1. DL manuals
  2. Wayne-Dalton
  3. Garage Door Opener
  4. 8000
  5. Quick Start Manual

Wayne-Dalton 8000 Quick Start Manual

Manual is about: Residential Standard Lift Windload

Summary of 8000

  • Page 1

    The complete installation instructions and owner’s manual are available at no charge from: - your local wayne dalton sales center, or - online at www.Wayne-dalton.Com , or - by mailing to: wayne dalton, a division of overhead door corporation, p.O. Box 67, mt. Hope, oh., 44660 ©copyright 2018 rev8_0...

  • Page 2: Warning

    Important safety instructions definition of key words used in this manual: warning indicates a potentially hazardous situation which; if not avoided, could result in severe or fatal injury. Caution property damage or injury can result from failure to follow instructions. Important: required step for...

  • Page 3

    3 a. Flag angles (as required): a1. Quick install (q.I.) flag angles a2. Fully adjustable (f.A.) flag angles b. Jamb brackets (as required): b1. Quick install (q.I.) jamb brackets b2. Fully adjustable (f.A.) jamb brackets b3. Windload jamb brackets c. Track rollers (as required): c1. Short stem trac...

  • Page 4: Warning

    Door installation instructions before installing your door, be certain that you have read and followed all of the instruc- tions covered in the pre-installation section of this manual. Failure to do so may result in an improperly installed door. Note: reference tds 160 for general garage door termin...

  • Page 5: Caution

    The bottom section, so that the lower (#) hinge leaf is over the pre-punched holes in the end stile. Secure each graduated end hinge to the bottom section using (2) 1/4” - 14 x 5/8” self tapping screws. Note: refer to the windload specification sheet to determine if additional 1/4” - 14 x 7/8” self ...

  • Page 6: Warning

    Stacking sections 12 note: the sections can be identified by the graduation of the installed graduated end hinges. The smallest graduated end hinge on the section should be stacked on top of the bottom section, with each graduated end hinge increasing as the sections are stacked, see door section id...

  • Page 7: Warning

    Warning failure to assemble and attach rear back hangs properly according to the above instructions may result in door falling when raised, causing severe or fatal injury. Note: perforated angle must be attached to sound framing members and nails should not be used . 90° (3) 5/16” bolts and nuts (3)...

  • Page 8: Warning

    5/16”-18 x 3-3/4” eye bolt special knot 3 hole clip rear back hang spring restraint cable special knot 5/16”-18 x 3-3/4” eye bolt 5/16”-18 hex nut extension spring horizontal track 5/16”-18 hex nut horizontal track 5/16”-18 hex nut 6”-8” attaching spring sheaves 19 hook the sheave fork through the f...

  • Page 9: Caution

    Caution never mix cleansers or detergents with bleach. Glass cleaning instructions clean with a mild detergent solution (same as above) and a soft cloth. After cleaning, rinse thoroughly. Acrylic cleaning instructions clean acrylic glazing with nonabrasive soap or detergent and plenty of water. Use ...

  • Page 10

    From the core of the product section, due to cracking, splitting, or other deterioration of the steel skin, or due to structural failure caused by separation or degradation of the foam insulation. • peeling of the original paint as a result of a defect in the original paint or in the application of ...

  • Page 12

    If you need assistance, please call 1-866-569-3799 (press option 1) and follow the prompts to contact a customer service representative. They will be happy to handle any questions that you may have. Thank you for your purchase. Please do not return this product to the store after installation is com...