Operation/installation manual - wbcc series - page : 1 operation/installation manual - wbcc series - page : 1 edition dated 1st january 2004 digital control panel f u n c t i o n i n g p r i n c i p l e s webasto - air conditioning sea-water pump eletrical control box self-contained cpac unit - 7000...
Operation/installation manual - wbcc series - page : 2 operation/installation manual - wbcc series - page : 2 edition dated 1st january 2004 self-contained air-conditioning units - wbcc series operation and installation manual c o n t e n t s page 1) general information ................................
1. General information all webasto air conditioning units are controlled by a digital display control> which gives access to all functions necessary for the normal opera- tion of the unit and attached accessories (blowers, pumps, etc). All webasto air conditioning units are sea-water cooled by means...
Recognized by the inscription at the bottom left hand corner of each digital display. All webasto air conditioning units are sea-water cooled by means of an ac sea- water pump. In order to start the system you only need to press the key on the digital dis- play. From there on the electronic control ...
B) calibrate all blower speed settings in real time mode. It is now possible to calibrate all speed set- tings (1 to 5) before actually putting the sys- tem into service. To do so entrer programming mode with set- point at 15° c.; proceed to following line i.E. Code = speed 5 (max). The blower will ...
Operation/installation manual - wbcc series - page : 6 operation/installation manual - wbcc series - page : 6 edition dated 1st january 2004 code and will be followed by a system halt. Whenever any of these codes appear the sys- tem is stopped for approx. 60 seconds and then a re-start is attempted....
Operation/installation manual - wbcc series - page : 7 operation/installation manual - wbcc series - page : 7 edition dated 1st january 2004 to gain access to the hidden programming functions proceed as following : raise set-point to max. Value i.E. 29° c (or alternatively to lowest value i.E. 15° c...
Operation/installation manual - wbcc series - page : 8 operation/installation manual - wbcc series - page : 8 edition dated 1st january 2004 during low-voltage cut-out the display panel will show the 3 letters . Programming of a cut-out level below 195 v is done at the entire risk of the operator. I...
Introduce shut-off valves for each unit if 1 pump provides cooling for more than 1 air-conditioning unit. This will allow easy priming of the circuit and also calibration of the sea-water flow for each air-conditioning unit in case of imbalance in the water tubing lengths. 3) evaporator coils : the ...
Operation/installation manual - wbcc series - page : 10 operation/installation manual - wbcc series - page : 10 edition dated 1st january 2004 9 - air ducting - ventila- tion 1) minimum air-grille sec- tions in order to obtain an acceptable noise level at max. Blower speed certain requirements as re...
Operation/installation manual - wbcc series - page : 11 operation/installation manual - wbcc series - page : 11 edition dated 1st january 2004 10 - w i r i n g d i a g r a m s dipswitch select or displa y cable connect or extern al air temp . Sensor ev ap . Coil temp . Sensor sea w a ter pump 230v s...
Operation/installation manual - wbcc series - page : 12 operation/installation manual - wbcc series - page : 12 edition dated 1st january 2004 run capac. Blower rever. Cycle valve hp bp c r s seawater pump 230v supply gnd gnd dipswitch selector display cable connector external air temp. Sensor evap....
Dipswitch selector run capacit. Start capac. Start relay 5 2 1 r c s blower rever. Cycle valve hp safety switch sea-water pump terminal strip 230 v ac supply pump1 valve fan comp1 230v ac 230v fan comp1 hp bp pump1 valve gnd display cable connector external air temp. Sensor evaporator coil temp. Sen...
Webasto-representatives - webasto-vertretungen germany -deutschland bayern, webasto ag baden-würtemberg, business unit spm hessen (teilweise), niederlassung süd saarland, kraillinger strasse 5, d-82131 stockdorf rheinland pfalz tel. +49 89 85794-789, fax +49 89 85794-702 australia- australien aus-22...
