1. DL manuals
  2. Wood Stone
  3. Oven
  4. WS-MS-4-RFG-LP
  5. Installation And Operation Manual

Wood Stone WS-MS-4-RFG-LP Installation And Operation Manual

Manual is about: RFG models

Summary of WS-MS-4-RFG-LP

  • Page 1

    Stone-fired cooking equipment gas-fired oven installation and operation manual additional copies available upon request 1801 w. Bakerview rd. Bellingham wa 98226 usa toll-free 800-988-8103 tel. 360-650-1111 fx. 360-650-1166 www.Woodstone-corp.Com revised october 2005 rfg models.

  • Page 2: Gas Oven Installation and

    Wood stone ws-ms-(4,5,6,7)-rfg gas oven installation and operating instructions do not throw this manual away retain this manual for future reference. Additional copies of this manual and prompt responses to service/maintenance questions are available from wood stone @ 800-988-8103. Important: consu...

  • Page 3: Unloading and Moving

    Questions? Call wood stone at 800-988-8103 3 october 2005 rfg oven installation and operation manual unloading and moving lifting the oven 1. Using a crane the oven arrives with four lifting eyes attached. When craning a wood stone oven, use a spreader bar with a two-legged sling rigged on each end....

  • Page 4: Clearances

    Questions? Call wood stone at 800-988-8103 4 october 2005 rfg oven installation and operation manual if this oven is not properly installed a fire may result. To reduce the risk of fire, follow these installation instructions. A major cause of oven related fires is failure to maintain required clear...

  • Page 5: Installation Clearances

    Questions? Call wood stone at 800-988-8103 5 october 2005 rfg oven installation and operation manual installation clearances 1" side clearance to combustible building materials. 14 " 14 " top clearance to combustible building materials. 123456789 123456789 123456789 123456789 123456789 123456789 123...

  • Page 6: Facade Details

    Questions? Call wood stone at 800-988-8103 6 october 2005 rfg oven installation and operation manual wood stone mountain series (ms) ovens carry an nsf/ansi standard 4 component listing. This means that the surfaces of the oven which are meant to be left exposed after the facade has been put in plac...

  • Page 7: Gas

    Questions? Call wood stone at 800-988-8103 7 october 2005 rfg oven installation and operation manual gas the wood stone gas ovens are equipped with a 3/4" npt gas connection located at the rear left of the oven. Have a licensed gas installer provide the hook-up and test all fittings and pipe connect...

  • Page 8: Gas Specifications

    Questions? Call wood stone at 800-988-8103 8 october 2005 rfg oven installation and operation manual hourly natural gas btu input rates for wood stone rfg gas ovens model hourly btu input rate ws-ms-4-rfg-ng 68,000 ws-ms-5-rfg-ng 105,000 ws-ms-6-rfg-ng 105,000 ws-ms-7-rfg-ng 123,000 hourly propane b...

  • Page 9: Electrical

    Questions? Call wood stone at 800-988-8103 9 october 2005 rfg oven installation and operation manual electrical have a licensed electrician wire the transformer terminal strip with a 120v, 15 amp lead. Electrical diagrams are located directly to the right, behind the removable service/intake panel o...

  • Page 10: Oven Venting

    Questions? Call wood stone at 800-988-8103 10 october 2005 rfg oven installation and operation manual oven model series flue collar mt. Chuckanut ws-ms-4 8 inch i.D. Mt. Adams ws-ms-5 10 inch i.D. Mt. Baker ws-ms-6 10 inch i.D. Mt rainier ws-ms-7 10 inch i.D. Sumas mtn. Ws-ms-8 10 inch i.D. The foll...

  • Page 11: Very Important!

    Questions? Call wood stone at 800-988-8103 11 october 2005 rfg oven installation and operation manual very important! Wood stone recommends that you submit your venting plans to local code authorities before proceeding with installation. It is never appropriate to use “b vent” in any part of an exha...

  • Page 12: Assembly

    Questions? Call wood stone at 800-988-8103 12 october 2005 rfg oven installation and operation manual assembly assembly 1. Mount the oven mantle (if provided) using the hardware provided. On page 13). 2. Mount the stainless steel toe kick to the front of the oven stand, near the floor using the hard...

