1. DL manuals
  2. Waeco
  3. Battery Charger
  4. IU152A
  5. Installation And Operating Manual

Waeco IU152A Installation And Operating Manual - Iu152A

Manual is about: IU0U Automatic Charger

Summary of IU152A

  • Page 1

    Perfectcharge iu152a, iu154a, iu252a, iu254a, iu452a i phase iu phase u phase on of f slee p mode i ii 0 de 11 iu0u-automatiklader montage- und bedienungsanleitung en 33 iu0u automatic charger installation and operating manual fr 54 chargeur automatique de batteries iu0u instructions de montage et d...

  • Page 2

    Perfectcharge 3 i p ha se iu p ha se u p ha se off on i ii 0 sleep mode 1 3 2 5 4 6 1 i phase iu phase u phase on off sleep mode i ii 0 2 3 1 2 _perfectcharge_iu152a-iu254a.Book seite 3 mittwoch, 26. März 2008 4:48 16.

  • Page 3: Iu254A, Iu452A

    Perfectcharge 4 ts start batt + 230 v ac input batt + batt - rc rc ts batt 1+ batt 2+ batt 3+ batt - 230 v ac input batt 3+ batt 2+ batt 1+ batt - rc ts 230 v ac input 3 4 2 1 iu254a, iu452a 3 4 2 1 1 3 2 4 iu154a, iu252a iu152a 3 _perfectcharge_iu152a-iu254a.Book seite 4 mittwoch, 26. März 2008 4:4...

  • Page 4

    Perfectcharge 5 1. 2. I p ha se iu p ha se u p ha se on off i ii 0 sleep mode 4 230 v ac input 2 1 5 _perfectcharge_iu152a-iu254a.Book seite 5 mittwoch, 26. März 2008 4:48 16.

  • Page 5

    Perfectcharge 6 i p h ase iu p h ase u p has e o n o f f sl eep m o d e i ii 0 2 1 6 i p ha se iu p ha se u p ha se o n of f sl ee p m od e i ii 0 2 3 4 1 7 _perfectcharge_iu152a-iu254a.Book seite 6 mittwoch, 26. März 2008 4:48 16.

  • Page 6: Iu152A

    Perfectcharge 7 230 v ac input 1 2 5 4 3 8 iu152a ts start batt + 230 v ac input batt + batt - rc + _ + _ 12 v 12 v 9 _perfectcharge_iu152a-iu254a.Book seite 7 mittwoch, 26. März 2008 4:48 16.

  • Page 7: Iu154A

    Perfectcharge 8 iu154a rc ts batt 1+ batt 2+ batt 3+ batt - 230 v ac input + _ + _ 24 v + _ + _ 24 v + _ + _ 24 v 0 iu252a rc ts batt 1+ batt 2+ batt 3+ batt - 230 v ac input + _ + _ + _ 12 v 12 v 12 v a _perfectcharge_iu152a-iu254a.Book seite 8 mittwoch, 26. März 2008 4:48 16.

  • Page 8: Iu254A

    Perfectcharge 9 iu254a rc ts batt 2+ batt 1+ batt 3+ batt - 230 v ac input + _ + _ 24 v + _ + _ 24 v + _ + _ 24 v b iu452a batt 2+ batt 3+ batt 1+ batt - rc ts 230 v ac input + _ + _ + _ 12 v 12 v 12 v c _perfectcharge_iu152a-iu254a.Book seite 9 mittwoch, 26. März 2008 4:48 16.

  • Page 9

    Perfectcharge 10 230 v a c inpu t 1 2 3 d _perfectcharge_iu152a-iu254a.Book seite 10 mittwoch, 26. März 2008 4:48 16.

  • Page 10: Table of Contents

    Perfectcharge 33 please read this manual carefully before installing and starting up the device, and store it in a safe place. If the device is passed on to another person, this manual must also be handed over with it. Table of contents 1 notes on using the manual . . . . . . . . . . . . . . . . . ....

  • Page 11: Notes On Using The Manual

    Notes on using the manual perfectcharge 34 1 notes on using the manual d caution! Safety instruction: failure to observe this instruction can cause material damage or personal injury. A caution! Safety instruction: failure to observe this instruction can cause material damage and impair the function...

  • Page 12: General Safety Instructions

    Perfectcharge general safety instructions 35 2 general safety instructions the manufacturer will not be held liable for claims for damage resulting from the following: z faulty assembly or connection z damage to the appliance resulting from mechanical influences and excess voltage z alterations to t...

  • Page 13: 2.2

    General safety instructions perfectcharge 36 a z use the iu0u automatic charger only as intended. Z charge the battery only in well ventilated rooms. Z always disconnect the power supply when working on the de- vice. Z store the iu0u automatic charger in a dry and cool place. Z maintenance and repai...

  • Page 14: Scope of Delivery

    Perfectcharge scope of delivery 37 3 scope of delivery 4 accessories 5 intended use perfectcharge iu0u automatic chargers can charge or trickle charge batter- ies or supply batteries, which are used to generate power in vehicles or on boats. The iu0u automatic charger can be used to continuously cha...

