently firing or flooded engine, can cause three-way catalytic converter or exhaust system overheating. ● remember that tampering or unauthorized modifications to the engine or the vehicle may be illegal and can c...

  • Page 126: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 7 - wheels and tires pg. 97 wheels and tires general information 98 tire inflation 99 tire inflation pressure tables 101 tire pressure monitoring system (tpms) 102 self supporting run flat tires 103 tire designations 104 glossary of tire terminology 105 vehic...

  • Page 127

    2005 volvo s80 (the structural member at the side of the vehicle, at the rear of the driver's door opening), or on the inside of the fuel filler door on canadian models. The tires have good road holding characteristics and offer good handling on dry and wet surfaces. It should be noted however that ...

  • Page 128

    2005 volvo s80 characteristics of the vehicle. New tires remember that tires are perishable goods. As of 2000, the manufacturing week and year will be indicated with 4 digits (e.G. 1502 means that the tire illustrated was manufactured during week 15 of 2002). Improving tire economy: • maintain corre...

  • Page 129

    2005 volvo s80 tire inflation check tire inflation pressure regularly. A table listing the recommended inflation pressure for your vehicle can be found on page 101. Tire inflation pressure placards are also located on the driver's side b-pillar (the structural member at the side of the vehicle, at t...

  • Page 130

    2005 volvo s80 • use a tire gauge to check the tire inflation pressure, including the spare, at least once a month and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be inaccurate. • use the recommended cold inflation pressure...

  • Page 131

    2005 volvo s80 driving and it is normal for pressures to increase above recommended cold pressures. A hot tire at or below recommended cold inflation pressure could be significantly under-inflated. To check inflation pressure: 1. Remove the cap from the valve on one tire, then firmly press the tire ...

  • Page 132

    2005 volvo s80 225/50r17 39 (270) 39 (270) 235/45r17 ssrft 2 39 (270) 39 (270) 235/40r18 39 (270) 39 (270) temporary spare tire t125/80r17 61 (420) 61 (420) 1 these weights include the weight of all occupants of the car plus cargo. 2 self supporting run flat tires. See page 103 for more information....

  • Page 133

    2005 volvo s80 when low inflation pressure is detected, tpms will light up the tire pressure warning light ( ) in the instrument panel, and will display a message in the text window. The wording of this message is determined by the degree of inflation pressure loss. When the tire pressure monitoring...

  • Page 134

    2005 volvo s80 vehicle: only the factory-mounted wheels are equipped with tpms sensors in the valves. If the vehicle is equipped with a temporary spare tire, this tire does not have a tpms sensor. If, for example, winter wheels/tires are used that are not equipped with tpms sensors, the message tire...

  • Page 135

    2005 volvo s80 warning! • only specially trained persons should mount self supporting run flat tires. • if self supporting run flat tires are mounted, the vehicle must be equipped with a tire pressure monitoring system. • after a low pressure warning has been displayed, do not exceed 50 mph (80 km/h...

  • Page 136

    2005 volvo s80 3. R: radial tire. 4. 15: the diameter of the wheel rim (in inches). 5. 95: the tire's load index. In this example, a load index of 95 equals a maximum load of 1521 lbs (690 kg). 6. H: the tire's speed rating, or the maximum speed at which the tire is designed to be driven for extende...

  • Page 137

    2005 volvo s80 tubeless, etc. Glossary of tire terminology • tire information placard: a placard showing the oe (original equipment) tire sizes, recommended inflation pressure, and the maximum weight the vehicle can carry. • tire identification number (tin): a number on the sidewall of each tire pro...

  • Page 138

    2005 volvo s80 • recommended tire inflation pressure: inflation pressure, established by volvo, which is based on the type of tires that are mounted on a vehicle at the factory. This inflation pressure is affected by the number of occupants in the car, the amount of cargo, and the speed at which the...

  • Page 139

    2005 volvo s80 the vehicle's curb weight + cargo + passengers. Note: • the location of the various labels in your vehicle can be found on page 144 . • a table listing important weight limits for your vehicle can be found on page 145 . Steps for determining correct load limit (1) locate the statement...

  • Page 140

    2005 volvo s80 pg. 107 wheels and tires uniform tire quality grading all passenger vehicle tires must conform to federal safety requirements in addition to these grades quality grades can be found, where applicable, on the tire sidewall between the tread should and maximum section width. For example...

