- DL manuals
- Weed Eater
- Lawn Mower
- 182983
- Owner's Manual
Weed Eater 182983 Owner's Manual - Operation
9
OPERATION
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning.
BATTERY
CAUTION OR
WARNING
REVERSE
FORWARD
FAST
SLOW
ENGINE ON
ENGINE OFF
OIL PRESSURE
LIGHTS ON
FUEL
CHOKE
MOWER HEIGHT
PARKING BRAKE
LOCKED
UNLOCKED
REVERSE
NEUTRAL
HIGH
LOW
ATTACHMENT
CLUTCH ENGAGED
MOWER LIFT
DANGER, KEEP HANDS AND FEET AWAY
FREE WHEEL
(Automatic Models only)
OVER TEMP
LIGHT
PARKING BRAKE
IGNITION
ATTACHMENT
CLUTCH DISENGAGED
P
KEEP AREA CLEAR
SLOPE HAZARDS
15
15
15
(SEE SAFETY RULES SECTION)
Summary of 182983
Page 1
Model no. We1538b 15 hp 38 inch lawn tractor for parts and service, contact our authorized distributor: call 1-800-849-1297 for technical assistance: call 1-800-829-5886 182983 rev. 1 06.05.02 rh printed in u.S.A. ®.
Page 2: Safety Rules
2 i. General operation • read, understand, and follow all instructions in the manual and on the machine before starting. • only allow responsible adults, who are familiar with the instructions, to operate the machine. • clear the area of objects such as rocks, toys, wire, etc., which could be picked...
Page 3: Safety Rules
3 safe operation practices for ride-on mowers safety rules • be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. • never carry passengers or children even with the blades off. • do not mow in reverse unless absolutely necessary. Al- ways look down and beh...
Page 4: Table of Contents
4 product specifications gasoline capacity 1.25 gallons and type: unleaded regular oil type (api-sf-sj): sae 30 (above 32°f) sae 5w-30 (below 32°f) oil capacity: 3 pints spark plug: champion rc12yc (gap: .030") ground speed (mph): forward: 1st 1.1 2nd 2.2 3rd 3.3 4th 4.4 5th 4.9 reverse: 1.4 tire pr...
Page 5: Unassembled Parts
5 unassembled parts steering wheel steering wheel insert steering boot steering wheel adapter (1) bolt (1) washer 17/32 x 1-3/16 x 12 gauge seat (2) keys slope sheet keys (1) lock washer 1/2 steering extension shaft (1) large flat washer (1) oil drain tube for future use (1) hex bolt 1/4-28 x 1-1/4 ...
Page 6: Assembly
6 assembly your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper ...
Page 7: Assembly
7 assembly to roll tractor off skid (see operation section, page 10, for location and function of controls) • press lift lever plunger and raise attachment lift lever to its highest position. • release parking brake by depressing clutch/brake pedal. • place gearshift lever in neutral (n) position. •...
Page 8: Assembly
8 assembly 3 checklist before you operate and enjoy your new trac- tor, we wish to assure that you receive the best performance and satisfaction from this quality product. Please review the following checklist: ✓ all assembly instructions have been completed. ✓ no remaining loose parts in carton. ✓ ...
Page 9: Operation
9 operation these symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. Battery caution or warning reverse forward fast slow engine on engine off oil pressure lights on fuel choke mower height parking brake locked unlocked reverse neutral ...
Page 10: Operation
10 operation know your tractor read this owner's manual and safety rules before operating your tractor compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Our tractors conform to the safety...
Page 11: Operation
11 operation the operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles...
Page 12: Operation
12 operation to operate mower (see fig. 6) your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. • select desired height of cut. • start mower blades by enga...
Page 13: Operation
13 operation mowing tips • tire chains cannot be used when the mower housing is attached to tractor. • mower should be properly leveled for best mowing performance. See “to level mower housing” in the service and adjustments section of this manual. • the left hand side of mower should be used for tr...
Page 14: Customer Responsibilities
14 customer responsibilities before each use t r a c t 0 r inspect muffler/spark arrester lubrication chart check brake operation clean air filter change engine oil (with oil filter) replace air filter paper cartridge replace spark plug check battery level check tire pressure clean battery and termi...
Page 15: Customer Responsibilities
15 customer responsibilities blade removal (see fig. 8) • raise mower to highest position to allow access to blades. • remove blade bolt, lock washer and flat washer secur- ing blade. • install new or resharpened blade with trailing edge up towards deck as shown. Important: to ensure proper assembly...
