1. DL manuals
  2. Weber
  3. Grill
  4. Summit 625 NG
  5. Operating Manual

Weber Summit 625 NG Operating Manual

Other manuals for Summit 625 NG: Step-by-step Manual
Manual is about: Natural Gas Barbecues

Summary of Summit 625 NG

  • Page 1

    W e b e r w e b e r summit ™ 4 burner & 6 burner serial number serial number summit 4 burner ng summit 6 burner ng 92774 10/98 ® r a p p r o v e d canadian gas association w e b e r w e b e r read before assembly natural gas cooking modules operating guide w e b e r w e b e r w e b e r w e b e r war...

  • Page 2: Danger

    2 danger failure to follow the dangers, warnings and cautions contained in this owner’s manual may result in serious bodily injury or death, or a fire or an explosion causing damage to property. Warnings ■ do not store a spare or disconnected lp tank under or near this barbecue. ■ improper assembly ...

  • Page 3: Table of Contents

    3 table of contents warnings 2 warranty 4 a word of thanks 4 standards and codes information 5 storage 5 operating area 5 natural gas supply testing 5 *refer to your step-by-step section at this time lighting 6-7 crossover ignition system 6-7 to extinguish 7 manual lighting 8-9 to extinguish 9 cooki...

  • Page 4: A Word of Thanks

    4 a word of thanks weber-stephen products co. (weber) hereby warrants to the original purchaser of this weber gas barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: aluminum castings, 25 years, cooking grates and flavorizer bars, 7 years, all r...

  • Page 5: Refer to Your Step-By-

    5 your weber gas barbecue is a portable outdoor cooking appliance. With the weber gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and flavorizer bars produce that "outdoor" flavor in the food. The weber ...

  • Page 6: Lighting

    6 lighting 1) open the lid. Figure 1. 2) make sure all burner control knobs are off. (push each burner control knob down and turn clockwise.) 3) turn on gas supply. Warning: do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barb...

  • Page 7: Lighting (Continued)

    7 figure 1 crossover ignition system summit 425 or 450 2 1 3 3 1 2 crossover ignition system summit 625 or 650 1 3 2 crossover ignition system summit 475 1 2 3 crossover ignition system summit 675 lighting (continued).

  • Page 8: Manual Lighting

    8 manual lighting each heat zone operates independently. Summary lighting instructions are on the control panel. Manual lighting summit 425 or 450 high medium low off 2 1 3 3 1 2 manual lighting summit 625 or 450 1 3 2 1 2 3 manual lighting summit 475 manual lighting summit 475 figure 2 warning: the...

  • Page 9: Manual Lighting (Continued)

    9 5) put a match in the match holder and strike the match. 6) insert match holder and lit match through matchlight hole to ignite left burner. Figure 3. Figure 3 control panel matchlight hole in control panel hole in cooking box assembly left burner tube manual lighting (continued) warning: do not l...

  • Page 10: Cooking

    10 warning: turn your weber gas barbecue off and wait for it to cool before cleaning. Caution: do not clean your flavorizer bars or cooking grates in a self-cleaning oven. Replacement cooking grates and flavorizer bars are available through your retailer or the weber-stephen customer service center....

  • Page 11

    11 the steam-n-chips smoker cooks with both weber firespice wood chips and chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the firespice chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and...

  • Page 12: Maintenance

    12 spider/insect screens your gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5. This could resu...

  • Page 13: Maintenance

    13 maintenance figure 8 figure 9 replacing main burners 1. Your weber gas barbecue must be off and cool. 2. Turn off gas at source. 3. To remove control panel refer to “remove the control panel and the front panel” in the step-by-step guide. 4. Remove cooking grates. 5. Remove flavorizer bars. 6. Re...

  • Page 14: Maintenance

    14 maintenance manifold 8. Pull the manifold out of the burners. Figure 12. Figure 12 7. Disconnect white and black wire from each igniter. Figure 11. Figure 11 black wire white wire summit 4 burner manifold summit 6 burner.

  • Page 15: Maintenance

    15 11. To reinstall the burners, reverse steps 3 through 10. Caution: the burner openings must be positioned properly over the valve orifices. Figure 15(a). Check proper assembly before fastening manifold in place. Figure 15 (b). Figure 15 (a) (b) valve burner maintenance 9. Slide the burner assembl...

  • Page 16: Maintenance

    16 maintenance crossover ignition system operations if the crossover ignition system fails to ignite the left burner, light the left burner with a match. If the left burner lights with a match, then check the crossover ignition system. ■ check that both the white and black ignition wires are attache...

  • Page 17: Troubleshooting

    17 troubleshooting problem burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in high position. Experiencing flare-ups: caution: do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when bu...

  • Page 20: Patents & Trademarks

    Patents & trademarks © 1997 weber-stephen products co. Weber, the silhouette, flavorizer and crossover are registered u.S. Trademarks; summit, grill cozy, gas catcher, spider stopper, and steam-n-chips, are trademarks, all of weber-stephen products co., 200 east daniels road, palatine, il 60067-6266...