- DL manuals
- Wacker Neuson
- Engine
- WM 130
- Operator's Manual
Wacker Neuson WM 130 Operator's Manual
Summary of WM 130
Page 1
Www.Wackergroup.Com engine wm 130 wm 170 wm 270 operator’s manual 0156647en 002 0 4 05 0 1 5 6 6 4 7 e n.
Page 3: Wm 130/170/270
Wm 130/170/270 table of contents wc_bo0156647002entoc.Fm 1 1. Foreword 2 2. Emission control system information 3 3. Safety information 16 3.1 laws pertaining to spark arresters .................................................... 16 3.2 operating safety ................................................
Page 4
Wc_tx000001gb.Fm 2 california proposition 65 warning: engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the state of california to cause cancer and birth defects or other reproductive harm. 1. Foreword this manual provides information and pro...
Page 5: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 3 2. Emission control system information source of emissions the combustion process produces carbon monoxide, oxides of nitrogen, and hydrocarbons. Control of hydrocarbons and oxides of nitrogen is very important because, under cert...
Page 6: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 4 replacement parts the emission control systems on your wacker engine were designed, built, and certified to conform with epa and california emissions regulations. We recommend the use of genuine wacker parts whenever you have main...
Page 7: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 5 methanol - (methyl or wood alcohol) 5% by volume. You may use gasoline containing up to 5% methanol by volume, as long as it contains cosolvents and corrosion inhibitors to protect the fuel system. Gasoline containing more than 5%...
Page 8: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 6 emissions component defect warranty coverage this emission warranty is applicable in all states, except the state of california. Wacker corporation, n92 w15000 anthony avenue, menomonee falls, wi 53051-1504, (herein "wacker") warr...
Page 9: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 7 parts covered listed below are the parts covered by the emission components defect warranty. Some of the parts listed below may require scheduled maintenance and are warranted up to the first scheduled replacement point for that p...
Page 10: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 8 obtaining warranty service to obtain warranty service, take your engine to the nearest authorized wacker service dealer. Bring your sales receipts indicating date of purchase for this engine. The service dealer authorized by wacke...
Page 11: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 9 things you should know about the emission control system warranty: maintenance and repairs you are responsible for the proper maintenance of the engine. You should keep all receipts and maintenance records covering the performance...
Page 12: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 10 california emission control warranty statement your warranty rights and obligations the california air resources board is pleased to explain the emission control system warranty on your 2003 and newer wacker engine. In california...
Page 13: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 11 limited warranty on emission control systems - california only - wacker warrants to the owner of the 2003 and later engine that the engine (1) has been designed, built and equipped so as to conform at the time of manufacture with...
Page 14: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 12 d. What is not covered 1. This limited warranty does not cover any part which malfunctions, fails or is damaged due to failure to follow the maintenance and operating instructions set forth in the 2003 and later owner's manual in...
Page 15: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 13 g. Maintenance, replacement and repair of emission- related parts only warranted engine replacement parts approved by wacker should be used in the performance of any warranty maintenance or repairs on emission-related parts. If o...
Page 16: Wm 130/170/270
Emission control system information wm 130/170/270 wc_tx000239gb.Fm 14 i. Maintenance statements it is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2003 and later owner's manual and to retain proof that inspection and mainten...
Page 17: Wm 130/170/270
Wm 130/170/270 emission control system information wc_tx000239gb.Fm 15 air index to show compliance with california emission regulations, a hangtag has been provided displaying the air index level and durability period of this engine. The air index level defines how clean an engine’s exhaust is over...
Page 18: Safety Information
Safety information wm 130/170/270 wc_si000090gb.Fm 16 3. Safety information this manual contains danger, warning, caution, and note callouts which must be followed to reduce the possibility of personal injury, damage to the equipment, or improper service. This is the safety alert symbol. It is used ...
Page 19: Wm 130/170/270
Wm 130/170/270 safety information wc_si000090gb.Fm 17 3.2 operating safety familiarity and proper training are required for the safe operation of equipment! Equipment operated improperly or by untrained personnel can be dangerous! Read the operating instructions contained in this manual and familiar...