Page 16: Customer Responsibilities
16 customer responsibilities engine lubrication only use high quality detergent oil rated with api service classification sf-sj. Select the oil’s sae viscosity grade according to your expected operating temperature. Temperature range anticipated before next oil change sae viscosity grades -20 0 30 4...
Page 17: Customer Responsibilities
17 customer responsibilities air filter (see fig. 13) your engine will not run properly using a dirty air filter. Clean the foam pre-cleaner after every 25 hours of operation or every season. Service paper cartridge every 100 hours of operation or every season, whichever occurs first. Service air cl...
Page 18: Customer Responsibilities
18 customer responsibilities muffler inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. Spark plugs replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug ...
Page 19: Service and Adjustments
19 38 38 42 42 service and adjustments fig. 15 suspension arms retainer spring anti-sway bar housing guide collar large retainer spring clutch spring small retainer spring bracket retainer springs (both sides) front link engine pulley square hole to remove mower (see fig. 15) mower will be easier to...
Page 20: Service and Adjustments
20 to replace mower blade drive belt (see fig. 20) the mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. Belt removal - • place attachment clutch in “disengaged” position. • move attachment lift lever forward to lower mower to its lowest p...
Page 21: Service and Adjustments
21 service and adjustments to adjust brake (see fig. 21) your tractor is equipped with an adjustable brake system which is mounted on the right side of the transaxle. If tractor requires more than six (6) feet stopping distance at high speed in highest gear on a level dry concrete or paved surface, ...
Page 22: Service and Adjustments
22 service and adjustments fig. 25 fig. 26 seat pan keps nut hex bolt positive (red) cable negative (black) cable terminal cover replacing battery (see figs. 25 and 26) caution: do not short battery terminals by allowing a wrench or any other object to contact both terminals at the same time. Before...
Page 23: Service and Adjustments
23 service and adjustments fig. 28 to remove hood and grill assembly (see fig. 27) • raise hood. • unsnap headlight wire connector. • stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor. • to replace, reverse above procedure. Fig. 27 headlight wire connector ho...
Page 24: Storage
24 storage immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. Caution: never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing ...
Page 25: Troubleshooting Points
25 troubleshooting points will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “choked” properly. 2. See “to start engine” in operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/r...
Page 26: Troubleshooting Points
26 troubleshooting points problem cause correction engine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not when operator leaves corrected, contact an authorized service center/ seat with attachment department. Clutch engaged poor c...
Page 27
27 tractor - - model number we1538b schematic battery fuse ignition switch red red red black ignition unit headlights removable connections black black black white white white red black orange black brown black black black starter m seat switch (not occupied) grounding connector att'ment clutch (clu...
Page 28: Repair Parts
28 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 48 16 16 22 21 repair parts tractor - - model number we1538b electrical 52.
Page 29: Repair Parts
29 1 163465 battery 2 74760412 bolt hex hd 1/4-20unc x 3/4 8 176689 box battery 16 176138 switch interlock 21 166181 harness asm light w/4152j 22 4152j bulb light #1156 24 4799j cable battery 6 ga 11"red 25 146147 cable battery 26 175158 fuse 20 amp 27 73510400 nut keps hex 1/4-20 unc 28 4207j cable...
Page 30: Repair Parts
30 repair parts tractor - - model number we1538b chassis 3 2 35 3 26 35 3 26 33 10 34 1 208 11 17 29 28 208 13 12 51 57 53 52 54 55 24 26 25 26 25 3 31 24 30 209 8 209 6 16 9 15 209 209 5 5 58 145 37 37 18 206 205 205 38 38 212.
Page 31: Repair Parts
31 repair parts tractor - - model number we1538b chassis key part no. No. Description note: all component dimensions given in u.S. Inches 1 inch = 25.4 mm. 1 174620 chassis 2 176554 drawbar, stretch 3 17060612 screw 3/8-16 x 3/4 5 155272 bumper, hood/dash 6 174643x013 saddle silkscreen 8 155138 clip...
Page 32: Repair Parts
32 repair parts tractor - - model number we1538b drive 29 28 112 14 41 38 39 57 51 74 75 78 76 77 25 26 19 24 2 53 35 34 37 36 35 62 36 64 65 59 56 212 55 63 116 70 77 61 22 27 26 6 113 18 51 5 18 6 52 30 32 32 30 52 11 21 4 3 13 10 8 12 12 7 250 250 1 145 96 26 79 52 66 27 51 48 151 202 49 47 50 12...
