Notice to installer: these instructions must be left with the owner and the owner should keep them for future use. Warning: f o l l ow all leak ch e ck pro c e d u r e s carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. Warning: do not try to light ...
2 danger failure to fo l l ow the dange rs , warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or a fire or an explosion causing damage to pro p e rt y. Warnings ■ do not store a spare or disconnected lp t a n k under or near this barbecue. ■ improp...
3 table of contents warnings 2 warranty 4 a word of thanks 4 standards and codes information 5 storage 5 operating area 5 natural gas supply testing 5 *refer to your step-by-step section at this time lighting 6-7 crossover ignition system 6-7 to extinguish 7 manual lighting 8-9 to extinguish 9 cooki...
4 a word of thanks weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber gas barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: aluminum castings, 25 years, cooking grates and flavorizer bars, 7 years, all r...
5 your weber gas barbecue is a portable outdoor cooking appliance. With the weber gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer bars produce that "outdoor" flavor in the food. The weber ...
6 lighting each heat zone operates independently. Summary lighting instructions are on the control panel. Crossover ignition system note - the crossover ignition system ignites the left burner of each heat zone with a spark from the igniter electrode inside the gas catcher ignition chamber. You gene...
7 3) turn on gas supply. Wa r n i n g : do not lean over open barbecue. Keep your face and body at least one foot aw ay from the m a t chlight hole when lighting the barbecue. 4) select heat zone. 5) push left burner control knob down and turn to start/hi. 6) push the crossover ignition button sever...
8 manual lighting each heat zone operates independently. Da n g e r failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. Manual lighting ...
9 3) turn gas supply valve on. 4) select heat zone. 5) put a match in the match holder and strike the match. 6) insert match holder and lit match through matchlight hole to ignite left burner. Warning: do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight...
10 c au t i o n : turn your weber gas barbecue off and wait for it to cool before cl e a n i n g . C au t i o n : do not clean your flavo r i zer bars or cooking grates in a self-cleaning ov e n . R e p l a c e m e n t cooking grates and flavo r i zer bars are ava i l a bl e t h rough your retailer ...
11 the steam-n-chips smoker cooks with both we b e r firespice wood chips and chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the firespice chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken ...
12 spider stopper guards your gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. This could resu...
13 maintenance main burner cleaning procedure turn off the gas supply. Remove the manifold. Look inside each burner with a flashlight. Figure 8. Clean the inside of the burners with a wire (a straightened out coat hanger will work). Figure 9. Check and clean the air shutter opening at the ends of th...
14 maintenance 8. Unlatch the spider stopper guards and remove. Figure 12. Figure 12 manifold 9. Pull the manifold out of the burners. Figure 13. Figure 13 7. Disconnect white and black wire from each igniter. Figure 11. Figure 11 black wire white wire summit 4 burner manifold summit 6 burner.
15 12. To reinstall the burners, reverse steps 3 through 11. Caution: the burner openings must be positioned properly over the valve orifices. Figure 16 (a). Check proper assembly before fastening manifold in place. Figure 16 (b). Figure 16 (a) (b) valve burner 13. Reinstall the spider stopper guard...
16 maintenance crossover ignition system operations if the crossover ignition system fails to ignite the left burner, light the left burner with a match. If the left burner lights with a match, then check the crossover ignition system. ■ check that both the white and black ignition wires are attache...
17 troubleshooting problem burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in high position. Experiencing flare-ups: caution: do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when bu...
18 exploded views for summit 425 ng.
19 replacement parts list for summit 425 ng 1 lid 2 thermometer 3 cooking grates (2) 4 flavorizer bar / cooking grate holder (2) 5 flavorizer bar (7) 6 stainless steel work surface (2) 7 condiment holder (2) 8 cooking box 9 crossover tube (2) 10 left burner (2) 11 right burner (2) 12 burner control ...
20 exploded views for summit 450 ng.
21 replacement parts list for summit 450 ng 1 lid 2 thermometer 3 cooking grates (2) 4 flavorizer bar / cooking grate holder (2) 5 flavorizer bar (7) 6 cooking box 7 crossover tube (2) 8 left burner (2) 9 right burner (2) 10 burner control knob (4) 11 igniter (2) 12 igniter lock nut (2) 13 igniter w...
22 exploded views for summit 475 ng.
23 replacement parts list for summit 475 ng 1 lid 2 thermometer 3 flavorizer bar / cooking grate holder (2) 4 flavorizer bar (7) 5 cooking box 6 crossover tube (2) 7 left burner (2) 8 right burner (2) 9 burner control knob (4) 10 igniter (2) 11 igniter lock nut (2) 12 igniter wire (black) (2) 13 ign...
24 exploded views for summit 625 ng.
25 replacement parts list for summit 625 ng 1 lid 2 cooking grates (3) 3 flavorizer bar / cooking grate holder (2) 4 flavorizer bar (11) 5 stainless steel work surface (2) 6 condiment holder (2) 7 crossover tube (3) 8 left burner (3) 9 right burner (3) 10 burner control knob (6) 11 igniter (3) 12 ig...
26 exploded views for summit 650 ng.
27 replacement parts list for summit 650 ng 1 lid 2 cooking grates (3) 3 flavorizer bar / cooking grate holder (2) 4 flavorizer bar (11) 5 stainless steel work surface (2) 6 condiment holder (2) 7 crossover tube (3) 8 left burner (3) 9 right burner (3) 10 burner control knob (6) 11 igniter (3) 12 ig...
28 exploded views for summit 675 ng.
29 replacement parts list for summit 675 ng 1 lid 2 cooking grates (3) 3 flavorizer bar / cooking grate holder (2) 4 flavorizer bar (11) 5 crossover tube (3) 6 left burner (3) 7 right burner (3) 8 burner control knob (6) 9 igniter (3) 10 igniter lock nut (3) 11 igniter wire (black) (3) 12 igniter wi...
Patents & trademarks © 1997 weber-stephen products co. Weber, the silhouette, flavorizer and crossover are registered u.S. Trademarks; summit, grill cozy, gas catcher, spider stopper, and steam-n-chips, are trademarks, all of weber-stephen products co., 200 east daniels road, palatine, il 60067-6266...