  • Page 141

    2005 volvo s80 warning! The temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, under-inflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure. Pg. 108 wheels and tires ...

  • Page 142

    2005 volvo s80 • the handling of the vehicle can be adversely affected when driving with chains. Avoid fast or sharp turns as well as locked wheel braking. Snow tires, studded tires 1 tires for winter use: • owners who live in or regularly commute through areas with sustained periods of snow or icy ...

  • Page 143

    2005 volvo s80 warning! Current legislation prohibits the use of the "temporary spare" tire other than as a temporary replacement for a punctured tire. It must be replaced as soon as possible by a standard tire. Road holding and handling may be affected with the "temporary spare" in use. Do not exce...

  • Page 144

    2005 volvo s80 ● remove the wheel cap (where applicable) using the lug wrench in the tool bag. ● with the car still on the ground, use the lug wrench to loosen the wheel bolts 1/2 -1 turn by exerting downward pressure. Turn the bolts counterclockwise to loosen. Loosen wheel bolts ● position the jack...

  • Page 145

    2005 volvo s80 changing over to winter tires/wheels). Pg. 111 changing wheels correct tightening order for wheel bolts installing the wheel ● clean the contact surfaces on the wheel and hub. ● lift the wheel and place it on the hub. ● install the wheel bolts and tighten hand-tight. Using the lug wre...

  • Page 146

    2005 volvo s80 warning! · the jack must correctly engage the bar in the jack attachment (a). The car's weight must not rest on the jack attachment (b). See illustration on page 110 . · be sure the jack is on a firm, level, non-slippery surface. · never allow any part of your body to be extended unde...

  • Page 147: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 8 - maintenance/servicing pg. 113 maintenance/servicing fuses 114 replacing bulbs 119 paint touch up 126 washing the car 127 cleaning the upholstery 129 maintenance service, warranty 130 fuel/emissions systems 131 drive belt, coolant 132 emissions maintenance...

  • Page 148

    2005 volvo s80 pg. 114 fuses replacing fuses if an electrical component fails to function, it is likely that a fuse has blown due to a temporary circuit overload. Fuses are located in four different places: 1. Relays/fuse box in the engine compartment 2. Fuse box in the passenger compartment, behind...

  • Page 149: Ordinary Fuses

    2005 volvo s80 pg. 115 fuses in the engine compartment relays/fuses in the engine compartment when replacing fuses, be sure to replace a blown fuse with a new one of the same color and amperage (written on the fuse). Fuses in positions marked x are replacement fuses. A - to open, press the plastic c...

  • Page 150

    2005 volvo s80 13 windshield wipers 25a 14 abs 30a 15 - 16 - 17 driver's side low beam 20a 18 front parking lights 15a 19 abs 30a 20 passenger's side low beam 20a 21 fuel pump 15a 22 starter motor 35a 23 engine control module, engine relay 10a 24 - pg. 116 fuses in the passenger compartment fuse box...

  • Page 151

    2005 volvo s80 1 power driver's seat (option) 25a 2 power passenger's seat (option) 25a 3 climate system blower 30a 4 control module - front passenger's door 25a 5 control module - driver's door 25a 6 ceiling lighting, upper electrical control module 10a 7 moon roof (option) 15a 8 ignition switch, s...

  • Page 152

    2005 volvo s80 34 - 35 - 36 - 37 - 38 - pg. 117 fuses in the passenger compartment fuse box in the passenger compartment, behind the plastic cover this fuse box is located behind the plastic cover below the steering wheel. When replacing a blown fuse, be sure to replace it with a new one of the same...

  • Page 153

    2005 volvo s80 15 abs, stc/dstc 5a 16 power steering, bi-xenon headlights (option) 10a 17 driver's side front foglight (option) 7.5a 18 passenger's side front foglight (option) 7.5a 19 - 20 - 21 transmission control module, reverse gear block (m66 gearbox) 10a 22 driver's side high beam 10a 23 passe...

  • Page 154: Ordinary Fuses

    2005 volvo s80 fuses in the trunk the fuses in the trunk are located behind the panel on the driver's side. When replacing a blown fuse, be sure to replace it with a new one of the same color and amperage (written on the fuse). Ordinary fuses location amperage 1 backup lights 10a 2 parking lights, f...

