- DL manuals
- Webb
- Lawn Mower
- WER18SP
- Operator's Manual
Webb WER18SP Operator's Manual
Summary of WER18SP
Page 1
Operator’s manual and parts list self propelled petrol lawnmower wer18sp spares & support: 01793 333212 www.Webblawnmowers.Co.Uk before use please read & understand this manual, paying particular attention to the safety instructions. 16/06/2014.
Page 2
Thank you for choosing our petrol lawnmower. To ensure that you get the best results from your petrol lawnmower please read all of these safety and operating instructions carefully before using this product. Table of contents product specification product specifications…………………….1 safety rules…………………...
Page 3
1. General operation and safety rules z read the instructions carefully. Be familiar with the controls and the proper use of the equipment. Z do not put your hands or feet near or under rotating parts. Keep clear of the discharge opening at all times. Z only allow responsible individuals, who are fa...
Page 4
Z before using, always visually inspect to ensure that the blade, blade bolts and cutter assembly are not worn or damaged. Replace worn or damaged blades and bolts in sets to preserve balance. Z never tamper with safety devices. Regularly check that they are operating properly. Z keep the machine fr...
Page 5
Apply inward pressure to the lever assembly on the left hand side of the machine, to remove the lever lug from the handle assembly. Insert the brake cable into the opc lever. Insert the drive cable into the drive lever. 4.
Page 6
Re-seat the lever assembly back into the main handle. Install attachments your lawnmower was shipped ready to be used as a rear bag mower. The mower has three different operating modes. 1. Collecting: • fit the grassbox by lifting the rear flap on the mower and hook the front of the box to the shaft...
Page 7
Operation operator presence control (opc) bar - must be held down to the handle to start the engine. Release to stop the engine. Starter rope - used to start the engine. Drive control lever - used to engage self- propelled motion of the lawn mower. Lawnmower engine speed the engine speed was set at ...
Page 8
Before starting engine add oil before each subsequent use the oil level must be checked and if necessary topped up with sae30 engine oil. Oil filler cap/dipstick your lawnmower is shipped without oil in the engine. Caution: do not overfill the engine with oil, or it will smoke heavily from the muffl...
Page 9
Caution: to avoid engine problems, the fuel system should be emptied before being stored for 30 days or more. Empty the fuel tank, start the engine and let it run until the fuel lines and carburettor are empty. Use fresh fuel for your next use of the machine. See storage instructions for additional ...
Page 10
9) check the self-closing guard and grass-catcher frequently for wear and deterioration. 10) whenever the machine is to be handled, transported or tilted you must: - wear strong working gloves. - grasp the machine at the points that offer a safe grip, clear of the blade and taking account of the wei...
Page 11
The environment in order to protect the environment, we recommend that the following points should be given special consideration: z always use pure unleaded petrol. Z always use a funnel and/or petrol can with a level control to avoid spillage when refilling the fuel tank. Z do not fill the fuel ta...
Page 12
Parts diagram and list – handle assembly item no part number description qty item no part number description qty 1 we114-1 foam handle cover 1 14 we113-14 pin 6x20 2 2 we114-2 brake lever 1 15 we113-15 bolt for quick lock handle 2 3 we114-3 self-propelled lever 1 16 we113-16 lock for quick lock hand...
Page 13
Parts diagram and list – deck assembly item no part number description qty item no part number description qty 1 we113-24 deck 1 12 we113-35 rear drive right bracket 1 2 we113-25 "o" ring 11.2x2.65 1 13 we113-36 rear drive left bracket 1 3 we113-26 inlet 1 14 we113-37 hex self-tapping screw m6x10 4 ...
Page 14
Parts diagram and list – front axle assembly item no part number description qty 1 we113-49 front axle 1 2 we113-50 front wheel 2 3 we113-51 wheel bearing 4 4 we113-52 lock nut m8 2 5 we113-53 wheel trim 2 6 we114-5 inner wheel cover 2 13.
Page 15
Parts diagram and list – rear axle assembly item no part number description qty item no part number description qty 1 we113-54 rear axle with height adjustment handle 1 10 we114-14 drive cog l 1 2 we114-6 gearbox assembly 1 11 we114-15 drive cog r 1 3 we114-7 bush 2 12 we114-16 drive pin 6 4 we114-8...
Page 16
Parts diagram and list – grass collector assembly item no part number description qty 1 we113-58 grass box frame 1 2 we113-59 grass box top 1 3 we113-60 filter plate 1 4 we113-61 60l grass box bag (unbranded) 1 5 we113-62 rear discharge cover 1 6 we113-63 rear discharge cover shaft 1 7 we113-64 rear...
Page 17
Parts diagram and list – blade assembly item no part number description qty 1 we114-18 blade adapter assy 1 2 we113-69 18" double edge blade 1 3 we113-70 blade washer 1 4 we113-71 50mm hex flange bolt 1 5 we114-19 chassis bushing 2 6 we114-20 hex self-tapping screw 3/8-16x1st-30mm 2 7 we114-21 hex s...
Page 18
Wer18sp 80.5db (a) 125cc 17.
Page 19: Guarantee
Guarantee this product is guaranteed against manufacturing defects for a period of 24 months. This does not cover the product where the fault is due to misuse, abuse, use in contravention of the instructions, or where the product has been the subject of unauthorised modifications or alterations. Thi...
Page 20
• • h h a a n n d d p p u u s s h h c c y y l l i i n n d d e e r r l l a a w w n n m m o o w w e e r r s s • • e e l l e e c c t t r r i i c c & & p p e e t t r r o o l l c c y y l l i i n n d d e e r r l l a a w w n n m m o o w w e e r r s s • • i i n n t t e e r r c c h h a a n n g g e e a a b b ...
Page 21
20
Page 22
21.
Page 23: Warranty Registration Form
Warranty registration form please g o to www.We b blawnmowers.Co.Uk select registration and complete t he registration for your machine. (alternativel y please fill in this fo rm and return to the address above.) ow ner’s n ame: …………………..…………………………………………………………………..... ............. Address: ……………………...
Page 24
Webb lawnmowers hobley drive stratton st margaret swindon wiltshire sn3 4ns.