1. DL manuals
  2. Weber
  3. Grill
  4. 43721
  5. Owner's Manual

Weber 43721 Owner's Manual

Manual is about: Natural Gas Grill

Summary of 43721

  • Page 1

    S u m m i t ® warning: follow all leak-check procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. Notice to installer: these instructions must be left with the owner and the owner should keep them for future use. This gas appliance is de...

  • Page 2: Dangers & Warnings

    A-2 dangers & warnings danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. Warnings do not store a spare or disconnected liquid propane cylinder under or ne...

  • Page 3: Contents

    A-3 contents danger & warnings .................................................................................. A-2 warranty .................................................................................................. A-4 general instructions ....................................................

  • Page 4: Warranty

    A-4 weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompanying it. Weber ...

  • Page 5: General Instructions

    A-5 general instructions your weber ® gas barbecue is a portable outdoor cooking appliance. With the weber ® gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer ® bars produce that “outdoor” f...

  • Page 6: General Instructions

    A-6 general instructions grilling methods note: if grill looses heat while cooking refer to the troubleshooting section of this manual. Warning: do not move the weber ® gas barbecue when operating or while barbecue is hot. You can adjust the left and right burners in each burner set as desired. The ...

  • Page 7: Summit

    A-7 summit ® silver b exploded view 5 43 1 2 summit ® silver b ng 111202 7 12 13 14 16 22 23 25 26 27 28 29 30 31 33 38 39 40 41 49 52 53 54 56 63 64 65 66 42 21 4 8 10 15 17 18 19 24 32 34 51 11 9 57 67 47 48 50 3 35 36 6 58 20 68 59 60 61 62 55 69 46 44 37 45.

  • Page 8: Summit

    A-8 summit ® silver b exploded view list 1. Hinge pin 2. Thermometer hardware 3. Thermometer bezel 4. Warm-up ™ basket 5. 12 inch cooking grate 6. Left flavorizer ® bar assembly 7. Cookbox assembly hardware 8. 1/4 - 20 hex nut 9. Electrode assembly 10. Crossover ® tube 11. Left burner tube 12. 1/4 -...

  • Page 9: Summit

    A-9 summit ® gold b exploded view 5 44 1 2 summit ® gold b ng 111202 7 13 14 15 17 23 24 26 27 28 29 30 31 32 34 39 40 41 42 45 50 53 54 55 56 57 59 64 65 66 67 68 43 22 4 8 10 16 19 20 21 25 33 35 49 52 58 11 9 60 62 69 63 47 46 48 51 3 36 37 6 70 12 18 61 38.

  • Page 10: Summit

    A-10 summit ® gold b exploded view list 1. Hinge pin 2. Thermometer hardware 3. Thermometer bezel 4. Warm-up ™ basket 5. 12 inch cooking grate 6. Left flavorizer ® bar assembly 7. Cookbox assembly hardware 8. 1/4 - 20 inch hex nut 9. Electrode assembly 10. Crossover ® tube 11. Left burner tube 12. R...

  • Page 11: Summit

    A-11 summit ® silver b parts list lid - 1 cookbox - 1 left frame assembly - 1 right frame assembly - 1 side table - 1 side burner - 1 bottom shelf - 1 rear panel - 1 left door - 1 right door - 1 warming rack - 1 warm-up ™ rack - 1 rear frame rail - 1 front frame rail - 1.

  • Page 12: Summit

    A-12 hose - 1 catch-pan holder - 1 catch-pan - 1 disposable drip pans - 2 wrench - 1 7/16 inch wrench - 1 flavorizor ® bars - 2 sets stainless steel cooking grates - 2 bottom tray - 1 summit ® silver b parts list 1/2 inch bolts (1/4 x 20 x 1/2 inch bolt) - 8 plastic washer - 1 hinge pin- 2 hair pin ...

  • Page 13: Summit

    A-13 summit ® gold b parts list lid - 1 cookbox - 1 left frame assembly - 1 right frame assembly - 1 side table - 1 bottom shelf - 1 rear panel - 1 left door - 1 right door - 1 warming rack - 1 warm-up ™ rack - 1 side burner - 1 rear frame rail - 1 front frame rail - 1.

  • Page 14: Summit

    A-14 catch-pan holder - 1 catch-pan - 1 disposable drip pans - 2 wrench - 1 7/16 inch wrench - 1 flavorizor ® bars - 2 sets stainless steel cooking grates - 3 bottom tray - 1 summit ® gold b parts list hose - 1 1/2 inch bolts (1/4 x 20 x 1/2 inch bolt) - 8 plastic washer - 1 hinge pin- 2 hair pin co...

  • Page 15

    B-a 1 ba401.B a b c (1) (2) (3) (3) caution: before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3). The tab on frame rail (2) must be facing toward the wheels..

  • Page 16

    B-b 2 b a attention! Only start these bolts. Do not tighten yet..

  • Page 17

    B-c 3.

  • Page 18

    B-d b c a 1 2 4 attention! Completely remove both partially started bolts from top rear frame rail attention! Reinstall both bolts through rear panel and into rear frame rail..

  • Page 19

    B-e 5 a (1) (2) (2) (1) (2) (2) attention! Remove packing tape holding the gas line and bracket(1). When installing cookbox route the gas line and bracket(1) inside the frame rails(2)..