  • Page 155

    2005 volvo s80 11 - 12 - 13 - 14 - 15 - 16 - 17 accessory audio 5a 18 - 19 folding head restraints (option) 15a 20 trailer wiring (15-feed) 20a 21 - 22 - 23 all wheel drive (option) 7.5a 24 four-c chassis system (option) 15a 25 - 26 park assist (option) 5a 27 main fuse: trailer wiring, four-c, park ...

  • Page 156

    2005 volvo s80 replacing high/low beam headlight bulbs the headlight bulbs must be replaced from the engine compartment. Caution: ● do not touch the glass on halogen bulbs with your fingers. Grease, oil or any other impurities can be carbonized onto the bulb and cause damage to the reflector. ● be s...

  • Page 157

    2005 volvo s80 installing a new bulb installing a new bulb: ● insert the new bulb, without touching the glass, with the guide lug upward (1). The bulb will only seat properly in this position. ● move the retaining spring up and push it slightly to the left until it seats properly (2). ● press the co...

  • Page 158

    2005 volvo s80 front parking lights ● switch off the ignition. ● remove the plastic cover over the high beam bulb by turning it counterclockwise. ● pull out the bulb and its socket. Replace the bulb. ● press the bulb and its socket back into place. ● switch on the ignition to test the bulb. ● reinst...

  • Page 159

    2005 volvo s80 ● press the connector onto the bulb holder. ● switch on the ignition to test the bulb. ● press the lamp housing back into place on the fender. Be sure it seats properly. Pg. 121 replacing bulbs tail lights 1. Tail light 2. Tail light/fog light (left side only) 3. Turn signal 4. Back-u...

  • Page 160

    2005 volvo s80 · press the bulb holder back into place. · reconnect the wiring. · fold up and close the covering panel. To replace bulb 5: · pull the bulb holder straight out of its retainer. · pull the bulb out of the holder. · press a new bulb into the holder. · press the bulb holder back into pla...

  • Page 161

    2005 volvo s80 vanity mirror lights ● carefully insert a screwdriver and pry out the lens. ● pry out the defective bulb and replace it. ● carefully press the lower edge of lens onto the four tabs and press the upper edge of the lens into place. Pg. 123 replacing bulbs license plate lights ● switch o...

  • Page 162

    2005 volvo s80 door step courtesy lights the door step courtesy lights are located under the dash on the driver's and passenger's sides. To replace a bulb: ● carefully insert a screwdriver and pry out the lens. ● replace the defective bulb. ● reinstall the lens. Rear door step lights ● carefully ins...

  • Page 163

    2005 volvo s80 pg. 124 replacing bulbs side turn signal ● open the front door halfway. ● from the inside of the fender, push the lamp housing out. ● turn the bulb holder 1/4 turn counterclockwise and pull it out from the lens. ● remove the defective bulb by pulling it straight out. ● insert a new bu...

  • Page 164

    2005 volvo s80 ● press the bulb holder into place and turn it clockwise. ● reinstall the lamp unit in the fender. Trunk lights ● carefully insert a screwdriver and pry out the lamp unit. ● replace the bulb. ● press the lamp unit back into place. Pg. 125 replacing bulbs front courtesy lights these bu...

  • Page 165

    2005 volvo s80 rear reading lights these bulbs may be difficult for you to replace yourself. We recommend that you let an authorized volvo retailer replace these bulbs if necessary. Note: other bulbs may be difficult for you to replace yourself. Let an authorized volvo retailer replace these bulbs i...

  • Page 166

    2005 volvo s80 paint - touch-up bottle brush masking tape note: when touching up the car, it should be clean and dry. The surface temperature should be above 60° f (15° c). Minor scratches on the surface if the stone chip has not penetrated down to the metal and an undamaged layer of paint remains, ...

  • Page 167

    2005 volvo s80 ● bird droppings: remove from paintwork as soon as possible. Otherwise the finish may be permanently damaged. ● a detergent can be used to facilitate the softening of dirt and oil. ● a water-soluble grease solvent may be used in cases of sticky dirt. However, use a wash place equipped...

  • Page 168

    2005 volvo s80 warning! ● when the car is driven immediately after being washed, apply the brakes several times in order to remove any moisture from the brake linings. ● engine cleaning agents should not be used when the engine is warm. This constitutes a fire risk. Drain holes pg. 128 washing the c...

  • Page 169

    2005 volvo s80 caution: volvo does not recommend the use of long-life or durable paint protection coatings, some of which may claim to prevent pitting, fading, oxidation, etc. These coatings have not been tested by volvo for compatibility with your vehicle's clear coat. Some of them may cause the cl...

