1. DL manuals
  2. Weber
  3. Grill
  4. 42373
  5. Owner's Manual

Weber 42373 Owner's Manual

Manual is about: BUILT-IN NATURAL GAS GRILL

Summary of 42373

  • Page 1

    Summit ® built-in natural gas grill owner's guide 42373 us 04/01/04 ng us english # 42373 summit ® silver a notice to installer: these instructions must be left with the owner and the owner should keep them for future use. Danger if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any ...

  • Page 2

    2 dangers & warnings danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. Warnings do not store a spare or disconnected liquid propane cylinder under or nea...

  • Page 3

    3 warranty warranty weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber ® gas grill that it will be free of defects in mate- rial and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accom...

  • Page 4

    4 general instructions cleaning warning: turn your weber ® gas barbecue off and wait for it to cool before cleaning. Caution: do not clean your flavorizer ® bars or cooking grates in a self-cleaning oven. For availability of replacement cooking grates and flavorizer ® bars contact the customer servi...

  • Page 5

    55 gas instructions check for gas leaks danger do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily injury or death and damage to ...

  • Page 6

    66 gas instructions remove the front panel by sliding the panel up and out of the slots. Check: 1) gas line-to-manifold connections. Warning: if there is a leak at connection (1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tig...

  • Page 7

    77 operating instructions the most important thing to know about grilling is which cooking method to use for a specifi c food, direct or indirect. The difference is simple: place the food directly over the fi re, or arrange the fi re on either side of it. Using the right method is the shortest route...

  • Page 8

    88 operating instructions indirect cooking the indirect method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor, and appearance you can’t get from an oven. To set up for indirect cooking, gas burners are lit on either side of the food but not directly be- neath i...

  • Page 9

    99 operating instructions *the grill illustrated may have slight differences than the model purchased. To extinguish push down and turn each burner control knob clock- wise to the off position. Turn gas supply off at the source. 1 2 2 3 6 4,5,8 7 lighting summary lighting instructions are on the con...

  • Page 10

    10 10 operating instructions manual lighting *the grill illustrated may have slight differences than the model purchased. To extinguish push down and turn each burner control knob clock- wise to the off position. Turn gas supply off at the source. 2 1 2 4,5,7 6 3 danger failure to open lid while ign...

  • Page 11

    11 problem check cure burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect spider / insect screens for possible obstructions. (blockage of holes.) clean spider / insect screens. (see section “annual maintenance”) burner does not light, or fl ame is low in high p...

  • Page 12

    12 12 maintenance weber ® spider /insect screens your weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the a...

  • Page 13: Replacing Main Burners

    13 13 maintenance replacing main burners 1. Your summit ® gas grill must be off and cool. 2. Turn gas off at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove smoker box. 6. Remove flavorizer ® bars. 7. To remove control panel refer to “remove the control panel” under “check for g...

  • Page 14

    14 14 maintenance 11. Lift and twist the burner assembly slightly, to sepa- rate the crossover ® tube (a) from the burners (b). 12. Remove the crossover ® tube. 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. 14. To reinstall the manifold assembly, rev...

  • Page 15

    15 15 maintenance crossover ® ignition system operations if the crossover ® ignition system fails to ignite the left burner in a burner set, light the left burner with a match. If the left burner lights with a match, then check the crossover ® ignition system. • check that both ignition wires(1,2) a...