- DL manuals
- Waldorf
- Ranges
- RN8610E
- Installation And Operation Manual
Waldorf RN8610E Installation And Operation Manual
Summary of RN8610E
Page 1
I n s t a l l a t i o n a n d o p e r a t i o n m a n u a l series rn8610e rn8610ec electric range date purchased serial number dealer service provider 230559-9 for use in gb & ie rnl8610e rnl8610ec.
Page 2
The reproduction or copying of any part of this manual by any means whatsoever is strictly forbidden unless authorized previously in writing by the manufacturer. In line with policy to continually develop and improve its products, moffat ltd. Reserves the right to change the specifications and desig...
Page 3
1 waldorf electric ranges convection / static ovens - 900 mm rn(l)610e electric range static oven. Rn(l)8613e electric range static oven. Rn(l)8616e electric range static oven. Rn(l)8619e electric range static oven. Rn(l)8610ec electric range convection oven. Rn(l)8613ec electric range convection ov...
Page 4
2 introduction we are confident that you will be delighted with your waldorf electric range and it will become a most valued appliance in your commercial kitchen. To ensure you receive the utmost benefit from your new waldorf electric range, there are two important things you can do. Firstly: please...
Page 5
3 specifications model numbers covered in this specification rn[1]8610e electric range static oven + 6 radiant elements. Rn[1]8613e electric range static oven + 4 radiant elements + 300 mm griddle. Rn[1]8616e electric range static oven + 2 radiant elements + 600 mm griddle. Rn[1]8619e electric range...
Page 6
4 dimensions rn(l)8610e / rn(l)8610e / ec rn(l)8613e / rn(l)8619e / rn(l)8616e / hob options.
Page 7
5 installation requirements note: • it is most important that this electric range static / convection oven is installed correctly and that operation is correct before use. Installation shall comply with local electrical and health and safety requirements. • this appliance shall be installed with suf...
Page 8
6 assembly all models this model is delivered completely assembled. Ensure that the legs are securely attached. Note: • this appliance is fitted with adjustable feet to enable it to be positioned securely and level on uneven floors. This should be carried out on completion of the gas connection. Ref...
Page 9
7 electrical connection note: all electrical connections must only be carried out by an authorised person. Each appliance should be connected to an adequately protected power supply and isolation switch mounted adjacent to, but not behind the appliance. This switch must be clearly marked and readily...
Page 10
8 commissioning 1. Before leaving the new installation; a. Check the following functions in accordance with the operating instructions specified in the ‘operation’ section of this manual. • check the current draw and loading for the equipment. Refer to the 'specifications' section for correct electr...
Page 11
9 operation guide 1. Waldorf electric range static / convection ovens have been designed to provide simplicity of operation. They can be fitted with 300 mm, 600 mm or 900 mm griddle option depending on range size. 2. Improper operation is therefore almost impossible, however bad operation practices ...
Page 12
10 hob element / griddle options radiant elements (solid or open) the controls for the radiant elements may be set at any position between high and low to provide the desire level of heating. An individual green neon for each element, will glow when the element is switched 'on' to show that there is...
Page 13
11 oven the oven is fitted with top and bottom elements. The thermostat maintains the overall oven temperature. The top element is further controlled by the oven top heat control. Convection ovens (rn8610ec) are fitted with a circulation fan. Note: the thermostat on the oven provides overall control...
Page 14
12 general clean the range regularly. A clean appliance looks better, will last longer and will perform better. Carbonised grease on the surface or on the griddle plate (if fitted) will hinder the transfer of heat from the cooking surface to the food. This will result in loss of cooking efficiency. ...
Page 15
13 cleaning and maintenance daily cleaning 1. The grease drawer should be checked and emptied frequently to prevent overflow and spillage. Remove the grease drawer while still warm so that the grease is in a liquid state. Empty any grease from the drawer and wash thoroughly in the same manner as any...
Page 16
14 weekly cleaning note: • if the range usage is very high, we recommend that the weekly cleaning procedure is carried out on a more frequent basis. • ensure that protective gloves are worn during the cleaning process. • do not use harsh abrasive detergents, strong solvents or caustic detergents as ...
Page 17
15 fault finding this section provides an easy reference guide to the more common problems that may occur during the operation of your appliance. The fault finding guide in this section is intended to help you correct, or at least accurately diagnose problems with your equipment. Although this secti...
Page 18
16 circuit schematics static ovens (rn8610e series).
Page 19
17 circuit schematics convection ovens (rn8610ec series).
Page 20
18 circuit schematics cooktop - 6 elements (rn8610e/ec models) cooktop - 4 elements - 300 mm griddle (rn8613e/ec models).
Page 21
19 circuit schematics cooktop - 2 elements - 600 mm griddle (rn8616e/ec models) cooktop - 900 mm griddle (rn8619e/ec models).
Page 22
20 circuit schematics wiring layout for static oven wiring layout for convection oven wiring connection between oven and hob.
Page 23
21 replacement parts list when ordering replacement parts, please quote the part number and the description as listed below. If the part required is not listed below, request the part by description and quote model number and serial number which is shown on the rating plate. Cooktop 010137 element r...
Page 24
22 oven 228082 oven top element 2kw. 228059 oven bottom element 4.5kw. 228704 door spring kit. (includes 2 springs). 229021 terminal block mains. 229146 thermostat 50 - 300°c. 227963 neon orange. 227962 neon green. 013989 energy regulator. 227398 control knob hi/lo heat. 227399 control knob thermost...
Page 25
23.
Page 26
24.