Wacker Neuson G2.5A Operator's Manual - Foreword

Other manuals for G2.5A: Operator's Manual, Repair Manual

Page of 22

Download

Print this page

Bookmark us

Foreword

wc_tx000001gb.fm

Engine exhaust, some of its constituents, and certain vehicle

components contain or emit chemicals known to the State of California

to cause cancer and birth defects or other reproductive harm.

Foreword

This manual provides information and procedures to safely operate

and maintain this Wacker model. For your own safety and protection

from injury, carefully read, understand and observe the safety

instructions described in this manual.

Keep this manual or a copy of it with the machine. If you lose this

manual or need an additional copy, please contact Wacker

Corporation. This machine is built with user safety in mind; however,

it can present hazards if improperly operated and serviced. Follow

operating instructions carefully! If you have questions about operating

or servicing this equipment, please contact Wacker Corporation.

The information contained in this manual was based on machines in

production at the time of publication. Wacker Corporation reserves the

right to change any portion of this information without notice.

All rights, especially copying and distribution rights are reserved.

No part of this publication may be reproduced in any form or by any

means, electronic or mechanical, including photocopying, without

express written permission from Wacker Corporation.

Any type of reproduction or distribution not authorized by Wacker

Corporation represents an infringement of valid copyrights and will be

prosecuted. We expressly reserve the right to make technical

modifications, even without due notice, which aim at improving our

machines or their safety standards.

WARNING

« ‹ Prev 1 2 3 4 5 6 7 Next › »

