Webasto Air Top Evo 3900 Operating Instructions Manual - page 2
10. The heat transfer unit on air heaters is exposed to very high thermal stress and
must be replaced by a genuine Webasto spare part ten years after it is used for
the first time.
If exhaust lines pass through areas used by personnel, they must also be
replaced by genuine spare parts after ten years.
11. The fuel specified by the vehicle manufacturer is suitable for use in the Air Top Evo
3900 B/Air Top Evo 5500 B. Both leaded and unleaded fuel may be used.
The diesel fuel specified by the vehicle manufacturer is suitable for use in the Air Top
Evo 3900 D/Air Top Evo 5500 D. Class EL heating oil (not L heating oil) may also be
used as long as it complies to the normal quality available on the German market
pursuant to DIN 51603.
The Air Top Evo 3900 D/Air Top Evo 5500 D heaters are also licensed for use with
PME (bio-diesel), which complies with DIN EN 14214.
We know of no negative influences due to additives.
If fuel is extracted from the vehicle’s tank, follow the additive instructions issued by the
vehicle manufacturer.
If you change to low-temperature fuel, the heater must be operated for approx.
15 minutes so that the fuel system is filled with the new fuel.
12. The temperature in the area around the heater unit must not exceed 85 °C (storage
temperature). If the temperature exceeds this level there is a risk of permanent
damage to the electronics systems.
13. Non-compliance with the installation instructions and the warnings contained therein
will lead to the exclusion of all liability by Webasto. The same applies if repairs are
carried out incorrectly or with the use of parts other than genuine spare parts. This will
result in the invalidation of the type approval for the heater unit, and therefore of its
homologation/EC type licence.
14. Keep the hot air inlet and hot air outlet free of dirt and foreign bodies. Soiled or blocked
hot air lines may cause overheating, and therefore result in the overheating cut-out
tripping.
15. To prevent mechanical parts seizing, the heater should be operated for approx.
20 minutes every four weeks.
16. Do not stand on the heater and do not place any heavy items on the heater or throw
items at the heater.
17. Do not place any items of clothing, textiles or similar materials over the heater or in
front of the hot air inlet and the hot air outlet.
18. The current of hot air in the heater must not be restricted or blocked by highly
inflammable substances or materials such as rags, cleaning wool, etc.
19. The heater must not be cleaned with a high pressure cleaner.
Servicing and safety instructions