Page 20: Safety Information
Safety information wm 130/170/270 wc_si000090gb.Fm 18 3.3 operator safety while using internal combustion engines internal combustion engines present special hazards during operation and fueling! Read and follow all warning instructions and safety guidelines in this manual. Failure to follow warning...
Page 21: Wm 130/170/270
Wm 130/170/270 safety information wc_si000090gb.Fm 19 3.4 service safety poorly maintained equipment can become a safety hazard! In order for the equipment to operate safely and properly over a long period of time, periodic maintenance and occasional repairs are necessary. 3.4.1 do not attempt to cl...
Page 22: Safety Information
Safety information wm 130/170/270 wc_si000090gb.Fm 20 3.5 safety labels wacker machines use international pictorial labels where needed. These labels are described below: label meaning read the operator's manual for machine infor- mation. Warning! Hot surface! Danger! Engines emit carbon monoxide; o...
Page 23: Wm 130/170/270
Wm 130/170/270 technical data wc_td000091gb.Fm 21 4. Technical data wm 130 wm 170 wm 270 engine type 4-stroke, overhead valve, single cylinder engine make wacker rated power kw (hp) 3.2 (4.3) 4. 2 ( 5 . 7 ) 6.6 (9.0) displacement cm³ (in³) 126 (7.69) 169 (10.31) 265 (16.17) engine speed - max. Rpm 4...
Page 24: Operation
Operation wm 130/170/270 wc_tx000241gb.Fm 22 5. Operation 5.1 recommended fuel this engine is certified to operate on automotive unleaded gasoline. Use only fresh, clean gasoline. Gasoline containing water or dirt will damage fuel system. 5.2 before starting 5.2.1 read and understand safety and oper...
Page 25: Wm 130/170/270
Wm 130/170/270 operation wc_tx000241gb.Fm 23 5.3 to start see graphic: wc_gr000655 5.3.1 open fuel valve by moving lever down (a1). Note: if engine is cold, move choke lever to close position (d2). If engine is hot, set choke to open position (d1). 5.3.2 turn engine switch to “on” (b2). 5.3.3 open t...
Page 26: Maintenance
Maintenance wm 130/170/270 wc_tx000242gb.Fm 24 6. Maintenance 6.1 periodic maintenance schedule maintenance, replacement or repair of emission control devices and systems may be performed by any repair establishment or individual. Daily before starting after first 20 hours every 2 weeks or 50 hrs. E...
Page 27: Wm 130/170/270
Wm 130/170/270 maintenance wc_tx000242gb.Fm 25 6.2 spark plug see graphic: wc_gr000028 clean or replace spark plug as needed to ensure proper operation. The muffler becomes very hot during operation and remains hot for a while after stopping the engine. Do not touch the muffler while it is hot. Note...
Page 28: Maintenance
Maintenance wm 130/170/270 wc_tx000242gb.Fm 26 6.3 engine oil see graphic: wc_gr000087 6.3.1 drain oil while engine is still warm. Note: in the interests of environmental protection, place a plastic sheet and a container under the machine to collect any liquid which drains off. Dispose of this liqui...
Page 29: Wm 130/170/270
Wm 130/170/270 maintenance wc_tx000242gb.Fm 27 6.5 air cleaner see graphic: wc_gr000656 never use gasoline or other types of low flash point solvents for cleaning the air cleaner. A fire or explosion could result. Caution: never run engine without air cleaner. Severe engine damage will occur. The en...
Page 30: Maintenance
Maintenance wm 130/170/270 wc_tx000242gb.Fm 28 6.6 storage if machine is being stored for more than 30 days: 6.6.1 drain fuel from tank. Start engine and run until remaining fuel is used. 6.6.2 remove spark plug. Pour approximately 5 cc of clean sae 10w30 engine oil into cylinder through spark plug ...
Page 32
Wacker construction equipment ag · preußenstraße 41 · d-80809 münchen · tel.: +49-(0)89-3 54 02 - 0 · fax: +49 - (0)89-3 54 02-3 90 wacker corporation · p.O. Box 9007 · menomonee falls, wi 53052-9007 · tel. : (262) 255-0500 · fax: (262) 255-0550 · tel. : (800) 770-0957 wacker asia pacific operations...