  • Page 170

    2005 volvo s80 suede-like upholstery can be cleaned with a soft cloth and mild soap solution. Leather care volvo's leather upholstery is manufactured with a protectant to repel soiling. Over time, sunlight, grease and dirt can break down the protection. Staining, cracking, scuffing, and fading can r...

  • Page 171

    2005 volvo s80 maintenance service volvo advises you to follow the service program outlined in the warranty and service records information booklet. This maintenance program contains inspections and services necessary for the proper function of your car. The maintenance services contain several chec...

  • Page 172

    2005 volvo s80 may be read and used by: · volvo car corporation · service and repair facilities · law enforcement or government agencies · others who may assert a legal right to know, or who obtain your consent to know such information. Pg. 131 fuel/emissions systems fuel system the fuel system cont...

  • Page 173

    2005 volvo s80 note: ● overfilling the fuel tank can cause damage to the evaporative control system. ● if the fuel filler cap is not closed tightly or if the engine is running when the car is refueled, the malfunction indicator lamp may indicate a fault. ● during a transitional period, a small numbe...

  • Page 174

    2005 volvo s80 coolant and has a lower boiling point. It can also cause damage to the cooling system if it should freeze. Top up with volvo genuine coolant/antifreeze only. Caution: the cooling system must always be kept filled to the correct level. If it is not kept filled, there can be high local ...

  • Page 175

    2005 volvo s80 pg. 133 emissions maintenance periodic maintenance helps minimize emissions periodic maintenance will help keep your vehicle running well. Your warranty and service records information booklet provides a comprehensive periodic maintenance schedule up to 150,000 miles (240,000 km) of v...

  • Page 176

    2005 volvo s80 spark plugs the spark plugs should be replaced every 60,000 miles (96,000 km) under normal driving conditions. City driving or fast highway driving may necessitate replacement sooner. Under normal driving conditions, spark plugs require no maintenance between replacement intervals. Wh...

  • Page 177

    2005 volvo s80 hoisting the car if a garage jack is used to lift the car, the two jack attachments points should be used. They are specially reinforced to bear the weight of the car. A garage jack can also be placed under the front of the engine support frame. Take care not to damage the splash guar...

  • Page 178

    2005 volvo s80 ● press up the release control located under the front edge of the hood (at the center) and lift. Warning! Check that the hood locks properly when closed. Engine compartment 1 expansion tank - coolant 2 oil filler cap - engine 3 dipstick - engine oil 4 brake fluid reservoir 5 battery ...

  • Page 179

    2005 volvo s80 engine oil must meet the minimum ilsac specification gf-2, including acea a1, api sj, sj/cf and sj/energy conserving. Your volvo has been certified to standards using ilsac oil specification gf-2 5w-30. Volvo recommends use of oil with a quality rating equal to or higher than ilsac gf...

  • Page 180: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 9 - specifications pg. 143 specifications label information 144 dimensions and weights 145 engine specifications 146 oil/fluid specifications and volumes 147 fuel system, distributor ignition system, suspension 148 electrical system 149 on call roadside assis...

  • Page 181

    2005 volvo s80 4 model plate vehicle identification number (vin). Codes for color and upholstery, etc. The plate is located in the engine compartment, on the inside of the left front fender. 5 vehicle identification number (vin) * the vin plate is located on the top left surface of the dashboard. Th...

  • Page 182

    2005 volvo s80 pg. 145 dimensions and weights dimensions length 190.9 in. (485 cm) width 72.1 in. (183 cm) height 57.2 in. (145 cm) wheelbase 109.9 in. (279 cm) track, front 62.3 in. (158 cm) track, rear 61.4 in. (156 cm) turning circle (between curbs) 35.8 - 39 ft. (10.9 - 12 m) cargo capacity - tr...

  • Page 183

    2005 volvo s80 5 cyl. Automatic awd 2440 lbs 1110 kg 6 cyl. Turbo automatic 2491 lbs 1130 kg permissible axle weight, rear 5 cyl. Automatic 2293 lbs - 5 cyl. Automatic awd 2400 lbs 1090 kg 6 cyl. Turbo automatic 2293 lbs 1040 kg max roof load 220 lbs 100 kg max trailer weight (w/o brakes) 1650 lbs 7...

