Platinum ™ series ii natural gas barbecues operating guide notice to installer: these instructions must be left with the owner and the owner should keep them for future use. Warning: follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was d...
2 table of contents warnings 3 warranty 4 a word of thanks 4 standards and codes information 5 storage 5 operating area 5 natural gas supply testing 5 *refer to your step-by-step section at this time lighting 6 crossover ignition system 6 to extinguish 6 manual lighting 7 to extinguish 7 lighting th...
3 warnings danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or a fire or an explosion causing damage to property. ■ do not store a spare or disconnected lp tank under or near this barbecue. ■ improper assembly ...
4 standards and codes information your weber gas barbecue is a portable outdoor cooking appliance. With the weber gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer bars produce that "outdoor...
5 thank you for choosing a weber barbecue. Our family here at weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable customer service staff is prepared to help you with any pr...
6 lighting the main burners warning: check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only weber authorized replacement hose. Order from weber-stephen products co., customer service or...
7 manual lighting 1) open the lid. Figure 2. 2) make sure all burner control knobs are turned off. (push each burner control knob down and turn clockwise.) for barbecues equipped with a side burner, push the burner control knob in and turn clockwise to off. 3) turn gas supply valve on. 4) strike a m...
8 the side burner has a separate ignition system from the main cooking box. Lighting only the side burner. Figure 3. 1) open the side burner lid. 2) check that the side burner valve is off (push in and turn clockwise), and all main burner control knobs are off (push down and turn clockwise). 3) turn...
9 cooking the weber gas barbecue should not be moved when operating or hot. If burners go out during cooking, open lid, turn off all burners and wait 5 minutes before relighting. Note: the temperatures inside your cooking box, for the first few uses, while surfaces are still very reflective, may be ...
10 the steam-n-chips smoker cooks with both weber firespice wood chips and chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the firespice chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and...
11 maintenance spider stopper guards your gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. Thi...
12 maintenance view from behind cooking box wing nuts figure 11 guide screw figure 12 figure 10 replacing main burners a) your weber gas barbecue must be off and cool. B) turn gas off at source. C) to remove the control panel, see the step-by-step guide. D) unlatch the spider stopper guards and remo...
13 figure 16 white wire black wire crossover ignition system operations if the crossover ignition system fails to ignite the front burner, light the front burner with a match. If the front burner lights with a match, then check the crossover ignition system. ■ check that both the white and black ign...
14 troubleshooting problem burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in high position. Experiencing flare-ups: caution: do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when bu...
15 problem side burner does not light. Flame is low in high position. Flame is very yellow in conjunction with the smell of gas, or burner makes popping noise in conjunction with the smell of gas. Push button ignition does not work. Flame is large or erratic. Check is gas supply off? Is fuel hose be...
16 warning: all gas controls and supply valves should be in the off position. Figure 17 (a). Make sure black wire is connected between igniter and electrode. Make sure white wire is connected between igniter and ground. Check that igniter lock nut is tight. Figure 17 (b) and figure 17 (c). Note - if...
17 figure 19 to clean the burner head remove the windshield and grate. Remove the burner cap. Figure 19 (a). Clean with soap and water. Soak if necessary. Remove the burner ring. Figure 19 (b). Clean with soap and water. Soak if necessary. Caution: do not enlarge the slots in the burner ring. Only c...
18 platinum series ii 2200 natural gas exploded view ® ® ® ® ® ® ® ® w eb er w e b e r 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41-44 46 45 47 48 49 50 51.
19 platinum series ii 2200 natural gas replacement parts list 1 hinge pin cotter (2) 2 hinge pin (2) 3 lid (assembly) 4 thermometer 5 weber warm-up basket 6 warming rack 7 steam-n-chips smoker 8 steam-n-chips smoker flue 9 cooking grate (2) 10 cooking box 11 keps nut 12 1/4-20 x 1/2 inch bolt (12) 1...
20 platinum series ii 3200 natural gas exploded view ® ® ® ® ® ® ® ® w ebe r w e be r 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41-44 45 46 47 48 49 50 51.
21 platinum series ii 3200 natural gas replacement parts list 1 hinge pin cotter (2) 2 hinge pin (2) 3 lid (assembly) 4 thermometer 5 weber warm-up basket 6 warming rack 7 steam-n-chips smoker 8 steam-n-chips smoker flue 9 cooking grate (2) 10 cooking box 11 keps nut 12 1/4-20 x 1/2 inch bolt (12) 1...
22 platinum series ii 3400 natural gas exploded view ® ® ® ® ® ® ® ® w ebe r w e be r 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 41-44 45 46 47 48 49 50 51 52 53 54 60 55 59 56 58 40 57.
23 platinum series ii 3400 natural gas replacement parts list 1 hinge pin cotter (2) 2 hinge pin (2) 3 lid (assembly) 4 thermometer 5 weber warm-up basket 6 warming rack 7 steam-n-chips smoker 8 steam-n-chips smoker flue 9 cooking grate (2) 10 cooking box 11 keps nut 12 1/4-20 x 1/2 inch bolt (14) 1...
Patents and trademarks © 1998 weber. Weber, , genesis, flavorizer and crossover are registered u.S. Trademarks; perma- mount, gas catcher, flamecheck, steam-n-chips, spider stopper, and warm-up are u.S. Trademarks of weber-stephen products co., 200 east daniels road, palatine, il 60067-6266. U.S.A. ...
