Weber Summit 450 Operating Manual

Other manuals for Summit 450: Operating Manual, Step-by-step Manual, Operating Manual, Step-by-step Manual, Step-by-step Manual, Instructions Manual

Manual is about: LP Gas Barbecues

Page of 18

Download

Print this page

Bookmark us

SUMMIT

450 & 650

LP Gas Barbecues

Operating Guide

72626

01/24/02

Read before assembly

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flames.

3. Open lid.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire service. Leaking gas

may cause a fire or explosion which can

cause serious bodily injury or death, or

damage to property.

WARNING:

1. Do not store or use petrol or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

2. A gas supply cylinder not connected for

use should not be stored in the vicinity

of this or any other appliance.

WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if

barbecue was dealer assembled.

WARNING: Do not try to light the Weber

Gas Barbecue without first reading the

“Lighting” instructions in this manual.

INFORMATION FOR THE INSTALLER:

This manual must remain with the owner,

who should keep it for future use.

OUTDOOR USE ONLY.

1 2 3 4 5 6 7 Next › »

Summary of Summit 450

Page 1
Summit tm 450 & 650 lp gas barbecues operating guide w e b e r w e b e r w e b e r w e b e r 72626 01/24/02 read before assembly danger if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately c...
Page 2
2 danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. Warnings do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Imp...
Page 3: Table of Contents
3 table of contents warnings 2 warranty 4 a word of thanks 4 general instructions 5 operating area 5 storage 5 *refer to your step-by-step section at this time lighting 6-7 crossover ignition system 6 to extinguish 7 manual lighting 7-8 to extinguish 8 cooking 9 storage 9 cleaning 9 steam-n-chips sm...
Page 4: A Word of Thanks
4 thank you for choosing a weber barbecue. Our family here at weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable customer service staff is prepared to help you with any pr...
Page 5: General Instructions
5 general instructions your weber gas barbecue is a portable outdoor cooking appliance. With the weber gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer ® bars produce that “outdoor” flavor ...
Page 6: Lighting
1 3 2 1 3 2 6 crossover ignition system lighting crossover ignition system summit 450 summit 650 each heat zone operates independently summary lighting instructions are on the control panel. Danger failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the g...
Page 7: Manual Lighting
7 each heat zone operates independently. 1) open the lid. 2) make sure all burner control knobs are turned off. (push each burner control knob down and turn clockwise.) warning: the storage space under the cooking module is intended for storage of nonflammable items only. Danger failure to open lid ...
Page 8: To Extinguish
8 3) turn the tank on by turning the tank valve counterclockwise. 4) select heat zone. 5) put a match in the match holder and strike the match. 6) insert match holder and lit match through matchlight hole to ignite left burner. Warning: do not lean over open barbecue. Keep your face and body at leas...
Page 9: Cooking
9 cooking warning: turn your weber gas barbecue off and wait for it to cool before cleaning. Caution: do not clean your flavorizer ® bars or cooking grates in a self-cleaning oven. For availability of replacement cooking grates and flavorizer bars contact the customer service representative in your ...
Page 10
10 the steam-n-chips smoker cooks with both weber firespice wood chips and chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the firespice chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and...
Page 11: Refilling The Liquid
11 refilling the liquid propane cylinder we recommend that you refill the lp cylinder before it is completely empty. Removal of the lp cylinder 1) close cylinder valve (turn clockwise). 2) unscrew regulator coupling by turning counterclockwise, by hand only. 3) loosen cylinder lock wing nut and turn...
Page 12: Safe Handling Tips
12 hook the liquid propane cylinder onto the fuel gauge. Loosen the cylinder lock wing nut. Swing the cylinder lock down. Tighten the wing nut. Remove plastic dust cover from the fuel cylinder valve. Screw the regulator coupling onto the cylinder valve(1), clockwise, or to the right. Hand tighten on...
Page 13: General Maintenance
13 spider/insect screens your gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section venturi(1) of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. This...
Page 14: General Maintenance
14 general maintenance replacing main burners 1. Your weber gas barbecue must be off and cool. 2. Turn off gas at source. 3. Disconnect regulator. 4. To remove control panel refer to “remove the control panel and the front panel” in the step-by-step guide. 5. Remove cooking grates. 6. Remove flavori...
Page 15: General Maintenance
15 10. Slide the burner assembly from each heat zone. The left and right burners are connected by the crossover tube. ( 1) 9. Pull the manifold(1) out of the burners. General maintenance figure 13 pull out of here crossover tube summit 450 summit 650
Page 16: General Maintenance
16 general maintenance 11. Lift and twist the burner assembly slightly to separate the crossover tube(1) from the burners. Remove the burners from the cooking box. Separate here (1) 12. To reinstall the burners, reverse steps 3 through 11. Caution: the burner openings must be positioned properly ove...
Page 17: Troubleshooting
17 problem burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in high position. Experiencing flare-ups: caution: do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when burner is on high....