1. DL manuals
  2. WOOSIM
  3. Printer
  4. WSP-i450
  5. Operator's Manual

WOOSIM WSP-i450 Operator's Manual

Other manuals for WSP-i450: Operator's Manual
Manual is about: 4inch Rugged Mobile Printer

Summary of WSP-i450

  • Page 1

    Http://www.Woosim.Com model wsp-i450 (4inch rugged printer) rev. 4.0 woosim systems inc. #501, daerung technotown 3th, 448, gasan-dong, geumchun-ku, seoul, korea tel : +82-2-2107-3700 fax : +82-2-2107-3707 url: http://www.Woosim.Com all specifications are subjected to change without notice.

  • Page 2

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 2 ¦ copyright wsp-i450 4inch rugged printer operator’s manual. Copyright ⓒ2012 by woosim systems inc. All rights reserved. The information contained in this manual is the property of woosim systems inc. And may not be reproduced in whole or in part without the...

  • Page 3

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 3 ¦ introduction the wsp-i450 is the ideal solution for mobile banking system , retail, point of sales, credit card transaction, other traveling and mobile computing etc. The general features of wsp-i450 printer are as follows: u compact size (150.9×135.7×63.3...

  • Page 4

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 4 ¦ operating precautions please follow the precautions below to enjoy and maintain the full performance of the printer. U using the printer ● be careful not to drop or bump the printer on a hard surface. ● do not install the printer in direct sunlight or such...

  • Page 5

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 5 ¦ note this equipment has been tested and found to comply with the limits for a class b digital device, pursuant to part 15 the fcc rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. ...

  • Page 6: Contents

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 6 contents 1. Outline. .........................................................................................................................................8 1.1. Model classifications. .........................................................................

  • Page 7

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 7 5.1. Control panel. ..................................................................................................................28 5.2. The self test .........................................................................................................

  • Page 8

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 8 1 1 . . O o u u t t l l i i n n e e . . 1 1 . . 1 1 . . M m o o d d e e l l c c l l a a s s s s i i f f i i c c a a t t i i o o n n s s . . 1 1 . . 2 2 p p r r o o d d u u c c t t p p a a r r t t n n u u m m b b e e r r s s y y s s t t e e m m wsp-i450 ( ) (...

  • Page 9

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 9 1 1 . . 3 3 . . S s p p e e c c i i f f i i c c a a t t i i o o n n s s . . Item specifications print method direct thermal line printing characters per line 92cpl (max) character size eng: 9*24dots, 12*24dots kor: 16*24dots, [24*24dots] optional characters ...

  • Page 10

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 10 item specifications lcd 128×32 dots fstn (blue led backlight ) battery rechargeable 7.4v dc, 2200mah (li-ion) battery duration 1 hour continuous printing battery charger input (100~250v ac, 50~60hz) output(8.4vdc/0.8a), 4hours full charge time environment c...

  • Page 11

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 11 2 2 . . S s e e t t t t i i n n g g u u p p t t h h e e p p r r i i n n t t e e r r . . 2 2 . . 1 1 . . P p r r i i n n t t e e r r & & a a c c c c e e s s s s o o r r i i e e s s your printer box should include these items. If any items are damaged or miss...

  • Page 12

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 12 2 2 . . 2 2 . . P p r r i i n n t t e e r r f f e e a a t t u u r r e e s s ▶ part name.

  • Page 13

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 13 2 2 . . 3 3 . . D d i i m m e e n n s s i i o o n n s s.

  • Page 14

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 14 2 2 . . 4 4 . . R r e e p p l l a a c c i i n n g g p p a a p p e e r r r r o o l l l l . . 1. Make sure that the printer is not receiving data; otherwise, data may be lost. 2. Open the paper cover as the “one-touch” way by pressing the button in the arrow ...

  • Page 15

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 15 2 2 . . 5 5 . . P p o o w w e e r r s s u u p p p p l l y y 2 2 . . 5 5 . . 1 1 . . S s p p e e c c i i f f i i e e d d p p o o w w e e r r s s u u p p p p l l y y 2 2 . . 5 5 . . 2 2 . . I i n n s s t t a a l l l l i i n n g g t t h h e e s s a a m m c c a...

  • Page 16

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 16 2 2 . . 5 5 . . 3 3 . . R r e e c c h h a a r r g g i i n n g g t t h h e e b b a a t t t t e e r r y y p p a a c c k k for recharging the battery pack, install the battery pack in the printer. Insert the battery charger to the charge connector of the print...

  • Page 17

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 17 2 2 . . 6 6 . . S s e e t t o o p p e e r r a a t t i i o o n n m m o o d d e e in keeping on pressing the feed and power button simultaneously until after the error lamp blinks 5 times, the printer comes out at the circumstance to change the printer mode. ...

  • Page 18

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 18 u press mode & power button during the error lamp flickers 5 times. ®you will see present communication mode in the lcd. (uart) ® press the power button twice. And then, interface mode has set to bluetooth mode. U when you press feed button once. ®you will ...

