Summary of WL850HV
Page 1
Wl 850 hv technical manual.
Page 2
2 wl850 hv technical manual - version 1, november 2007 3 index introduction 5 operational information 6 creating carbonated water 10 components layout diagram 12 pre delivery inspection procedures (pdi) 14 installation procedures 16 operating instructions 20 maintenance and servicing 22 sanitizing t...
Page 3: Introduction
4 wl850 hv technical manual - version 1, november 2007 5 thank you for purchasing the waterlogic wl850hv water purifier. The wl850hv is suitable for use in a small or large office and it is designed to be connected to mains public drinking water supplies. Waterlogic international are using proven te...
Page 4: Operational Information
6 wl850 hv technical manual - version 1, november 2007 77 operational information wl850 hv moving of the small switch will allow just the hot button to be pushed to vend ambient water. This option does allow you to convert the machine for one button operation for hot water. All machines are factory ...
Page 5
8 wl850 hv technical manual - version 1, november 2007 9 water pipe and fittings all water connection fittings are made by the john guest company and are approved to nsf standard 51. The machine is connected the water supply by a ¼” female bulkhead fitting. The entire internal water circuit and all ...
Page 6: Creating Carbonated Water
10 wl850 hv technical manual - version 1, november 2007 11 creating carbonated water carbonation the carbonation in the tank has been designed to a similar level to that in international soft drinks. Good carbonation depends on a combination of co 2 gas pressure, water pressure, water quality and te...
Page 7: Components Layout Diagram
12 wl850 hv technical manual - version 1, november 2007 13 components layout diagram hot and cold 1 14 15 16 17 3 4 5 6 7 8 9 10 11 12 13 2 29 28 27 26 30 31 32 33 34 18 19 20 21 22 23 24 25.
Page 8: Pre Delivery
14 wl850 hv technical manual - version 1, november 2007 15 pre delivery inspection procedures (pdi) caution: only competent trained technicians should work on waterlogic products. Waterlogic units may weigh over 25kg. We recommend caution when lifting. Packing materials could present a trip hazard. ...
Page 9: Installation Procedures
16 wl850 hv technical manual - version 1, november 2007 17 installation procedures important notice: this procedure should only be carried out by an engineer or staff trained by waterlogic international or an approved distributing agent. 1. Site the machine with a 50mm. Air gap at both sides and bac...
Page 10
18 wl850 hv technical manual - version 1, november 2007 19 19. The sparkling water quality is dependent on the water temperature, and the water/gas pressure. If the sparkling water is not sharp enough at first, then completely purge the sparkling tank of water by holding the dark blue button until n...
Page 11: Operating Instructions
20 wl850 hv technical manual - version 1, november 2007 21 operating the machine is very simple. It’s as simple as selecting the option you want, and press the dispense button. The machine will dispense fresh water at your disposal. 1. Green led indicates the power is on. Flashing red led indicates ...
Page 12: Maintenance And Servicing
22 wl850 hv technical manual - version 1, november 2007 23 maintenance and servicing 1. Every six months it is strongly recommended that the filters and uv lamp be changed. If the model of machine is hot and cold, the hot tank may require any build up of calcium to be removed. The need to remove cal...
Page 13
24 wl850 hv technical manual - version 1, november 2007 25 sanitising the machine 1. You will need to have an ametek filter housing to follow this procedure. Also sanitizer, disposable rubber gloves, and bacterial wipes or spray. 2. Mix a solution of sanitizer in the ametek filter housing. 3. Turn o...
Page 14
26 wl850 hv technical manual - version 1, november 2007 27 troubleshooting the wl850hv 1. No cold water flowing: there are a number of reasons that could be causing this problem. 1) check if the water in the building is turned off! 2) check if the isolating valve has been turned off! 3) check if the...
Page 15: Exploded Diagram
28 wl850 hv technical manual - version 1, november 2007 29 exploded diagram 50 32 37 33 34 36 30 35 22 39 40 41 42 43 44 31 10 12 14 13 15 24 25 27 28 29 45 11 46 47 23 26 48 18 38 19 21 20 16 17 9 6 7 8 1 4 3 2 5 replacement parts list.
Page 16: Wetted Parts Diagram
30 wl850 hv technical manual - version 1, november 2007 31 wetted parts diagram 1 2 3 5 6 7 8 9 10 11 12 14 29 39 41 45 43 53 54 44 47 46 48 49 50 52 51 42 58 59 60 61 63 62 40 56 57 55 38 36 30 33 37 32 35 34 31 64 15 20 24 25 26 27 28 23 21 19 16 17 18 22 13 4.
Page 17: Main Parts Layout Diagram
32 wl850 hv technical manual - version 1, november 2007 33 main parts layout diagram drain valve solenoid valve solenoid valve filter dryer hot tank compressor condenser fi lter in (water) solenoid valve w ater in sparkling water out solenoid valve pump check valve co 2 in sparkling tank safety valv...
Page 18: Electrical Wiring Diagram
34 wl850 hv technical manual - version 1, november 2007 35 electrical wiring diagram cold, ambient and sparkling electrical wiring diagram cold, hot and sparkling danger high voltages present on this pcb care must be taken when live testing danger high voltages present on this pcb care must be taken...
Page 19: Technical Specifications
36 wl850 hv technical manual - version 1, november 2007 37 description wl850 hv hcs wl850 hv cs wl850 hv mhcs wl850 mcs width depth height 38w-34d-114h (cm) 38w-34d-114h (cm) 38w-34d-47h 38w-34d-47h water connection dia ¼” dia ¼” dia ¼” dia ¼” cold water temp 5-8ºc 5-8ºc 5-8ºc 5-8ºc hot water temp 8...
Page 20
38 e n g 02 79 -2 5 /0 2 /1 3 wli trading ltd. Suite 4, 2nd floor beacon court, sandyford, dublin 18, ireland www.Waterlogic.Com waterlogic usa, 4141 n. 156th street, omaha, ne 68116 speak to a water expert rest of the world exportsales@waterlogic.Com + 353 1 293 1960 usa, canada and mexico info@wat...