1. DL manuals
  2. Weber
  3. Burner
  4. Summit 42377
  5. Installation & Owners Manual

Weber Summit 42377 Installation & Owners Manual

Manual is about: BUILT-IN NG SIDE BURNER

Summary of Summit 42377

  • Page 1

    Summit ® # 42377 42377 us 01/18/06 ng you must read this owners guide before operating your gas grill built-in ng side burner installation/owner's guide summit ® built-in ng side burner these accessories may be purchased separately. Danger if you smell gas: 1. Shut off gas to the appliance. 2. Extin...

  • Page 2

    2 dangers & warnings danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. Warnings do not store a spare or disconnected liquid propane cylinder under or nea...

  • Page 3

    3 warranty warranty weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompa...

  • Page 4

    4 locating your built-in side burner when determining a suitable location for your built-in side burner installa- tion, give attention to concerns such as exposure to wind, proximity to traffi c paths, and keeping any gas supply lines as short as possible. Never locate the summit ® built-in side bur...

  • Page 5

    5 mounting the side burner connect the corrugated gas line to the side burner valve located on the back right hand side of side burner. Test connections all connections and joints must be thoroughly tested for leaks in accordance with local codes and all listed procedures in the latest edition of an...

  • Page 6

    6 gas instructions table 10-1 maximum capacity of pipe in cubic feet of gas per hour for gas pressures of 0.5 psi or less and a pressure drop of 0.3 inch water column. (based on a 0.60 specifi c gravity gas) nominal iron pipe size (inches) internal diameter (inches) length of pipe (feet) 10 20 30 40...

  • Page 7

    7 regulator hard piped gas supply top view figure 1 cap (optional side burner) regulator to side burner hard piped gas supply top view figure 2 connect gas supply 1) uncap the fl are fi tting from the optional side burner connection located at regulator. Note: you must connect your side burner to a ...

  • Page 8

    8 gas instructions toside burner toregulator topview check: 1) corrugated gas line-to-accessory “t” connection. 2) main gas supply to regulator warning: if there is a leak a connection(1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists aft...

  • Page 9

    9 (1) (2) (3) operating / maintenance manually lighting the side burner danger failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive fl ame-up which can cause serious bodily injury or d...

  • Page 10

    10 side burner maintenance warning: all gas controls and supply valves should be in the off position. Make sure wire is connected between the igniter and electrode. Spark should be a white/blue color, not yellow. 1) igniter wire 2) burner (3) side burner grate side burner cap side burner ring & head...

  • Page 11

    11 attention: this product has been safety tested and is only certifi ed for use in a specifi c country. Refer to coun- try designation located on outer carton. These parts may be gas carrying or gas burning components. Please contact weber-stephen products co., customer service department for genui...

  • Page 12

    ©2003 the following trademarks are registered in the name of weber-stephen products co., an illinois corporation, located at 200 east daniels road, palatine, illinois 60067 u.S.A. Australia; smokey joe, weber, kettle silhouette ® , genesis, austria; kettle silhouette ® , smokey joe, weber, benelux; ...