Xb-420m electric mobility scooter read this manual completely before riding. X-treme tm electric scooters.
1 battery maintenance and charging instructions 1. You must charge completely prior to initial use. (follow charging instructions in your product handbook) 2. Charge immediately after each use. 3. Charge before storage. You must charge every 30 days if not in use. 4. Charge the unit for 6-8 hours or...
2 warning this product does not conform to federal motor vehicle standards and is not intended for operation on public streets, roads or highways. Serious injury can result from the unsafe operations of this product. Operator can minimize these risks by using certain safety equipment such as: safety...
3 safety guide the recommended minimum age for riding this scooter is 16 years old. To avoid damage to the motor and footplate, do not overload the scooter. Never ride with more than one person. Inspect your scooter thoroughly before each use for loose or missing parts. Avoid unintentional starts by...
4 contents riding safety ………………………………………….. 5 safety basics & operating instructions…………. 6 wet weather & night riding ………………………. 8 specifications …………………………………………. 11 components ………………………………………….. 12 assembly and setup ……………………………….. 14 routine operation ………………………………….. 16 battery care and maintena...
5 the xb-420m is a highly stylish, environmentally friendly, fossil-fuel-free personal transportation device, incorporating these advanced-design components: highly efficient high torque dc motor. controller with battery indicator and protection from over voltage and under voltage. brake syste...
6 safety basics: do’s and don’ts the do’s o always conduct a safety check before you ride your xb-420m. Be thoroughly familiar with the controls of your xb-420m. O always wear an approved helmet when riding your xb- 420m. Follow the helmet manufacturer’s instructions for fit, use and care of your he...
7 who jumping their xb-420m risk serious damage to their xb-420m and will void their warranty. O never carry anything which obstructs your vision or your complete control of the xb-420m or which could become entangled in the moving parts of the xb- 420m. O never hitch a ride by holding on to another...
8 o ride defensively. To other road users, you may be hard to see. O concentrate on the path ahead. Avoid potholes, gravel and dirt, wet road, oil, curbs, speed bumps, drain grates and other obstacles. O be alert for unexpected events, such as opening car doors or cars backing out of concealed drive...
9 conditions, apply your brakes earlier and more gradually than you would under normal, dry conditions. Decrease your riding speed, avoid sudden braking, and take corners with additional caution. Keep in mind that there is a direct, but inverse, relationship between speed and controllability. Be mor...
10 ride at night only if necessary. Slow down and use familiar roads with street lighting, if possible. Other reminders the xb-420m works best on level ground. Use caution while going down an incline, such as a hill or a ramp. Hill climbing and repeated acceleration/braking will exhaust the battery ...
11 store your xb-420m in a dry place. Exposing your xb- 420m to rain, snow, or other precipitation may result in damage. Specifications product size (l x w x h): 64” x 28” x 40” net weight: 195 lbs carrying capacity: 350 lbs maximum range: ~40 miles maximum speed: 20 mph motor type: geared brush mot...
12 components 1.Battery storage access (tilt seat forward) (4 batteries total) 2. Seat recline adjuster 3. Drop down arm rests 4. Forward/reverse switch 5. Instrument panel 6. Throttle 7. Brake lever 8. Ignition switch 3.
13 1. Brake lever 2. High/low beam selector 3. Rearview mirror 4. Instrument panel 5. Rearview mirror 6. Headlight switch 7. Throttle 8. Ignition switch 9. Forward/reverse switch 10. Turn signal 11. Speed control knob 1 2 4 5 6 7 8 9 10 11.
14 assembly and setup 1) remove your xb-420m from its shipping carton. The xb-420m weighs about 150 lbs, so get help, and use care. Cut away any residual packing materials with a knife or scissors. Tools needed for setup are included in the xb- 420m tool kit. 2) attach the front wheel: a. Place a su...
15 5) check if the brakes are properly adjusted. The brake handles should stop short of touching the handgrip, when fully engaged. The rear brake cable can be adjusted in two places: at the cable end bracket, just before the lever, with 8 and 10 mm wrench adjustments, and at the end of the lever...
16 routine operation a) pre-ride check 1) be sure the tires have enough air. A low tire pressure risk rim pinching (tube failure) and lowers your range (distance per charge). 2) be sure the battery is fully charged. Riding on a low state-of-charge will reduce range, and can damage the battery. 3) ve...
17 4) the xb-420m has an onboard voltmeter, indicating the battery’s approximate state-of-charge. It is normal for this reading to “sag” somewhat during acceleration. Excessive voltage “sag” is a sign of a depleted or damaged battery. When a battery is exhausted, if you force it to supply energy, it...
18 battery care and maintenance what to expect of your batteries, ideally the battery is a sealed lead-acid type, with a gel electrolyte. With normal use, it can last for well over 300 charge/discharge cycles. Know that normal use should mean partial, and not complete discharging. If you employ “sha...
19 what’s inside your xb-420m battery the battery is composed of four 12 volt, 20 amp-hour capacity batteries, in series, for a total capacity of 48 v, 20 ah. The component batteries are a standard, commercially available size. Keep three things in mind, however, should you choose to service your ba...
20 replace the battery if there are leaks, visible breaks or cracks. Dispose of used batteries by taking them to a recycling center, or according to state and local laws. Battery temperature sensitivity ambient temperature will affect almost every kind of battery. Usually, the battery shows good dis...
21 frequent braking and acceleration, driving into headwinds, up hills or with cargo will all cost a lot of battery energy. In these conditions, the xb-420m will not reach its normal range. Battery charging be sure to charge the battery completely if you will not use it for a long period. Ideally, y...
22 3) keep the charger and battery away from water to prevent electrical shock and shorting. The charger is intended for use in a covered dry area only. 4) plug the end of the charger’s cord into the socket of the adaptor first. Next connect the adaptor to the xb-420m (the charger port in located be...
23 important the electric bike is powered by four 12v/20ah batteries wired in series to provide 48 volts of potential. All batteries charge simultaneously. You should charge your xb-420m after each ride. You should charge your xb- 420m if it has not been used for 30 days or more. Warning do not plac...
24 other maintenance your xb-420m should be checked once a year for a thorough inspection and adjustment. This can guarantee the comfort, safety and the normal operating life of the xb-420m. Front and rear brakes the adjustment of the front brake is the same as in a common motorcycle. It is very imp...
25 fuse the xb-420m comes with one 10a glass fuse. The fuse is located under the headlight fairing. Lubrication you should inspect and maintain your xb-420m and lubricate the mechanical power transmission components. The brake cables may also need lubrication lubricate the brake cables with silicone...
26 scheduled maintenance xb-420m should be checked from time to time. Refer to the maintenance schedule in the following chart: check ● adjust ◆ change ▲ lubricate ■ parts daily 30 days 180 days bolts, nuts, screws etc-to ensure that nothing is loose. ● ● ◆ ● ■ footboard-to ensure it is not worn out...
27 troubleshooting guide problem cause solution battery gauge does not register anything when vehicle is on. 1. Loose connection near the power switch or battery pack. 2. Battery is completely discharged. 1. Check the connections, reconnecting any that are loose. 2. Charge the battery. Battery gauge...
28 do not return to store! If you need help call toll free or go online 1-800-772-3852 www.X-tremescooters.Com/support/ for general information or parts visit www.X-tremescooters.Com revised 5/17/10