1. DL manuals
  2. Webb
  3. Lawn Mower
  4. WER21HW
  5. Operator's Manual

Webb WER21HW Operator's Manual

Manual is about: 53cm High Wheeled Self Propelled Lawnmower

Summary of WER21HW

  • Page 1

    Operator’s manual and parts list petrol lawnmower wer21hw spares & support: 01793 333212 www.Webblawnmowers.Co.Uk before use please read & understand this manual, paying particular attention to the safety instructions. 30/03/2012.

  • Page 2

    1 thank you for choosing our petrol lawnmower. To ensure that you get the best results from your petrol lawnmower please read all of these safety and operating instructions carefully before using this product. Table of contents product specification product specifications…........1 model number safe...

  • Page 3

    2 before use a) read the instructions carefully: be familiar with the controls and the proper use of the equipment. B) never allow children or people unfamiliar with these instructions to use the lawnmower. Local regulations may restrict the age of the operator. C) never mow while people, especially...

  • Page 4

    3 m) disengage all blade and drive clutches before starting the engine. N) start the engine or switch on the motor carefully according to instructions and with feet well away from the blade(s). O) do not tilt the lawnmower when starting the engine or switching on the motor. P) do not start the engin...

  • Page 5

    4 symbols the following symbols can be found on the machine to remind you of the care and attention that are required during use. The symbols mean: danger – rotating warning! Keep hands read the blades. Keep hands and feet clear of the operator’s and feet out of cutting deck when the manual. Opening...

  • Page 6

    5 • lower the flap to lock the grassbox in position. • when the box is full, the grass will be visible through the viewing window in the top of the box. • stop the engine before emptying the grassbox. 2. Rear discharge: • ensure that the side cover is closed. • with the grassbox removed and the rear...

  • Page 7

    6 drive control self-propelling is controlled by holding the operator presence control bar down to the handle and pushing the drive control lever forward until it clicks; then releasing the lever. Forward motion will stop when the operator presence control bar is released. To stop forward motion wit...

  • Page 8

    7 add petrol fill the fuel tank to the bottom of the tank filler neck. Do not overfill. Use fresh, clean, regular unleaded petrol. Do not mix oil with petrol. Purchase fuel in quantities that can be used within 30 days to assure fuel freshness. Caution: wipe off any spilled oil or fuel. Do not store...

  • Page 9

    8 pores in cloth grass catchers can become filled with dirt and dust with use and catchers will collect less grass. To prevent this, regularly hose the catcher off with water and let it dry before use. Keep the top of engine around the starter clear and clean of grass clippings and chaff. This will ...

  • Page 10

    9 changing blades empty the oil tank before removing the blade. To replace the blade, undo the screw. Reinstall as illustrated. Tighten the screw properly. Tightening torque 45 nm. When replacing the blade, the blade screw should also be replaced. Change oil 1. Run the engine until it is warm (not h...

  • Page 11

    10 air filter unclip the air filter cover and remove the paper filter element. Close the air filter cover to avoid objects falling into the air intake, while you clean or replace the paper filter element. Draining the fuel tank and carburetor 1. Place an approved petrol container below the carbureto...

  • Page 12

    11 maintenance schedule regular service period before each use first month or 5 hrs every 3 months or 25 hrs every 6 months or 50 hrs every year or 100 hrs every two years or 250 hrs page item perform at every indicated month or operating hour interval, whichever comes first. Engine oil check 6 repl...

  • Page 13

    12 engine lacks power possible cause correction 1.Check the air cleaner air cleaner elements clogged. Clean or replace air cleaner elements (p.10). 2. Check the fuel bad fuel; engine stored without draining petrol, or refueled with bad petrol. Drain the fuel tank and carburetor (p.10). Refuel with f...

  • Page 14

    13 servicing genuine spare parts are supplied by service workshops and by many dealers. We recommend that you take the machine to an authorised service dealer for annual servicing, maintenance and inspection of the safety equipment. For service and spare parts, please contact: handy garden machinery...

  • Page 15

    14 parts diagram.

  • Page 16

    15 parts list ref part no description qty ref part no description qty 1 we104-1 form cover 1 39 we104-39 v belt 1 2 we104-2 upper handle 1 40 we104-40 bs675 engine 1 3 we104-3 opc lever 1 41 we104-41 rear discharge cover spring 1 4 we104-4 drive lever 1 42 we104-42 rear discharge cover 1 5 we104-5 h...

  • Page 17

    16 77 we104-77 right press board for belt cover 1 88 we104-88 8" front wheel outer cover 2 78 we104-78 bag cover ventilation 1 89 we104-89 8" front wheel 2 79 we104-79 handle cap 1 90 we104-90 8" front inner cover 2 80 we104-80 70l collection bag 1 91 we104-91 carriage bolt m8x25 2 81 we104-81 70l c...

  • Page 18: Ec Declaration of Conformity

    17 ec declaration of conformity we, importer handy distribution sn3 4ns declare that the product model: wer21hw complies with the following directives: 2006/42/ec- machinery directive 2004/108/ec- electromagnetic compatibility directive 2000/14/ec amended by 2005/88/ec- noise emission in the environ...

  • Page 19

    18.

  • Page 20: Www.Webblawnmowers.Co.Uk

    19 to order spare parts and see the complete range of garden machinery and garden equipment from webb, visit: www.Webblawnmowers.Co.Uk spares & support: 01793 333212.