  • Page 20

    B-f (1) (2) (3) b 6.

  • Page 21

    B-g 7 (1) (2) (1) (2) c.

  • Page 22

    B-h 8 a b.

  • Page 23: (1)

    B-i 9 (1) (2) (3) a b.

  • Page 24

    B-j a b a b 10

  • Page 25

    B-1 (1) (2) a b (1) b405_ng.A 11 note: igniter wire(1) is located up under right side of control panel..

  • Page 26

    B-2 c d (1) (2)  caution: hold burner cap(1) down while pushing side burner ignition wire(2) on..

  • Page 27

    B-3 a b 12 13 14.

  • Page 28

    B-4 15 16.

  • Page 29

    B-5 b.

  • Page 30

    B-6 b.

  • Page 31: Gas  Instructions

    C-1 gas instructions install gas supply general specifications for piping note - contact your local municipality for building codes regulating outdoor gas barbecue installations. In absence of local codes, you must confirm to the latest edition of ansi z223.1. We recommend that this installation be ...

  • Page 32: Gas  Instructions

    C-2 gas instructions (1) (1) (2) (2) a b connect gas supply a) to connect gas hose at the supply: slide back the collar of the quick disconnect. Push male fitting of the hose into the quick disconnect, and maintain pressure(1). Slide the collar closed(2). If it does not engage or lock, repeat proced...

  • Page 33: Gas  Instructions

    C-3 gas instructions warning : the gas connections of your summit ® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your summit ® gas grill. Remove control panel part required: phillips screwdriver. Remove the burner control knobs...

  • Page 34: Gas  Instructions

    C-4 gas instructions remove the front panel by sliding the panel up and out of the slots. Check for gas leaks  danger do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or exp...

  • Page 35: Gas  Instructions

    C-5 gas instructions check: 1) quick disconnect hose to grill connection 2) side burner hose to manifold connection 3) side burner hose to side burner connection 4) hose to quick disconnect connection (gas supply) 5) valve to manifold connection  warning: if there is a leak at connections(1),(2),(3...

  • Page 36: Gas  Instructions

    C-6 gas instructions (1) (2) a = yellow tab with black wire b = white tab with black wire - + - + a b a = yellow tab with black wire b = white tab with black wire c = green tab with black wire d = grounding wire - + - + c b a d reinstall control panel parts required: control panel, screws, and burne...

  • Page 37: Operating Instructions

    D-1 operating instructions grilling methods note: if grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the left and right burners in each burner set as desired. The control settings are high (h), medium (m), low (l), or off (o). If burners go out dur...

  • Page 38: Operating Instructions

    D-2 operating instructions indirect cooking the indirect method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can’t get from an oven. To set up for indirect cooking, gas burners are lit on either side of the food but not directly beneath it. ...

  • Page 39: Operating Instructions

    D-3 operating instructions 1) open the lid. 2) make sure all burner control knobs are turned off. (push each burner control knob down and turn clockwise to ensure that they are in the off position.) 3) turn the gas supply valve on. Warning: do not lean over the open grill while lighting. 4) select t...

  • Page 40: Operating Instructions

    D-4 operating instructions manual lighting danger failure to open lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) open the lid. 2) make...

  • Page 41: Operating Instructions

    D-5 operating instructions side burner lighting instructions danger failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can cause serious bodily injury or death. Lighti...

  • Page 42: Main Burner Troubleshooting

    D-6 main burner troubleshooting problem check cure burners burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect weber ® insect/spider screens for possible obstructions. (blockage of holes.) clean weber ® insect/spider screens. (see section “annual maintenance”) burner do...

  • Page 43: Side Burner Maintenance

    D-7 problem check cure side burner does not light. Flame is low in high position. Push button ignition does not work. Is gas supply off? Turn supply on. Is the fuel hose bent or kinked? Straighten hose. Does burner light with a match? If match lights burner, checkigniter (see below). Side burner mai...

  • Page 44: Maintenance

    E-1 maintenance (1) (1) main burner flame pattern the weber ® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. 1) burner tube 2) tips occasionally flicker yellow 3) light blue 4) dark blue if the flames do not appear to be uniform th...

  • Page 45: Maintenance

    E-2 maintenance replacing main burners 1. Your summit ® gas grill must be off and cool. 2. Turn gas off at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove smoker box. 6. Remove flavorizer ® bars. 7. To remove control panel refer to “remove the control panel” under “check for gas...

  • Page 46: Maintenance

    E-3 maintenance 10. Disconnect the flexible manifold from the manifold. 11. Remove screws from the manifold assembly: (a) locate the screws on both sides of the manifold frame. (b) remove the screws from manifold frame. (a) (a) (b) (b) (a) (a) (b) (b).

  • Page 47: Maintenance

    E-4 maintenance (a) (b) (b) 12. Pull manifold assembly out from the manifold frame. 13. Lift and twist the burner assembly slightly, to separate the crossover ® tube (a) from the burners (b). 14. Remove the crossover ® tube. 15. Pull the selected burner(s) tube(s) from manifold frame and replace wit...

  • Page 48: Maintenance

    E-5 maintenance crossover ® ignition system operations if the crossover ® ignition system fails to ignite the left burner in a burner set, light the left burner with a match. If the left burner lights with a match, then check the crossover ® ignition system. • check that both ignition wires(1,2) are...