1. DL manuals
  2. Watts Premier
  3. Water Dispenser
  4. KP-4
  5. Nstallation, Operation And Maintenance Manual

Watts Premier KP-4 Nstallation, Operation And Maintenance Manual

Manual is about: Water Filters, Dispensers & Softeners

Summary of KP-4

  • Page 1

    Page 1 installation, operation and maintenance manual refer to enclosed warranty for operating parameters to ensure proper use with your water supply. Watts premier, inc. 8716 w ludlow drive suite #1 peoria, az 85381 phone: 800-752-5582 www.Wattspremier.Com fax: 623-866-5666 save manual for future r...

  • Page 2

    Page 2 thank you for your purchase of a state of the art watts premier reverse osmosis (ro) water treatment system. Water quality concerns are quickly becoming more of a focus for the public. Lately you may have heard about contaminants in the drinking water, such as arsenic, chromium, cryptosporidi...

  • Page 3: Table of Contents

    Page 3 with proper installation and maintenance, this system will provide you with high quality water for years to come. All of watts premier’s water enhancement products are rigorously tested by independent laboratories for safety and reliability. If you have any questions or concerns, please conta...

  • Page 4: Operational Parameters

    Page 4 1 tank – white 1 module – white 1 parts bag 1 faucet bag if any of the items are missing please contact premier prior to installing. Tools recommended for installation √ 1 1/4" hole saw bit for faucet opening √ round knock out punch for stainless sinks 1 ¼” √ adjustable wrench √ sharp knife √...

  • Page 5

    Page 5 make sure the surroundings of the sink are cooled before mounting the faucet to the sink after drilling and remove all sharp edges. Step 3 step 4 determine desired location for the ro faucet on your sink and place a piece of masking tape on over where the hole is to be drilled. Mark the cente...

  • Page 6: Standard Faucet Installation

    Page 6 remove nut (item 11) and blue tubing (item 12) from faucet (leave the nut and plastic delrin sleeve (item 10) on the blue tube). Feed both the red and black tubing through the pre drilled hole in the sink/counter until faucet is seated. Step 6 under the sink - on to the threaded faucet stem i...

  • Page 7: Adapt-A-Valve Installation

    Page 7 turn off the cold water supply to the faucet by turning the angle stop valve completely off. Step 10 step 11 attach the adapt-a-valve as illustrated in the three photos above, choosing the configuration that fits your plumbing. Drain saddle fits standard 1 ¼” – 1 ½” drain pipes drain saddle i...

  • Page 8: Green Tube Connection

    Page 8 drill hole and connect 3/8” black tube from faucet to the drain saddle measure the 3/8” black tube from faucet to the drain saddle on the drain pipe and make a straight cut to the correct length. Slip black tube through black compression nut. Insert black tube into the opening in the drain sa...

  • Page 9

    Page 9 connect blue tube from “tank” port on ro module to the tank position tank in desired location. Stand it upright or lay it on its side (using the black plastic stand). Measure the blue tube from the ro module port marked “tank” over to the tank and cut it to desired length. Insert the blue 3/8...

  • Page 10

    Page 10 connect the blue tube from the faucet to ro module step 25 step 24 connect the red tube from faucet to ro module insert the open end of the red 1/4” tube attached to the ro faucet into the 1/4” x 1/4” quick connect fitting on the ro manifold. Make sure the tube is pushed in all the way to th...

  • Page 11: Start Up Instructions

    Page 11 start up instructions register by mail, phone, fax or internet. Watts premier uses this information only to provide a filter change reminder notice. Pre-filters should be changed every 6 months and final polishing filter annually. You may register your system via our website at www.Wattsprem...

  • Page 12: 6 Month System Maintenance

    Page 12 √ stage 1 - sediment filter (part #: 104017) √ stage 2 - carbon filter √ stage 4 - carbon filter • part#:101009: wp-4, wp4-50 part#:101009 • part#:100037: kp-4 note: the kp-4 r.O. Unit is equipped with annual filters, therefore require only one annual change. Clean filter housings (bowls) wi...

  • Page 13: Annual Maintenance

    Page 13 annual maintenance step 1 √ stage 1 - sediment filter (part #: 104017) √ stage 2 & 4 - carbon block filter (part #: 101009-white end caps) √ 1/2 cup of hydrogen peroxide or common household bleach. *order filters by calling 1-800-752-5582 or buy online at www.Wattspremier.Com. Note: sanitizi...

