1. DL manuals
  2. Worcester
  3. Boiler
  4. GREENSTAR 29CDi Classic ErP
  5. User Instructions

Worcester GREENSTAR 29CDi Classic ErP User Instructions

Manual is about: GREENSTAR CDi CLASSIC ErP WALL HUNG RSF GAS FIRED CONDENSING COMBINATION BOILER

Summary of GREENSTAR 29CDi Classic ErP

  • Page 1

    Uk/ie user instructions wall hung rsf gas fired condensing combination boiler greenstar cdi classic 6 720 812 179-00. 1o for sealed central heating systems and mains fed domestic hot water 6 720 8 12 179 (2014/07) the appliances are for use with: natural gas or l.P.G. (cat. Ii 2h3p type c13, c33 & c...

  • Page 2

    2 preface greenstar cdi classic combi – 6 720 812 179 (2014/07) preface please read these instructions carefully these instructions are applicable to the worcester, bosch group boiler model stated on the front cover only. These instructions apply in the uk/ie only and must be followed except for any...

  • Page 3

    3 key to symbols and safety instructions greenstar cdi classic combi – 6 720 812 179 (2014/07) 1 key to symbols and safety instructions 1.1 key to symbols warnings the following keywords are defined and can be used in this document: • note indicates a situation that could result in damage to propert...

  • Page 4

    4 general information greenstar cdi classic combi – 6 720 812 179 (2014/07) handover to the user when handing over, instruct the user how to operate the heating system and inform him about its operating conditions. ▶ explain how to operate the heating system and draw the user's attention to any safe...

  • Page 5

    5 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3 operating the boiler 3.1 controls fig. 1 control panel [1] on/off button [2] position for optional programmer [3] display [4] system pressure gauge [5] reset button [6] eco button (only in conjunction with optional divert...

  • Page 6

    6 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.2 switching the boiler on/off fig. 2 switching on ▶ switch on the boiler by pressing the on/off button. The on/off indicator light [1] shows blue. Switching off ▶ switch off the boiler by pressing the on/off button. The o...

  • Page 7

    7 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.3 setting the central heating temperature ▶ turn the central heating temperature control to the desired level, between approximately 35°c and 90°c. When the burner is lit, the burner indicator light [1] underneath the on/...

  • Page 8

    8 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.4 setting the hot water temperature fig. 4 ▶ turn the domestic hot water temperature control [1] to the desired level, between approximately 40°c and 60°c. 6 720 812 178-05.1o 2 3 position hot water temperature min approx...

  • Page 9

    9 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.5 frost protection (for the boiler) activating frost protection will turn off the central heating system. Heating of domestic hot water will stay activated. If the temperature within the boiler drops to 5°c the boiler wil...

  • Page 10

    10 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.7 domestic hot water pre-heat you can choose to run your boiler in pre-heat mode or in eco mode. Pre-heat reduces the time taken to produce hot water at the tap and is controlled by the eeco button. When the eco button i...

  • Page 11

    11 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.8 holiday setting activating the holiday setting will turn off the central heating system. Frost protection and heating of domestic hot water will stay activated. Fig. 7 to activate holiday mode: ▶ press the holiday butt...

  • Page 12

    12 operating the boiler greenstar cdi classic combi – 6 720 812 179 (2014/07) 3.9 fault condition in the event of a fault occurring while the boiler is in operation the reset button [2] and the fault indicator [3] will flash. The display [1] will show a fault code (for fault codes see section 4.3 on...

  • Page 13

    13 maintenance greenstar cdi classic combi – 6 720 812 179 (2014/07) 4 maintenance 4.1 re-pressuring the heating system to re-pressurise the heating system: 1. Remove the bottom panel to gain access to the filling link. The filling link is situated as indicated below. Fig. 9 filling link 2. Pull dow...

  • Page 14

    14 maintenance greenstar cdi classic combi – 6 720 812 179 (2014/07) 3. When the pressure gauge reads 1.5 bar push up the lever [1] back into closed position. This stops filling the heating system with mains water. Fig. 11 stop filling the heating system 6 720 812 479-01.1o 1.

  • Page 15

    15 maintenance greenstar cdi classic combi – 6 720 812 179 (2014/07) 4.2 fault finding this table gives information on basic operating system problems. Problem cause remedy ea fault code flashing on display no gas supply/low gas supply pressure ▶ contact your gas supplier. Condensate outlet blocked ...

  • Page 16

    16 maintenance greenstar cdi classic combi – 6 720 812 179 (2014/07) 4.3 error codes when calling worcester, bosch group, you may be asked for the error code. This table is for you to help identify the possible cause of the fault. ▶ do not try to rectify any of the faults listed below by yourself. ▶...

  • Page 17

    17 general notes greenstar cdi classic combi – 6 720 812 179 (2014/07) 4.4 extreme cold weather in some instances where the condensate pipe work is run externally or in an unheated area, such as a garage, the condensate pipe work can be at risk of freezing, even if well insulated. A frozen/blocked c...

  • Page 18

    18 fault or breakdown greenstar cdi classic combi – 6 720 812 179 (2014/07) ventilation this is a room sealed boiler and does not require any air for combustion from inside the property. If a compartment is built around the boiler after installation, then this must be carried out as described in the...

  • Page 19

    19 tips on energy saving greenstar cdi classic combi – 6 720 812 179 (2014/07) 7 tips on energy saving heating economically the boiler is designed to provide a level of comfort while keeping gas consumption and the resulting environmental effect as low as possible. The gas supply to the burner is co...

  • Page 20

    20 your guarantee greenstar cdi classic combi – 6 720 812 179 (2014/07) 8 your guarantee this boiler has a guarantee against faulty materials or workmanship for a period of two years from the date of installation subject to the following terms and conditions: • during the period of this guarantee an...

  • Page 21

    21 glossary greenstar cdi classic combi – 6 720 812 179 (2014/07) 9 glossary central heating systems all radiators must be heated at an even rate. If the top of a radiator is at a lower temperature than the bottom then it should be bled by releasing air through the bleed screw at the top of the radi...

  • Page 22

    22 greenstar cdi classic combi – 6 720 812 179 (2014/07) notes.

  • Page 23

    23 greenstar cdi classic combi – 6 720 812 179 (2014/07) notes.

  • Page 24

    Worcester, bosch group: technical support: 0330 123 3366 appointments: 0330 123 9339 spares: 0330 123 9779 literature: 0330 123 9119 training: 0330 123 0166 sales: 0330 123 9669 worcester, bosch group cotswold way, warndon, worcester wr4 9sw. Tel. 0330 123 9559 worcester, bosch group is a brand name...