  • Page 19

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 19 2 2 . . 6 6 . . 1 1 . . G g a a p p / / h h o o l l e e s s e e n n s s o o r r s s e e t t t t i i n n g g after setting gap/hole of mark and auto of sensor, the printer is required to save the sensing gap/hole so please press the buttons by self-test way ...

  • Page 20

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 20 mode option bluetooth wlan communication port uart(rs-232c) uart(rs-232c) protocol uart (rs-232c) protocol uart (rs-232c) bluetooth wlan protocol bluetooth protocol wlan bluetooth(iap) - baud rate 9600 bps 19200 bps 38400 bps 57600 bps 115200 bps data bit 7...

  • Page 21

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 21 2 2 . . 7 7 . . C c o o n n f f i i r r m m a a t t i i o o n n o o f f t t h h e e w w i i r r e e l l e e s s s s - - l l a a n n i i n n f f o o r r m m a a t t i i o o n n 2 2 . . 7 7 . . 1 1 . . M m a a c c a a d d d d r r e e s s s s p p r r i i n n t...

  • Page 22

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 22 3 3 . . I i n n t t e e r r f f a a c c e e 3 3 . . 1 1 . . U u a a r r t t ( ( r r s s - - 2 2 3 3 2 2 c c o o r r t t t t l l ) ) & & u u s s b b the wsp-i450 printer has a uart(rs-232c or ttl) & usb interface and is connected by means of a 5 pin mini usb...

  • Page 23

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 23 ② usb pin no. Name function 1 vcc +5v 2 dm data “-” 3 dp data “+” 4 nc. - 5 gnd ground note : ● when data receiving, when it removes the communication cable, it loses a data..

  • Page 24

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 24 3 3 . . 2 2 . . B b l l u u e e t t o o o o t t h h 3 3 . . 3 3 . . W w i i r r e e l l e e s s s s l l a a n n category specification bluetooth spec. Bluetooth ver2.1 + edr / class2 (10m) frequency range 2.4ghz ism band data transmission rate 57600bps fixe...

  • Page 25

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 25 3 3 . . 4 4 . . C c a a r r d d r r e e a a d d i i n n g g & & s s m m a a r r t t c c a a r r d d i i n n s s e e r r t t please take notice that magnetic stripe card should be swapped in direction of arrow. Card can be read in both insert the smart card ...

  • Page 26

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 26 4 4 . . S s m m a a r r t t c c a a r r d d m m o o d d u u l l e e 4 4 . . 1 1 . . G g e e n n e e r r a a l l s s p p e e c c . . U contact smart card reader module for iso/iec-7816 u support asynchronous protocol t=0,t=1 u smart card connection - short c...

  • Page 27

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 27 4 4 . . 2 2 . . C c o o m m m m u u n n i i c c a a t t i i o o n n p p r r o o t t o o c c o o l l s s e e q q u u e e n n c c e e 4 4 . . 2 2 . . 1 1 . . R r e e g g u u l l a a r r o o p p e e r r a a t t i i o o n n 4 4 . . 2 2 . . 2 2 . . I i r r r r e...

  • Page 28

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 28 5 5 . . U u s s i i n n g g t t h h e e p p r r i i n n t t e e r r 5 5 . . 1 1 . . C c o o n n t t r r o o l l p p a a n n e e l l . . U button - feed button : when the printer is on, paper can be feed manually by pressing and holding the feed button for m...

  • Page 29

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 29 5 5 . . 2 2 . . T t h h e e s s e e l l f f t t e e s s t t 5 5 . . 3 3 . . U u s s i i n n g g t t h h e e a a c c c c e e s s s s o o r r y y 5 5 . . 3 3 . . 1 1 . . U u s s i i n n g g t t h h e e s s h h o o u u l l d d e e r r s s t t r r a a p p the s...

  • Page 30

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 30 5 5 . . 3 3 . . 2 2 . . U u s s i i n n g g t t h h e e b b e e l l t t c c l l i i p p following the instruction of the arrow, please put the belt clip in the hole and turn and fix the screw to the right by using a thing like a coin. Afterward, you can use...

  • Page 31: Cautions

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 31 6 6 . . C c o o n n s s u u m m a a b b l l e e p p a a r r t t s s . . 6 6 . . 1 1 . . R r e e c c o o m m m m e e n n d d e e d d p p a a p p e e r r . . 6 6 . . 2 2 . . P p r r i i n n t t i i n n g g p p o o s s i i t t i i o o n n . . Type : thermal pa...

  • Page 32

    Wsp-i450 rev. 4.0 http://www.Woosim.Com 32 7 7 . . R r e e v v i i s s i i o o n n h h i i s s t t o o r r y y date version comments dec. 24. 2010 2.0 2.2 part name additional (sensor) feb 17. 2011 3.0 2.6.1 gap/hole sensor setting aug. 10. 2012 4.0 * 4inch industrial printer → 4inch rugged printer ...