Page 33: Repair Parts
33 repair parts tractor - - model number we1538b drive key part no. No. Description key part no. No. Description 1 - - - - - - - transaxle peerless model 205-544c (order parts from transaxle manufacturer) 2 146682 spring return brake 3 123666x pulley transaxle 18"tires 4 12000028 ring retainer # 510...
Page 34: Repair Parts
34 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82 88 71 17 29 43 91 repair parts tractor - - model number we1538b steering.
Page 35: Repair Parts
35 1 140044x428 wheel steering ayp/p/l blk 2 175131 axle asm 3 169840 spindle asm lh 4 169839 spindle asm rh 5 6266h bearing race thrust harden 6 121748x washer 25/32 x 1-5/8 x 16 ga 7 19272016 washer 27/32 x 1-1/4 x 16 ga 8 12000029 ring klip #t5304-75 9 3366r bearing col strg blk 10 175121 link dr...
Page 36: Repair Parts
36 2 1 optional equipment spark arrester 29 44 46 32 31 33 37 33 62 13 4 72 78 81 3 16 78 23 45 14 38 40 26 25 repair parts tractor - - model number we1538b engine.
Page 37: Repair Parts
37 key part no. No. Description 1 170551 control th/ch flag 2 17720408 screw hex thd cut 1/4-20 x 1/2 3 - - - - - - - - engine, b&s 28u707 (order parts from engine manufacturer) 4 137352 muffler exhaust b&s 13 165291 gasket eng 1 313 id tin plated 14 148315 plug drain oil easy 16 11050600 washer loc...
Page 38: Repair Parts
38 repair parts tractor - - model number we1538b seat key part no. No. Description 1 127426x seat 2 140551 bracket seat pivot 3 71110616 bolt hex 3/8 - 16 x 1 4 19131610 washer 13/32 x 1 x10ga. 5 145006 clip push-in hinged 6 73800600 nut lock hex w/ins 3/8 - 16 7 124181x spring seat cprsn 2 250 blk ...
Page 39: Repair Parts
39 repair parts tractor - - model number we1538b decals key part no. No. Description 1 101892x decal, clutch/brake eng/fr 2 180888 decal, replacement 3 180972 decal, engine hp 4 170563 decal warning 5 180521 decal, pnl sd 6 157140 decal, fender danger english 7 162398 decal ins str wh 9 171448 decal...
Page 40: Repair Parts
40 repair parts tractor - - model number we1538b mower lift 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13.
Page 41: Repair Parts
41 repair parts tractor - - model number we1538b mower lift 1 159460 wire asm inner/sprg w/plunger 2 159471 shaft asm lift rh 3 105767x pin groove 1 500 zinc 4 12000002 e ring #5133-62 5 19211621 washer 21/32 x 1 x 21 ga 6 120183x bearing nylon blk 629 id 7 109413x grip handle bicycle matte blk 8 12...
Page 42: Repair Parts
42 repair parts tractor - - model number we1538b mower deck 19 86 38 42 2 15 14 13 11 10 9 8 1 21 2 96 97 29 27 23 26 28 25 24 21 87 88 21 146 31 40 150 45 32 33 69 55 56 36 36 89 123 113 53 30 109 89 122 40 89 108 107 68 4 3 5 6 2 21 149 16 21 2 110 54 148 152 151 153 154 157 158 67 153 156 155.
Page 43: Repair Parts
43 repair parts tractor - - model number we1538b mower deck key part no. No. Description 1 170280 mower housing assembly 2 72140506 bolt carriage 5/16-18 x 3/4 3 138017 bracket asm fr. Sway bar 4 169970 bracket deck sway bar 38"/42" 5 4939m retainer spring 6 178024 bar sway deck 8 850857 bolt 3/8-24...
Page 44: Service Notes
44 service notes.
Page 45: Limited Warranty
45 limited warranty the manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and workmanship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, with...
Page 46: Service
46 t e c u m s e h ® issued january 1980 revised january 1991 t e c u m s e h ® service p o l i c y warranty limited warranties for new peerless gear power train components a. Products warranted peerless gear and machine division of tecumseh products company (“tecumseh”), subject to the limitations ...
Page 47
47 15 degrees max. Fold alon g dot ted l ine this is a 15 d egree slop e only ride up and down hill, not across hill suggested guide for sighting slopes for safe operation warning: to avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes ...
Page 48
®.