1. DL manuals
  2. Weber
  3. Grill
  4. 55768
  5. Owner's Manual

Weber 55768 Owner's Manual

Manual is about: Natural Gas Grill

Summary of 55768

  • Page 1

    G e n e s i s ® warning: follow all leak-check procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. Notice to installer: these instructions must be left with the owner and the owner should keep them for future use. This gas appliance is ...

  • Page 2: Dangers & Warnings

    A-2 dangers & warnings danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. Warnings do not store a spare or disconnected liquid propane cylinder under or ne...

  • Page 3: Contents

    A-3 contents danger & warnings .................................................................................. A-2 warranty .................................................................................................. A-4 general instructions ....................................................

  • Page 4: Warranty

    A-4 weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompanying it. Weber ...

  • Page 5: General Instructions

    A-5 general instructions your weber ® gas barbecue is a portable outdoor cooking appliance. With the weber ® gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer ® bars produce that “outdoor” f...

  • Page 6: General Instructions

    A-6 general instructions cooking warning: do not move the weber ® gas barbecue when operating or while barbecue is hot. You can adjust the front and back burners as desired. The control settings: high (h), medium (m), low (l), or off (o) are described in your weber ® cookbook. The cookbook uses thes...

  • Page 7: Exploded View

    A-7 exploded view 12 genesis ® silver c premhd ng 102203 5 6 7 8 9 10 11 13 16 17 20 21 22 23 24 25 26 33 34 35 36 37 38 39 40 41 42 43 44 45 34 46 47 50 52 53 18 15 14 48 54 1 2 3 4 27 28 30 31 29 32 19 49 51.

  • Page 8: Exploded View List

    A-8 exploded view list 1. Hinge pin 2. Left endcap 3. Shroud 4. Handle 5. Warm-up ™ basket 6. Warming rack 7. Cooking grates 8. Flavorizer ® bars 9. Cooking box 10. 1/4-20 keps nut 11. Slide out bottom tray 12. Work surface 13. Catch pan holder 14. Left rear trim assembly arm 15. 1/4 - 14 x 5/8 inch...

  • Page 9: Parts List

    A-9 parts list cooking box assembly - 1 caster frame - 1 wheel frame - 1 bottom rack - 1 left trim assembly - 1 right swing up table - 1 side table - 1 flavorizer ® bars - 5 warm-up ™ basket - 1 warming rack - 1 hose - 1 bottom tray - 1 catch-pan holder - 1 catch-pan - 1 disposable drip pans - 2 1 i...

  • Page 10: Unpacking

    A-10 unpacking 1 2 3 4.

  • Page 11

    B-a 1 • push down firmly until bottom rack locking clip, "locks" under the rail. • arrow sticker to the front. B a c 1 2 3 ba303.B.

  • Page 12

    B-b 2 a • push down firmly on both sides to ensure bottom rack is locked under the rails. Warning: do not go to next step if bottom rack is not locked in place b 3 2 1.

  • Page 13

    B-c 3 • install bolts at indicated locations. Use supplied tool to tighten. Recheck each bolt for tightness with a 7/16” open end wrench..

  • Page 14

    B-1 4 b308_lp.C.

  • Page 15

    B-2 5.

  • Page 16

    B-3 6 a b 7.

  • Page 17

    B-4 a b 8 c.

  • Page 18

    B-5 10 9 b a 11 12.

  • Page 19

    B-6 13.

  • Page 20: Gas  Instructions

    C-1 gas instructions install gas supply general specifications for piping note - contact your local municipality for building codes regulating outdoor gas barbecue installations. In absence of local codes, you must confirm to the latest edition of ansi z223.1. We recommend that this installation be ...

  • Page 21: Gas  Instructions

    C-2 gas instructions remove control panel and burner control knobs you will need: phillips screwdriver. 1) remove control knobs. 2) unhook side burner from cookbox frame. 3) remove screws with a phillips screwdriver 4) pull up igniter button until it sticks in the up position and remove control pane...

  • Page 22: Gas  Instructions

    C-3 gas instructions check for gas leaks  danger do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion which can cause serious bodily injury or death and damage to p...

  • Page 23: Operating Instructions

    D-1 operating instructions lighting summary lighting instructions are on the control panel. Danger failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause ser...

  • Page 24: Operating Instructions

    D-2 operating instructions manual lighting danger failure to open lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) open the lid. 2) make...

  • Page 25: Operating Instructions

    D-3 operating instructions the side burner has a separate ignition system from the main cooking box. Danger failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can caus...

  • Page 26: Troubleshooting

    D-4 troubleshooting problem check cure burners burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect weber ® insect/spider screens for possible obstructions. (blockage of holes.) clean weber ® insect/spider screens. (see section “annual maintenance”) burner does not light...

  • Page 27: Side Burner Maintenance

    D-5 side burner maintenance warning: all gas controls and supply valves should be in the off position. Check igniter: remove side burner cover. To remove side burner cover, remove control knob and screws that hold cover to bottom(1). Problem check cure side burner does not light. Flame is low in hig...

  • Page 28: Maintenance

    E-1 maintenance (1) (1) main burner flame pattern the weber ® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. 1) burner tube 2) tips occasionally flicker yellow 3) light blue 4) dark blue if the flames do not appear to be uniform th...

  • Page 29: Maintenance

    E-2 maintenance replacing main burners 1) your weber ® gas barbecue must be off and cool. 2) turn gas off at source. 3) to remove control panel: take off the burner control knobs. Remove the screws holding the control panel in place. Lift off the control panel. 4) unhook the manifold bracket(1) and ...