1. DL manuals
  2. X-TREME
  3. Scooter
  4. XG-575DS
  5. Owner's Manual

X-TREME XG-575DS Owner's Manual

Manual is about: Gas Scooters

Summary of XG-575DS

  • Page 1

    1 x-treme™ gas scooters xg-575ds owner’s manual please be safe when riding always wear a helmet and obey all laws!.

  • Page 2: Table of Contents

    2 table of contents table of contents……………………………………………………………………………………… 2 important information……………………………………………………………………………… 3 safety information……………………………………………………………………………………. 4 getting to know your xg-575ds……………………………………………………………… 5 package contents…………………………………………………………………………………….. 6 getting st...

  • Page 3

    3 please read this first before operating this product where to use your xg-575ds: this product does not conform to federal motor vehicle standards and is not intended for operation on public streets, roads or highways. Serious injury can result from the unsafe operations of this vehicle. Operators ...

  • Page 4

    4 fuel safety mix and pour fuel outdoors away from sparks and flames. Use only a container approved for fuel. Do not smoke or allow smoking near the scooter while working on the engine, or while the engine is running. Wipe up and clean all fuel spills before starting the engine. Move at least 10 met...

  • Page 5

    5 getting to know your a-blaze signature series xg-575ds 1. Gas/throttle lever 13. Choke 2. Front brake lever 14. Belt cover and mud guard 3. Rear brake lever 15. Handlebar down tube 4. Gearshift 16. Pull starter 5. Front disc brake 17. Gas tank 6. 2-stroke engine 18. Gas cap 7. Front fork folding m...

  • Page 6: Package Contents

    6 package contents your x-treme™ a-blaze signature series xg-575ds gas scooter comes with the following items in the box: please locate all of the following: 1. The xg-575ds gas scooter 2. Allen wrench 3. Owner’s manual getting started please read and understand these instructions and the operating ...

  • Page 7

    7 8.) slowly open the gas cap, so that possible over pressure disappears. 9.) clean the tank cap area to make sure that it is free from excess dirt and debris. 10.) pour pre-mixed gas/oil mixture into the gas tank. Tank capacity is 0.9 liters. **do not overfill. 11.) after fueling, replace the gas c...

  • Page 8: Folding And Storage

    8 changing gears 22.) as max rpm is achieved, second gear can be selected by pressing (a). The return to first gear; press (b) (fig. 7). Braking 23.) to brake, release the gas lever and gently press either brake levers (fig. 8). Folding and storage when you are done riding the a-blaze signature seri...

  • Page 9

    9 cycle oil. Mix (shake) the fuel container. Add the remaining amount of fuel. Mix (shake) the fuel oil thoroughly before filling the tank. Fueling warning! 1.) always shut the engine off before refueling. 2.) slowly open the fuel tank, so that possible over-pressure disappears. 3.) before fueling, ...

  • Page 10: Maintenance

    10 maintenance recommended tools to adjust and service the a-blaze signature series xg-575ds gas scooter you will need the following tools: allen keys: 3/4/5/6mm wrenches: 10/13/17mm – open and ring combination short reach spark plug socket water pump pliers philips head screwdrivers oil, grease or ...

  • Page 11

    11 if the scooter continues to move after idle speed adjustment, contact technical support at www.X-tremescooter/support . Cleaning the air filter it is a good idea to occasionally clean the air filter to ensure optimum performance. (replacement of air filter with anything other than the x-treme™ re...

  • Page 12

    12 squeaky brakes the brakes may squeak before they are driven in. This is normal and will not affect the function or performance of the brakes. With continued use, the squeak should go away. Tires and wheels the xg-575ds gas scooter uses an identical rim and tire assembly for the front and rear whe...

  • Page 13

    13 **do not over tighten or it will damage the bearings!! **do not continue to use product if there is too much free play as this will damage the bearings!! Adjusting the belts the belts will come adjusted from the factory. However, it may be necessary to adjust the pulleys from time to time. The be...

  • Page 14

    14 adjusting the free play of the gear selector 1.) the gear selector mechanism uses the same system to adjust as the front and rear brakes. 2.) correct tension is achieved when gear selector is in 1 st gear, the scooter should free wheel backwards. When the scooter is in 2 nd gear, it should not be...

  • Page 15

    15 taken up. Be sure to faster the locknut (no. 2 – fig b) up against the gearbox plate (no. 3 – fig. B). You will now be able to use your primary cable adjuster for minor adjustment and repeat the second step once the primary adjuster knob is out to the maximum. Once you have reached maximum adjust...

  • Page 16

    16 warranty and technical support x-treme scooters offers a 90-day limited bumper-to-bumper manufacturers warranty on all a-blaze signature series xg-575ds gas scooters that are purchased from an authorized dealer or direct. Original purchase receipt required. X-treme scooters will not offer any war...

  • Page 17: Do Not Return to Store!

    17 do not return to store! If you need help, call (253) 777-0690 or go online to www.X-tremescooters.Com/support revised 04/16/13.