Wallas SafeFlame 96 D Manual

Manual is about: Oven and stove

Page of 10

Download

Print this page

Bookmark us

SafeFlame 96 D / 97 D

Figure 1: Wallas SafeFlame 96 D Diesel Oven

INSTALLATION INSTRUCTIONS

Figure 4: Minimum dimensions of the space required for installation. If the oven is mounted in a closed space or covered

by a board, the cooling air opening must be reserved above the oven for air circulation, minimum 100 cm

Space Requirements

- The dimensions of the space required for installation

are illustrated in figures 4 and 5.

- Drilling cooling air holes in the bottom of the

installation opening is recommended. Collective area

of the holes should be about 30 cm

- The dimensions of the space required for installation

of the 96 D oven’s control panel are illustrated in

figure 6.

- The gimbal-mounting frame defines the amount of

space required for a gimbal-mounted appliance.

- To remove the burner unit for service, the oven has to

be removed from its position.

- The installation opening must be manufactured from

a fire-resistant material or be lined with a fire-resistant

material.

- Note that the control panel cable for the basic 96 D

is 1.5 m long.

Fuel hoses

- The maximum length of the fuel hose is 8 m; the

standard fuel hose is 4 m.

Considerations on the installation place and on its effect on the installation

Figure 2: Wallas SafeFlame 97 D Diesel Stove

Figure 3: Optional gimbal-mounting 113 for both the oven

and stove

A 4-metre long electric cable and a 4-metre long fuel

pipe with a cork and an internal filter are delivered as

standard.

- The recommended position for the fuel tank is 0.5 –

1 m below the oven.

Exhaust pipes

- The maximum length of the exhaust pipe is 4 m.

Exhaust pipe must be insulated with ø 45 mm

insulation pipe.

- The Combination lead-through may be installed into

the hull or deck.

- The hull lead-through should be situated as far aft as

possible, preferably in the stern.

- If it is possible that the deck lead-through

transiently dips under water it has to be used a

sealable deck lead-through (2460).

- Air must be allowed to flow freely past the lead-

through.

- Take care not to blow hot gases against other boats.

Important:

- You must not mount the 95D cooking range and the

96D oven to the same installation opening. 95D and

96D require an installation opening of their own.

380 mm

min. 20 mm

475 mm

min. 500 mm

360 mm

min. 530 mm

475 mm

min. 100 cm

1 2 3 4 5 6 7 Next › »

Summary of SafeFlame 96 D

Page 1
Safeflame 96 d / 97 d 1 figure 1: wallas safeflame 96 d diesel oven installation instructions figure 4: minimum dimensions of the space required for installation. If the oven is mounted in a closed space or covered by a board, the cooling air opening must be reserved above the oven for air circulati...
Page 2: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 2 figure 5: minimum dimensions of the space required for installation of stove. When installing the stove into a fixed position, the width and depth measurements of the installation opening are identical to those shown in the oven installation diagram 495 mm and 530 mm. Figure ...
Page 3: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 3 30014 30012 30011 figure 11: table 1: - inclusion of a solenoid valve in the fuel hose near the tank is necessary if the tank’s fuel level is above the oven’s or stove’s bottom. - if the fuel tank is more than 0.5 m above or 1.5 m below the oven or stove, check the fuel feed ...
Page 4: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 4 operation instructions 1 2 3 4 5 6 on/off on/off fuel - the main fuels are diesel oil or furnace oil. - paraffin (kerosene) may also be used as fuel. - ensure the purity of the fuel by feeding it through a filter to the appliance. - when starting the appliance for the first t...
Page 5: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 5 figure 14: 1. 2. 3. 4. 5. Power switch on reading parameters self-testing waiting input 15 s running time and temperature can be set set time-delay oven start-up displays temperature and running time remaining power switch off running time ends cooling down 6.The oven is off ...
Page 6: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 6 service instructions regular service - possible crust from the burner should be cleaned in regular service. If necessary, the bottom carpeting of the burner and fuel needle should be changed. - crust develop around the bottom of the burner from the aromatic substances found i...
Page 7: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 7 9. If the bottom carpet remains intact, it can be re- used; otherwise, it must be replaced with a new one. The bottom carpet must be intact at least under the glow plug. Cleaning the cookin range burner 1.In order to clean the burner, you must remove the cooking range’s outer...
Page 8: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 8 table 3: table 2: n o i t c n u f l a m n g i s s n o i t c a g u l p w o l g 1 . R e g u l p w o l g e h t s a h t i s i r o , d e t i u c r i c - t r o h s h t i w k c e h c ; n e k o r b s i h t . R e t e m i t l u m e b o s l a y a m y a l p s i d y l e m e r t x e y b d ...
Page 9: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 9 warnings terms of guarantee - if washing the boat with a pressurised hose, avoid spraying the lead-through; the appliance may get wet. - if the appliance does not start even though there is fuel in the pump, do not start the appliance more than twice without checking for poss...
Page 10: Safeflame 96 D / 97 D
Safeflame 96 d / 97 d 10 accessories accessories for the 96 d oven and the 97 d oven with stove: 111 pot holders for ceramic stove. 113 gimbal-mounting for oven and oven with stove. 11011 extension suction hose 4 m, to extend the fuel pipe if necessary. 2024 5 l fuel tank, if the fuel is not fed dir...