User’s manual ：wy50qt-86 preface thank you for your purchasing the motorcycle wy50qt-86,and sincerely welcome you to join the user of ours. To enjoy a more safe and pleasurable driving ， at first please familiarity with the manual must carry on before driving. Your personal safety depends not only t...
The main items for attention Ÿ the driver and passenger, this motorcycle was limited to one driver and one passenger (except children younger than12 years old). Never exceed the max load capacity of motorcycle. L for the safety, avoid driving the motorcycle in atrocious weather or cold weather (unde...
List i、motorcycle safe driving rules for safe driving………………………1 the payload…………………………………2 ii、the parts & subassemblies and use manual the parts&subassemblies ………………3 meter and indicator light……………………5 fuel meter……………………………………5 ignition switch………………………………6 lock cover switch……………………………6 the light swit...
- 2 - payload warning ※ ： the light goods can only put in the rear shelf or other deposited place. The goods payload cannot heavier than blank 1: blank 1 storage item weight rear shelf 5kg the luggage box 1kg the rear box 5kg the motorcycle max payload is 75kg, including the weight with the driver, ...
- 4 - diagram 2 - 5 - the broken line（……） indicate the parts unseen in the picture mater and indicator light（diagram 3） ⑴ speedometer：during driving, the speed can be showed. ⑵turn left signal light：when the trunning signal light switch is moved to left,the indicator light will work. ⑶odometer：the r...
- 6 - ignition switch（diagram 5） ⑴on( )—when the key is turnned to this position，you can start the engine，and now，the key cann’t be pulled out. ⑵off( )—when the switch is trunned to this position,the engine will close，pull the key out. ⑶lock( )—when the key is turnned to（ ），pull it out，and now， cann...
- 8 - horn switch 3（diagram 8） pull it in,the horn works. Steering handle switch（diagram 9、dirgram 10） turn the steering handle to left until the end，and then turn the key to（ ），you can lock it well.，when you need to open the turnning lock,you can do it with opposite way. The seat lock(diagram 11) •...
- 10 - iii operation instruction check before driving make routine check-up before riding to insure the vehicle perform well and safe driving. Oil tank volume turn on the ignition switch and check the fuel meter, replenish gasoline when the pointer is close to red section, moreover, check the fuel t...
- 12 - free path of rear brake handle（diagram 16 diagram 17） measure the free path of rear brake l before it works. The free path range is 20-30mm measuring from the end of the brake handle. Adjust the nut：(a) increase the distance of free path. (b) decrease the distance of free path. The axle pin2 ...
- 14 - starting engine(diagram 19) • preparation ： release the vehicle main stand, pull the key in to ignition switch and trun to “ ”. • electric-start: press start button (1) while applying the throttle slowly, and the engine starts in less than 5 seconds. Attention： • before starting the engine,ho...
- 16 - log（km） 0～200 200～500 500～1000 speed (km/h) ≤20 ≤30 ≤35 operation for driving • release the main stand, and sit on the saddle with left foot on the ground to make the vehicle straight. • apply the throttle slowly and pull back the left foot to gain proper speed. Warning： • do not apply the th...
- 18 - operation for stopping the motorcycle when stopping the motorcycle, turn the ignition switch to（ ）first, then step down stand and lock the steering handle.(consult p 8) warning：park the motor in a smooth ground, or it may fall down and cause injuring. Points for anti-thief： • lock the handle ...
- 20 - speedometer（×1000km） cyc item within 2000km 1 4 8 12 consult page ﹡ wave gap i i i i ﹡ engine oil （300km）r r （r/3000 km） 25 ﹡ oil filter net change oil :c、 if necessary: r 25 ﹡ idle speed of carburetor i i i i 24 ﹡ cooled system i i add blank 3 speedometer（×1000km） cyc item within 2000km 1 4 ...
- 22 - simple trouble shooting （blank 4） blank 4 trouble trouble reason solution spark plug wear out change ignition coil wear out change cdi wear out change ignition switch wear out change spark plug no spark ignition come off or become flexible connect well or firm and tight spark plug gap too sma...
- 24 - air filter cleaning（diagram 22） • take out air cleaner cover • screw up the blot. • take apart the core from air cleaner box. • compress air or use dry brush clean the filter element or put a new filter in the air clean box. • do the above opposite to reinstall the air filter. Warning： • do n...
- 26 - change the engine oil and filter net clean（diagram 24） change the engine oil l change the engine oil only when the engine is not cool and the vehicle is supporting by jiffy stand, to pour out all the oil completely and quickly. Filter net clean l screw out the the cover of oil hole /oil dip r...
- 28 - the spark plug（diagram 28） spark plug types standaed： c7hsa（ngk） 、a7t or a7rt • disconnect the joint of the spark plug cover and take apart the spark plugwith special tool. • check if any accumulated carbon or dirt, clean them in cleanser or brusher. Replace the spark plug if badly corroded. ...
- 30 - use the vehicle after long-time storage • take off the cover and clean the vehicle. You should change the oil after 4 months above storage. • charge the battery if necessary, and fix it on. • check all the parts before driving. (consult p), ride motorcycle in a low speed in non-busy area, mak...
- 32 - viii main technique parameter blank 5 item parameter item parameter l×w×h (mm) 1830×685×1130 front tire 3.50-10 wheel base (mm) 1300 rear tire 3.50-10 ground clearance (mm) 110 fr.T. Pressure kpa 180 dry weight kg 92 rr.T. Pressure kpa 200 max payload kg 75 transmission type cvt turning angle...
- 34 - ix circuit diagram - 35 - Ⅹ. Emission control system warranty statement wangye usa co., llc is pleased to explain the emission control system warranty on highway motorcycle. New highway motorcycle must be designed, built and equipped to regulations and standards of the united states environme...
- 36 - 2. Responsibilities of customer to obtain repairs under warranty, the customer must: (i). Ensure that the motorcycle is properly operated, maintained and stored as specified in the owner’s manual; (ii). Give notice to dealer approved by wangye usa co., llc or other qualified service facility ...
- 38 - fax: 817-649-5006.