  • Page 14: Membrane Replacement

    Page 14 membrane replacement membranes have a life expectancy between 2 and 5 years, depending on the incoming water conditions and the amount the ro system is used. This reverse osmosis membrane is critical for effective reduction of total dissolved solids (tds). The product water should be tested ...

  • Page 15

    Page 15 procedure for extended non-use (more than 2 months) turn off the water supply to the ro at the adapt-a-valve and open the ro faucet to empty the storage tank (save a few ounces of ro water). Once the storage tank is empty, remove the membrane and place it in a sealed plastic bag with the ro ...

  • Page 16: Trouble Shooting

    Page 16 trouble shooting problem cause solution 1. Low/slow production low water pressure assure a minimum of 40 psi incoming water pressure. Premier sells a booster pump if home water pressure is low. Maker sure water supply is turned on and adapta valve is all the way open crimps in tubing check t...

  • Page 17

    Page 17 arsenic (as) is a naturally occurring contaminant found in many ground waters. Arsenic in water has no color, taste or odor. It must be measured by an arsenic test kit or lab test. Public water utilities must have their water tested for arsenic. You can obtain the results from your water uti...

  • Page 18: California Certification

    Page 18 california certification state of california department of health services water treatment device certificate number 1452 date issued: october 17, 2005 trademark/model designation 00 - watts premier deluxe plus watts premier ultra 5 watts premier pur-tek watts premier watts 25 watts premier ...

  • Page 19

    Page 19 description replace sediment filter part# 104017 6 months carbon filter  part# 101009 (wp-4) 6 months  part# 100037 (kp-4) 12 months depending upon incoming feed water conditions replacement time frame may vary. This system has been tested according to nsf/ansi 58 for reduction of the subs...

  • Page 20

    Page 20 this system has been tested according to nsf/ansi 58 for reduction of the substances below. The concentration of the indicated substances in water entering the system was reduced to a concentration less than or equal to the permissible limit for water leaving the system as specified in nsf/a...

  • Page 21

    Page 21 item qty part # description 1 1 101009 carbon block-10 inch-5m 2 1 104017 sediment filter-10 inch-5m 3 1 110016 ro membrane 35gpd 4 1 110019 ro membrane 50gpd 5 3 113018 filter bowl 6 1 113035 membrane vessel 7 3 113041 o-ring filter bowl 8 1 113045 o-ring membrane vessel 9 1 116001 faucet-a...

  • Page 22

    Page 22 50 gpd membrane compatible with watts premier reverse osmosis systems, this 50 gpd membrane generates a greater amount of water per day for your ro system. Good application for households with higher levels of nitrites & nitrates. Contact watts premier if you are in need of a nitrite/nitrate...

  • Page 23

    Page 23 whole house high performance water pressure regulator provides water pressure control solutions for residential, commercial, and indus- trial applications. Offers durability and years of continuous trouble free operation. Part no. 107001 *$69.95/ea water pressure gauge this gauge mounts onto...

  • Page 24

    Page 24 removing chlorine from your shower deluxe shower handle with built in filter replacement filters 2pk 5-way massaging spray 72” reinforced hose high strength bracket triple plated finish reversible filter cartridge (model hhc) cartridge life rating: 3 months part no. 107070 white *$38.95 part...

  • Page 25: 4 Ways to Register

    Page 25 4 ways to register 1. Online at www.Wattspremier.Com 2. Call in your information 1-800-752-5582 3. Fax in your information 623-866-5666 first name:_________________________ last name:____________________________ address: ________________________________________ city: ____________________ sta...

  • Page 26: Warranty Registration

    Page 26 warranty registration please fill out and keep for your records insert into envelope and return to watts premier first name:_________________________ last name:____________________________ address: ________________________________________ city: ____________________ state: ___________________...

  • Page 27: Service Record

    Page 27 service record date of purchase:__________ date of install:___________ installed by:__________________ serial no. _____________________ date 1st stage sediment (6 months) 2nd stage carbon (6 months) 4th stage carbon (1 year) tfm membrane (2-5 years) notes:.

  • Page 28: Limited Warranty

    Page 28 limited warranty what your warranty covers: if any part of your watts premier reverse osmosis system is defective in workmanship (excluding replaceable filters and membranes), return unit after obtaining a return authorization (see below), less tank, within 3 years of original retail purchas...