  • Page 184

    2005 volvo s80 bore 3.27" (83 mm) stroke 3.54" (90 mm) displacement 2.92 liters (115 cu. In.) compression ratio 8.5:1 number of valves 24 charge air cooler (intercooler) turbocharged engines employ a turbo-compressor to force air into the engine inlet manifold and a charge air cooler to cool the com...

  • Page 185

    2005 volvo s80 automatic transmission fluid total volume: 7.6 us qts (7.2 liters). Type: jws 3309 different types of oil should never be mixed. Cooling system type: positive pressure, closed system. The thermostat begins to open at 194 °f (90 °c). Coolant: volvo original coolant/antifreeze. Volume: ...

  • Page 186

    2005 volvo s80 firing order: 15-3-6-2-4 distributor ignition setting: not adjustable spark plugs: b 6284 t: p/n 271367-4 (or equivalent) b 5254 t2: champion rc8pyp 8 (or equivalent) spark plug gap: 0.028-0.032" (0.7-0.8 mm) tightening torque: 18.4 ft. Lbs. (25 nm) warning! The distributor ignition s...

  • Page 187

    2005 volvo s80 bulbs bulb type socket 1. High/low beams 55w h7 2. Bi-xenon headlight (option) 35w d2r 3. Front foglights 55w h1 4. Front parking lights, rear side marker lights, rear footwell lighting w5w w2.1x9.5d front side marker lights w3w w2.1x9.5d 5. Front turn signals py21w bau 15s 6. Side tu...

  • Page 188

    2005 volvo s80 12 volt, negative ground. Voltage-controlled generator. Single-wire system with chassis and engine used as conductors. Grounded on chassis. Battery voltage: 12 volt, capacity: 600 a/115 min. Reverse capacity the battery contains corrosive and poisonous acids. It is of the utmost impor...

  • Page 189

    2005 volvo s80 technician certification in addition to volvo factory training, volvo supports certification by the national institute for automotive excellence (a.S.E.). Certified technicians have demonstrated a high degree of competence in specific areas. Besides passing exams, each technician must...

  • Page 190: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 chapter 10 - audio systems pg. 151 audio systems introduction 152 hu-650 overview 153 hu-850 overview 154 audio functions hu-650/hu-850 155 radio functions hu-650/hu-850 157 cd player hu-650 162 internal cd changer - hu-850 163 external cd changer (option) - hu-650/h...

  • Page 191

    2005 volvo s80 the audio system is available in two versions: hu-650 features: am/fm radio, single-disc cd player, cassette player, 4x25w output, six speakers. Hu-850 features: am/fm radio, integrated 6-disc cd changer, 4x50w or 4x70w output plus 25w dolby pro logic ii, eleven speakers. Compact disc...

  • Page 192

    2005 volvo s80 · keep tapes away from oil, grease and other contaminants. · for optimal tape deck performance volvo does not recommend the use of c-120 tapes. · take up slack using a pen or a pencil before inserting a cassette in the cassette slot. Cassette cleaning we recommend the use of the volvo...

  • Page 193

    2005 volvo s80 6. Scan function (automatically search for radio stations) 7. Navigations buttons (seek/change radio station or cd track) 8. Cd eject 9. Cd slot 10. Cd random play 11. Fm 12. Am 13. Cd player 14. Automatically search for radio stations 15. Bass - press and turn treble - press to relea...

  • Page 194

    2005 volvo s80 6. Source/menu press to open main menu turn to select fm, am, cd, cd changer (option), selecting a disc 7. Exit (exit the menu) 8. Scan function (automatically search for radio stations) 9. Navigations buttons (seek/change radio station or cd track) 10. Cd eject 11. Dolby pro logic ii...

  • Page 195

    2005 volvo s80 after the bulletin has been completed, the audio system reverts to the originally selected sound source (radio or cd), which is played at the volume that was selected for that source. If the bulletin volume is adjusted while the bulletin is being broadcast, this new volume is saved an...

  • Page 196

    2005 volvo s80 fader - balance front/rear adjust front/rear speaker balance by pressing the button to extend the control and turning it to the left (more sound from the rear speakers) or to the right (more sound from the front speakers). A "detent" indicates "equalized" balance. Press the button bac...

  • Page 197

    2005 volvo s80 scan press the scan button to start the station scan function. When a station is found, scanning stops for approximately 10 seconds, after which scanning will continue. Press the scan or exit button when a station has been found if you would like to listen to that station and to disco...