  • Page 15: Technical Description

    Technical description perfectcharge 38 the iu0u automatic charger can be used to charge the following types of bat- teries: z lead starter batteries z gel batteries z fleece batteries (agm) z maintenance-free lead batteries with the capacities and voltages specified in the chapter “technical data” o...

  • Page 16: 6.2

    Perfectcharge technical description 39 three control lamps on the device are for constant monitoring of the iu0u au- tomatic charger (see chapter “functional check” on page 49). 6.2 specifications for the device variants various perfectcharge iu0u automatic charger versions are available. Your iu0u ...

  • Page 17

    Fastening the iu0u automatic charger perfectcharge 40 rear view (fig. 3, page 4) 7 fastening the iu0u automatic charger you can fasten the iu0u automatic charger using the four holders supplied. When selecting the installation location, observe the following instructions: z you can mount the iu0u au...

  • Page 18

    Perfectcharge connecting the iu0u automatic charger to the exhaust system 41 fastening the iu0u automatic charger to the floor ➤ clip two holders on the left bar and two on the lower right bar (fig. 4, page 5). You can move the holders as required. ➤ fasten the iu0u automatic charger by screwing one...

  • Page 19: Charger

    Connecting the iu0u automatic charger perfectcharge 42 9 connecting the iu0u automatic charger a caution the iu0u automatic charger may only be connected by a qualified specialist. The following information is intended for technicians who are famil- iar with the guidelines and safety precautions to ...

  • Page 20

    Perfectcharge connecting the iu0u automatic charger 43 a note loose connections may cause overheating. Tighten the screws on the terminals to a torque of 12 – 13 nm. I note iu152a: to connect starter batteries, use the special “start batt +” terminal intended for this purpose. I note iu154a, iu252a:...

  • Page 21: 9.2

    Connecting the iu0u automatic charger perfectcharge 44 connecting the battery cables to the iu0u automatic charger i note the iu0u automatic charger's connections are suitable for cables with cross-sections of 10 mm² to 25 mm². ➤ fit wire sleeves to the ends of the cables to ensure permanent contact...

  • Page 22: 9.3

    Perfectcharge using the iu0u automatic charger 45 9.3 connecting the temperature sensor (accessory) the temperature sensor measures the temperature at the battery or around the battery and transfers the data to the iu0u automatic charger. The charg- ing voltages specified in the chapter “technical d...

  • Page 23: 10.1

    Using the iu0u automatic charger perfectcharge 46 10.1 setting the iu0u automatic charger (fig. 8, page 7) charging voltage and time limit i note ask your battery retailer for details on the charging voltage and time limit required for your batteries. A caution make sure that the device is never use...

  • Page 24: 10.2

    Perfectcharge using the iu0u automatic charger 47 setting the duration of the main charging phase: setting the charging mode: 10.2 switching the device on and off with the remote control (accessory) ➤ turn the main switch on the iu0u automatic charger (fig. 2 1, page 3) to “sleepmode” to switch the ...

  • Page 25

    Using the iu0u automatic charger perfectcharge 48 i phase the empty battery is charged with a constant current at the beginning of the charging process, until the battery voltage reaches 13.8 v or 27.6 v. The charging current falls slowly when the battery has reached this charging lev- el. If the cu...

  • Page 26: 10.4

    Perfectcharge using the iu0u automatic charger 49 devices with temperature sensors (accessory) the charging voltage is adjusted according to the battery temperature. A temperature sensor can be connected for an optimum charging function. The charging voltage is increased or reduced according to the ...

  • Page 27: Matic Charger

    Cleaning and servicing the iu0u automatic charger perfectcharge 50 11 cleaning and servicing the iu0u auto- matic charger a caution do not use any sharp or hard objects for cleaning since they may damage the device. ➤ clean the iu0u automatic charger with a damp cloth from time to time. 12 rectifyin...

  • Page 28: Guarantee

    Perfectcharge guarantee 51 ➤ have the battery checked by a specialist, if necessary, or dispose of the battery. The battery discharges itself after a short time if it is not used ➤ use a suitable multimeter to check the voltage of the battery terminals. If the multimeter indicates a voltage below 12...

  • Page 29: Technical Data

    Technical data perfectcharge 52 15 technical data waeco perfectcharge iu152a iu252a iu154a item no.: 2222500001 2222500002 2222500003 battery connection 1: starter battery 13,8 v/1 a starter battery 13,8 v/1 a starter battery 27,6 v/1 a battery connection 2: 13,8 – 14,8 v/15 a 13,8 – 14,8 v total ma...

  • Page 30

    Perfectcharge technical data 53 variations, technical improvements and delivery options reserved. Tests/certificates applied to the iu0u automatic charger: product series standard: z iec 60950-1:2001 (1 st edition), en 60950-1: 2001 + a11: 2004 basic standard: z en 55022:2006 class b z en 55024: 199...

  • Page 31: Www.Waeco.Com

    Europe dometic austria gmbh neudorferstrasse 108 2353 guntramsdorf ℡ +43 2236 908070 +43 2236 90807060 mail: info@waeco.At dometic switzerland ag riedackerstrasse 7a ch-8153 rümlang (zürich) ℡ +41 44 8187171 +41 44 8187191 mail: info@waeco.Ch dometic denmark a/s tværvej 2 dk-6640 lunderskov ℡ +45 75...