- DL manuals
- WARRIOR GENERATORS
- Inverter
- LDG4600E
- Owner's Manual
WARRIOR GENERATORS LDG4600E Owner's Manual - page 24
Changzhou ITC Power Equipment Manufacturing Co.,Ltd.
Changzhou ITC Power Equipment Manufacturing Co.,Ltd.
Changzhou ITC Power Equipment Manufacturing Co.,Ltd.
Changzhou ITC Power Equipment Manufacturing Co.,Ltd.
Changzhou ITC Power Equipment Manufacturing Co.,Ltd.
23
POWER PRODUCTS
3.2.12 Cylinder head cover
Install with a new gasket
3.2.13 Fuel injector
(1) Install the fuel injector assembly.
(2) Tighten the lock bolts.
(3) Install the high-pressure fuel line.
·Be sure the installation direction of fuel injector is correct.
·Replace the nozzle washer when reassembling.
Injector Tightening Torque
10-12 N.m
3.2.14 Air inlet pipe
Install the air inlet pipe and ensure the washer is in proper position.
3.2.15 Cooling fan case
(1). Install the starter reel.
(2). Install the cooling fan case.
·Apply the seal rubber to the case.
·Be sure the collar and the fan case supporting are in right position.
Summary of LDG4600E
Page 1
Ldg4600e diesel generator owners manual before operating this equipment please read these instructions carefully.
Page 2: Notice
This manual contains information how to maintain and how to do troubleshooting. Keep this owner’s manual handy, so you can refer to it at any time. This service manual describes correct method of the maintaining this equipment. As a result of this disregard of our rules caused by person casualty and...
Page 3: Contents
1 preface 1 1-1 generator component identification 1 1-2 control panel 3 1-3 specifications of generator 4 1-4 specifications of engine 6 1-5 maintenance standard 7 2 periodic maintenance 9 2.1 service intervals 9 2.2 routine maintenance procedures 10 3. Engine disassembly and reassembly 13 3.1 disa...
Page 4: 1. Preface
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 1. Preface 1-1 generator component identification open type: d * 1 fuel tank fuel tank cap control panel up cover frame diesel engine recoil starter injection pump speed governor cock of oil dra...
Page 5
Changzhou itc power equipment manufacturing co.,ltd..
Page 6
Led4 display electric start key 1-2 control panel leakage breaker pcb ground terminal 12v dc socket socket pre-heater button ats signal socket 12v dc fuse changzhou itc power equipment manufacturing co.,ltd..
Page 7: Ldg4600E
Ldg4600e specifi cations frequency (hz) 50 cooling system forced air cooled starting watts 4600 lubricaton system forced lubrication running watts 4200 operation capacity (hr) >12 hrs (25% load) voltage (v) 1 x 110v 32 amp / 1 x 240v 32 amp dimension l*w*h (mm) 720 x 492 x 650 dc output (va) 12 / 8.3...
Page 8
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 1-5 maintenance standard parts item...
Page 9
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Camshaft cam height in cam height e...
Page 10: 2. Periodic Maintenance
2. Periodic maintenance 2.1 service intervals good maintenance is essential for safe, economical, and trouble-free operation. It will also help reduce air pollution. Exhaust gas contains poisonous carbon monoxide. Shut off the engine before perform any maintenance. If the engine must be run, make su...
Page 11
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 10 power products dipstick drain bo...
Page 12
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 11 power products 2.2.3 air filter ...
Page 13
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 12 power products 2.2.5 adjust the ...
Page 14
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 13 power products 3. Engine disasse...
Page 15
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 14 power products 3.1.7 air inlet p...
Page 16
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 15 power products 3.1.7 air inlet p...
Page 17
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 16 power products 3.1.13 remove the...
Page 18
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 17 power products t f a h s m a c 6...
Page 19
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 18 power products 3.1.19 flywheel (...
Page 20
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 19 power products 3.2 reassembly re...
Page 21
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 20 power products connecting rod nu...
Page 22
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 21 power products crankcase cover b...
Page 23
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 22 power products tightening torque...
Page 24
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. 23 power products 3.2.12 cylinder h...
Page 25
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 3.2.16 air cleaner (...
Page 26
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 25 3.3 recoil starte...
Page 27
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 26 (2) wind the star...
Page 28
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 27 3.3.3 inspection ...
Page 29
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 28 4. Inspection and...
Page 30
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 29 4.1.5 measure the...
Page 31
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 30 t i m i l e c n a...
Page 32
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 31 4.2.2 piston and ...
Page 33
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 32 4.2.4 piston ring...
Page 34
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 33 4.4 crankshaft, m...
Page 35
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 34 4.5 camshaft 4.5....
Page 36
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 35 4.7 crankcase cov...
Page 37
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 36 lo flow path lo f...
Page 38
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 37 4.9.1 lube oil pu...
Page 39
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 38 4.10 fuel system ...
Page 40
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 39 (5) disassembly a...
Page 41
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 40 4.12 adjustments ...
Page 42
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 41 (4) remove the fi...
Page 43
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 42 5. Troubleshootin...
Page 44
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 43 5.5 no start or h...
Page 45
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 44 5.6 engine over s...
Page 46
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 45 6 6-1.
Page 47
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 46 green green black...
Page 48
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 47.
Page 49
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 48 d400 black.
Page 50
D400 black black changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 49.
Page 51
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 50
Page 52
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 51 7 circuit diagram...
Page 53
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 53.
Page 54
Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Changzhou itc power equipment manufacturing co.,ltd. Power products 54 8.
Page 55: Your Local Dealer
Your local dealer contact warrior tech department warrior generators, unit 27 salisbury road haydock industrial estate st helens, wa11 9xg united kingdom tel: +44 (0)1942 528271 for any technical or faults please contact warrior direct on the following number or write:.