  • Page 198

    2005 volvo s80 pg. 158 radio functions hu-650/hu-850 storing stations 1. Tune to the desired station. 2. Press the knob. Choose a number by turning the knob. Press again to store the station. Preset to choose a preset station, turn button to the stored number. The currently selected station is displ...

  • Page 199

    2005 volvo s80 return to the normal radio mode by pressing the am, fm, or exit button or turn the preset/cd knob. To return to the auto-store mode, press the auto button briefly. Pg. 159 radio functions hu-650/hu-850 radio broadcast data system - rbds this feature, which may not be available in your...

  • Page 200

    2005 volvo s80 press fm briefly. Station information will be shown twice in the display. Alarm alarms bulletins are transmitted automatically by certain rbds stations. The function cannot be deactivated. "alarm!" is shown in the radio display when an alarm message is sent. The function is used to wa...

  • Page 201

    2005 volvo s80 the pty symbol in the display turns off and the radio returns to normal. Program type display text off pty off news news current affairs affairs information info sports sport education education drama drama art and culture culture science science entertainment varied pop music pop m r...

  • Page 203

    2005 volvo s80 pg. 161 radio functions hu-650/hu-850 automatic frequency update (af) the af function tunes to the strongest transmitter for the current station, if that station supports alternative frequencies. Af is off by default. To activate/deactivate af: 1. Select radio mode using the fm button...

  • Page 204

    2005 volvo s80 pg. 162 cd player hu-650 starting the cd player please refer to the illustration on page 153 for the location of the buttons referred to on this page. 1. Insert a disc into the player. 2. Press the cd button or turn the source knob to cd. Changing tracks briefly press the keys (or the...

  • Page 205

    2005 volvo s80 starting the cd changer the hu-850 is equipped with an internal, 6-disc cd changer. Please refer to the illustration on page 154 for the location of the buttons referred to on this page. To load discs into the changer: 1. Press the cd button or turn the source knob to cd. 2. Select an...

  • Page 206

    2005 volvo s80 note: · the eject all function can only be used while the vehicle is at a standstill and will be cancelled if the vehicle begins to move. · for reasons of traffic safety, you have 12 seconds in which to remove the ejected disc. After that, the disc automatically reinserts into the pla...

  • Page 207

    2005 volvo s80 changing tracks briefly press the keys (or the corresponding keys on the optional steering wheel keypad) to skip to the previous or next track. The track number is shown in the display. Fast forward/back press and hold down the keys (or the corresponding keys on the optional steering ...

  • Page 208

    2005 volvo s80 tape eject button tape eject if you press this button the tape stops and the cassette is ejected. To select a new mode (radio, cd) turn the "source" button. A cassette can be ejected even if the ignition is switched off. Dolby b noise reduction the function is preset. To switch the fu...

  • Page 209

    2005 volvo s80 same way. See page 152 for information on caring for cassettes. Pg. 166 dolby surround pro logic ii - hu-850 only dolby surround pro logic ii dolby surround pro logic ii is a further development of the previous version of the system and provides enhanced sound quality. The improved so...

  • Page 210

    2005 volvo s80 3 channel stereo to select 3 channel stereo mode press "3-ch". "3 ch" is displayed. Press "off" to return to 2 channel stereo. Pg. 167 dolby surround pro logic ii - hu-850 center level this function is used to set the level of the center speaker in the dashboard. To set the level: 1. ...

  • Page 211

    2005 volvo s80 external amplifier: 4 x 50 w or 4 x 75 w (option) radio frequency range: am 530 - 1710 khz fm 87.7 - 107.9 mhz subwoofer internal amplifier 150 w hu-850 output: 1 x 25 w (center speaker) impedance: 4 ohm. Voltage required: 12 v, negative ground external amplifier: 4 x 50 w or 4 x 75 w...

  • Page 213: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 homelink® universal transceiver (option) pg. 169 homelink® universal transceiver (option) homelink® universal transceiver homelink® is an advanced system that can be programmed to learn the codes of three different remote controlled-devices (e.G., garage door openers...

  • Page 214

    2005 volvo s80 indicator light begins to flash. Then release the buttons. 3. Hold your hand-held transmitter (garage door opener, for example) 2 to 5 in. (5 to 12 cm) away from the homelink® surface, keeping the indicator light in view. For placement questions, contact homelink® toll-free 1-800-355-...

  • Page 215

    2005 volvo s80 manufactured after 1996: ● refer to the garage door opener owner's manual for verification. ● if your hand-held transmitter appears to program the homelink® universal transceiver but the programmed button does not activate the garage door, your garage door opener may have a rolling co...