  • Page 13: Mantle Mounting

    Questions? Call wood stone at 800-988-8103 13 october 2005 rfg oven installation and operation manual mantle mounting whether mounting a stainless mantle or a bracket for a granite mantle, the initial steps are the same. 2. Next, place two spacer washers on each stud. 4. Lastly, place one final wash...

  • Page 14: Assembly

    Questions? Call wood stone at 800-988-8103 14 october 2005 rfg oven installation and operation manual assembly standard front panel and toe kick view of throttle assembly throttle knob throttle bracket clamp the throttle knob position can be adjusted inward or outward by loosening the clamp and slid...

  • Page 15: Assembly Diagram

    Questions? Call wood stone at 800-988-8103 15 october 2005 rfg oven installation and operation manual assembly diagram.

  • Page 16: Stucco Application

    Questions? Call wood stone at 800-988-8103 16 october 2005 rfg oven installation and operation manual this figure depicts the application of stucco on a wood stone oven. Use no less than one inch of stucco coating to cover all exposed metal lathing on the oven. Traditional stucco mix 1 part masonry ...

  • Page 17: Oven Startup

    Questions? Call wood stone at 800-988-8103 17 october 2005 rfg oven installation and operation manual oven startup initial oven startup first day 1. Make sure main gas supply is on (valve parallel with gas line). 2. Make sure the switch on the honeywell control gas valve is in the on position. 3. Re...

  • Page 18: Oven Operation

    Questions? Call wood stone at 800-988-8103 18 october 2005 rfg oven installation and operation manual oven operation important: if at any time you feel that the burner is not operating properly, turn the oven off and call for service. Before servicing, disconnect the electrical supply at the breaker...

  • Page 19: Controller Diagram

    Questions? Call wood stone at 800-988-8103 19 october 2005 rfg oven installation and operation manual 1-360-650-1111 www.Woodstone-corp.Com f c o i on/off button- press to turn oven on and off temperature units- press and hold to switch between fahrenheit and celcius. Hear thtemperature- the hear th...

  • Page 20: Controller Diagram

    Questions? Call wood stone at 800-988-8103 20 october 2005 rfg oven installation and operation manual this figure shows the face of the rfg gas oven controller used on ovens shipped before august 2005. Controller diagram 1-800-988-8103 www.Woodstone-corp.Com hearth temperature f c off on power dome ...

  • Page 21: Also

    Questions? Call wood stone at 800-988-8103 21 october 2005 rfg oven installation and operation manual daily maintenance: oven interior wood stone recommends the use of a long-handled, stiff-bristled brush for sweeping aside excess food particles that will accumulate on the floor of the oven during u...

  • Page 22: Periodic Thermal  Cleaning

    Questions? Call wood stone at 800-988-8103 22 october 2005 rfg oven installation and operation manual periodic thermal cleaning establishing a thermal cleaning schedule wood stone ovens are typically operated at temperatures which preclude the need for cleaning of the interior walls and ceiling (the...

  • Page 23

    Questions? Call wood stone at 800-988-8103 23 october 2005 rfg oven installation and operation manual quick troubleshooting guide problem solution controller will not turn on. 1.Incoming power to oven turned off. Check circuit breaker for circuit supplying the oven. Check that any wall switches exte...

  • Page 24: Electrical Schematic

    Questions? Call wood stone at 800-988-8103 24 october 2005 rfg oven installation and operation manual electrical schematic.

  • Page 25: Electrical Schematic

    Questions? Call wood stone at 800-988-8103 25 october 2005 rfg oven installation and operation manual electrical schematic models shipped before august, 2005..

  • Page 26: Interlock

    Questions? Call wood stone at 800-988-8103 26 october 2005 rfg oven installation and operation manual interlock of oven control to an exhaust fan this connection is intended to interrupt power to the oven until the fan is turned on. S1 is a double pole - single throw switch (provided by others) that...

  • Page 27

    Questions? Call wood stone at 800-988-8103 27 october 2005 rfg oven installation and operation manual burner operation sequence rfg oven - all controllers power on sv2 valve powers igniter and opens pilot valve pilot does not light, sv2 times out, touchpad style controllers will flash ‘chec’* sv2 se...

  • Page 28

    Questions? Call wood stone at 800-988-8103 28 october 2005 rfg oven installation and operation manual wood stone warrants its equipment to the original purchaser against defects in material or manufacture for a period of one year from the original date of purchase, subject to the following exclusion...