Summary of G2.5A

Page 1
Www.Wackergroup.Com generator g 2.5a operator's manual 0152792en 00 2 0902 0 1 5 2 7 9 2 e n.
Page 2
Danger carbon monoxide using a generator indoors can kill you in minutes. Generator exhaust contains carbon monoxide (co). This is a poison you cannot see or smell. If you can smell the generator exhaust, you are breathing co. But even if you cannot smell the exhaust, you could be breathing co. • ne...
Page 3: Foreword
Foreword wc_tx000001gb.Fm engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the state of california to cause cancer and birth defects or other reproductive harm. 1. Foreword this manual provides information and procedures to safely operate an...
Page 4
G2.5a ii serial number numéro de série my machine’s numbers are / les numéros de ma machine sont : revision niveau de revision item number numéro de référence model number modèle g2.5a 0009256 101 5010101 nameplate / plaque signalétique a nameplate listing the model number, item number, revision, an...
Page 5: G2.5A
G2.5a operating information 1a 1a-1 1.1 safety information .............................................................................. 1a-2 1.2 operating safety ................................................................................ 1a-3 1.3 operator safety while using internal combustio...
Page 6
1a-2 1a operation g2.5a laws pertaining to spark arresters notice: some local authorities require that in certain locations, spark arresters be used on internal combustion engines. A spark arrester is a device designed to prevent the discharge of sparks or flames from the engine exhaust. It is often...
Page 7
1a-3 g2.5a operation 1a 1.2 operating safety familiarity and proper training are required for the safe operation of electrical equipment! Equipment operated improperly or by untrained personnel can be dangerous! Read the operating instructions and familiarize yourself with the location and proper us...
Page 8
1a-4 1a operation g2.5a 1.4 service safety poorly maintained equipment can become a safety hazard! In order for the equipment to operate safely and properly over a long period of time, periodic maintenance and occasional repairs are necessary. If the generator is experiencing problems or is being se...
Page 9
1a-5 g2.5a operation 1a maximum output w 2500 continuous output w 2250 type single voltage, single phase, brushless system ac voltages available volts phase 120 1ø frequency hz 60 power factor 1.0 ac receptacles 120v gfi duplex amp 15 120v duplex amp 15 main circuit breaker amp 20 l x w x h in. (mm)...
Page 10: Danger
1a-6 1a operation g2.5a 1.6 safety and operating labels this wacker machine uses international pictorial labels where needed. These labels are described below: turn engine switch to "off" position. Close choke. 1 2 3 4 5 1 2 close fuel flow valve. Open choke. Pull rewind starter. Turn engine switch ...
Page 11
1a-7 g2.5a operation 1a 1.7 label locations 1 2 3 4 5 1 2 88 89 7 gnd stop danger gefahr peligro danger caution precaution precaucion vorsicht warning warnung advertencia avertissement improper connection of generator to a building's electrical system can allow electrical current from the generator ...
Page 12
1a-8 1a operation g2.5a 1.8 application and power requirements chart 1 : approximate starting power requirements incandescent lights and appliances such as irons and hot plates, which use a resistive-type heating element, require the same wattage to start and run as is stated on their nameplates. Fl...
Page 13
1a-9 g2.5a operation 1a 1.11 indoor operation if the generator must be operated indoors, adequate ventilation or exhaust hoses must be provided. When venting exhaust fumes, make sure the exhaust piping is large enough to prevent excessive back pressure to the engine. Back pressure reduces engine eff...
Page 14
1a-10 1a operation g2.5a 120 vac 20 amp a d e b c wc_gr000268 1.15 before starting 1. Read and understand safety and operating instruc- tions at beginning of this manual. 2. Read and understand the meanings of all warning and operating labels. 3. Inspect generator for any signs of damage which may a...
Page 15
1a-11 g2.5a operation 1a f c 2 c 1 1015sd03 1015sd04 1005sd47 1005sd49 e 1 e 2 choke d 1 d 2 1.16 to start before starting, be sure you read and understand all the safety and operating instructions in this manual. 1. Disconnect all loads from the generator. 2. Open fuel valve by moving lever to the ...
Page 16
1a-12 1a operation g2.5a 1.19 engine maintenance the periodic maintenance schedule below lists basic maintenance intervals for the engine and generator. Please read the detailed maintenance procedures for the engine described in engine owner’s manual. This manual was supplied with the generator. Rep...
Page 17
1a-13 g2.5a operation 1a 1.23 servicing air cleaner the engine is equipped with a dual element air cleaner— service frequently to prevent carburetor malfunction. Caution: never run engine without air cleaner. Severe engine damage will occur. E d 1001sd13 1001sd12 1.24 cleaning sediment cup turn fuel...
Page 18
1a-14 1a operation g2.5a 1.27 transporting when transporting the generator: 1. Turn the engine fuel valve to the off position. 2. Position the generator level to prevent fuel from spilling. 3. Secure the generator by tying it down with suitable rope. Let engine cool before transporting generator or ...
Page 19
1a-15 g2.5a operation 1a 1.28 storage before storing generator for a long period of time: 1. Close the fuel valve and remove and empty sediment cup under carburetor. 2. Disconnect the fuel line from the carburetor. Place open end of fuel line into a suitable container and open fuel valve to drain fu...
Page 20
1a-16 1a operation g2.5a 1.30 wiring schematic wire colors b - black w- white g - green y - yellow l - blue br- brown r - red t - tan o - orange b g w/y g/y b/r 20a b/y 120v ac b y g/y 20a 20a 120v ac b a r 1 w r w 2 3 b 4 b 25 uf 400 v g/w g wc_gr000262 bc 1 2 3 4 5 7 6 0 1 a= generator b= control ...
Page 21
Deutschland 80809 mÜnchen preussenstr. 41 tel. 089/35 40 21 fax 089/35 40 23 90 85757 karlsfeld (wlz) tel. 018131-59780 21109 hamburg fax 040/75 73 90 tel. 040/75 15 66 24145 kiel fax 0431/71 46 25 tel. 0431/71 15 25 23566 lübeck fax 0451/62 56 15 tel. 0451/62 56 19 28307 bremen-mahndorf fax 0421/48...
Page 22
Wacker corporation - p. O. Box 9007 - menomonee falls, wi 53052-9007 - tel.: (262)-255-0500 - fax: (262)-255-0550 wacker-werke gmbh & co. Kg - preußenstraße 41 - 80809 münchen - tel.: +49-(0)89-354 02-0 - fax: +49-(0)89-35 402-390 united states corporate office menomonee falls, wi 53052 n92 w15000 a...