Worksman WTX Assembly Instructions, Parts List, And Owners Manual - page 2
- 2 -
(3) Pedal Installation:
·
The left pedal tightens counter-clockwise so that it does not loosen as you ride.
Pedals and cranks are marked L and R to make sure that you installing the
correct pedal on the correct side. If any left or right part is installed incorrectly,
the crankarm (and possibly the pedal) will strip and eventually loosen-up and
fall off. This installation error is not covered under warranty.
When installing pedals, make sure the left and right crankarms are on the
correct sides, and that you are installing the correct pedals on the correct crankarm. The left pedal is
"reverse-threaded", and is tightened counter-clockwise (to the left). The right pedal is tightened clockwise.
(4) Handlebar Installation:
· Turn screw on top of handlebar stem so that the wedge is at a low
height. Then, insert handlebar stem into front fork tube at desired
height (make sure that it is past the minimum height or damage to the
tube may occur). Now turn screw on top of handlebar stem so that the
wedge rises, locking it in position.
· Slide the handlebars through the opening in the stem, place at desired
angle, and tighten the nut on the bottom of the stem clamp.
· Slide the grips onto the ends of the handlebar.
(5) Seat Installation:
· Install seat post into the clamp under the seat. Tighten clamp nut to
secure seat clamp to seat post.
· Remove the seat bolt from the frame, and place seat post bracket over
the frame. Replace the seat bolt through both the frame and the bracket
holes, and tighten with accompanying nut.
WTX Replacement Parts
155 Handlebar
174HD 5/8
” Bearings (for wheels/axles)
174W Axle washer
50A
Headset
55A Handlebar Stem
55B Grips (pair)
57
Rear Axle Nut (each)
7219 Pedal (pair)
8250V Seat w/ Clamp Assembly
60010 Frame (Specify color)
60011 Rear Wheel w/ Tire
60012 Fork (Specify color)
60013 Seat Bracket w/ Seatpost
60014 Rear Axle
60015 Front Wheel w/ Tire
60016 Crank Arms (pair)
60017 Crank Arm Pins (pair)
60018 Spindle for Front Wheel
60019 Bolt / Nut for Front Wheel
60020 Bolt / Nut for Seatpost Clamp
Worksman Cycles 94-15 100
th
Street Ozone Park, NY 11416 www.worksman.com 718-322-2000