  • Page 216

    2005 volvo s80 pg. 171 homelink® universal transceiver (option) erasing programmed buttons individual buttons cannot be erased. To erase all three programmed buttons: 1. Turn the ignition key to the "accessory" position (ii). 2. Hold down the two outside buttons on the homelink® universal transceive...

  • Page 217: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 index pg. 173 index a abs..........19 abs - warning light..........29 active chassis system (four-c)..........82 adjusting the steering wheel..........38 air conditioning..........47- 49, 51 air filter - engine..........133 air vents..........46 airbag (sips)...........

  • Page 218

    2005 volvo s80 hu-650 - overview..........153 hu-850 - overview..........154 specifications..........168 automatic car washing..........128 automatic locking retractor (alr)..........16 automatic transmission five speed..........78 four speed..........76 geartronic..........80 auxiliary socket.........

  • Page 219

    2005 volvo s80 chassis setting ..........82 child booster cushion ......... 15 child restraint anchorages ........ 14 child safety..........14 -17 child safety locks - rear doors..........69 child seat anchors isofix ........ 14 climate controls..........47 - 49, 51 climate system - general informat...

  • Page 220

    2005 volvo s80 electrical system - general information..........85 electrically operated front seats..........54 electrically operated moonroof..........43 electrically operated sideview mirrors..........42 electrically operated windows..........41 electronic brake force distribution..........19 ele...

  • Page 221

    2005 volvo s80 front suspension..........148 fuel..........72 , 147 fuel filler cap..........74 fuel filler door..........74 fuel filler door - unlocking manually..........35 fuel filter ..........133 fuel gauge..........27 fuel requirements..........72 fuel system..........131 , 133 , 148 fuel/emis...

  • Page 222

    2005 volvo s80 home safe system..........62 homelink® ........169, 170, 171 hood - opening..........135 i ignition switch..........38 immobilizer (start inhibitor)..........65 , 75 indicator lights..........28, 29 inflatable curtain (ic)..........11 inflation pressure tables..........101 instrument ...

  • Page 223

    2005 volvo s80 lifting the car..........134 load carriers..........86 locking and unlocking the car..........62 locking steering wheel..........38 long distance trip..........94 long loads..........55 m maintenance service..........130 malfunction indicator lamp..........29 manually unlocking the fu...

  • Page 224

    2005 volvo s80 power moonroof..........43 power seats..........54 power steering - speed-sensitive..........85 power steering fluid ........ 138 , 147 power windows..........41 r radio..........153, 154 radio broadcast data system - rbds..........159 rain sensor - windshield wipers..........37 readi...

  • Page 225

    2005 volvo s80 run flat tires..........103 s safety defects - reporting..........13 safety locks - child..........69 seat belt maintenance..........13 seat belts..........2, 3 , 16 seat belts - cleaning..........129 seats - front..........54 self supporting run flat tires..........103 servicing........

  • Page 226

    2005 volvo s80 suspension..........148 switches in center console ........ 31 t tachometer..........27 tail light bulbs - replacing ........ 121 temperature gauge..........27 text window..........30 three-way catalytic converters..........95, 96 timing belt..........133 tire inflation..........99 ti...

  • Page 227

    2005 volvo s80 vanity mirror lights - replacing..........122 vehicle identification number (vin)..........144 vehicle loading..........148 ventilation..........46 ventilation hose, battery ........139 volumes (oils and fluids) ........147 volvo on call..........150 w warning lights..........28, 29 w...

  • Page 228: 2 0 0 5

    2005 volvo s80 2 0 0 5 volvo s80 back cover back cover accessory installation - important warning ● we strongly recommend that volvo owners install only genuine, volvo-approved accessories, and that accessory installations be performed only by the factory-trained technicians at your authorized volvo...

  • Page 229

    2005 volvo s80 driving safely. Distraction can lead to a serious accident. ● in addition to this general warning, we offer the following guidance regarding specific newer features that may be found in your vehicles: ● never use a hand-held cellular telephone while driving. Some jurisdictions prohibi...

  • Page 230

    2005 volvo s80 4 engine oil level should be between the dipstick marks. The distance between the marks represents approx. 1.6 us qts (1.5 liters). See page 136. 5 brake fluid - check, without removing the cap, that the level is above the min mark. Use brake fluid dot 4+. See page 138. * engine oil s...