- DL manuals
- Xantrex
- Inverter
- 120 VAC/60
- Owner's Manual
Xantrex 120 VAC/60 Owner's Manual - Installation
INSTALLATION
2001 Xantrex Technology, Inc.
5916 - 195th Street N. E.
Arlington, WA 98223
Telephone: 360/435-8826
Fax: 360/435-2229
www.traceengineering.com
SW Series Inverter/Charger
Part No. 2031-5
Rev. C: February 2001
Page
23
DC DISCONNECT AND OVERCURRENT PROTECTION
For safety and to comply with regulations, battery over-current protection is required. Fuses and
disconnects must be sized to protect the wiring in the system. The fuse or disconnect is required to open
before the wire reaches its maximum current carrying capability.
For residential and commercial electrical systems, the National Electrical Code requires both overcurrent
protection and a disconnect switch. These installation parts are not supplied as part of the inverter.
However, Xantrex offers a DC rated, UL listed, circuit breaker disconnect specifically designed for use
with Trace™ inverters for applications requiring NEC compliance. Two amperage ratings are available - a
DC250 (250 amps) and a DC175 (175 amps). These disconnects are available in a single or double pole
configuration to handle either one or two inverters. The DC disconnect enclosure will accommodate up to
four smaller breakers for use as DC load disconnects, PV array disconnects, etc. and the top is designed
to allow direct connection of up to two Xantrex charge controllers. The Trace™ DC disconnect is not
designed to accept doubled (paralleled) cables which may be required for long cable runs. Also, the plastic
red and black covers on the end of the inverter is not designed to accommodate dual cables. If dual
cables are used, the optional conduit box (SWCB) should be used.
When sizing the DC disconnect, the expected continuous load on the inverter is used to determine the DC
current involved. You must account for the efficiency loss through the inverter (see the POWER VS.
EFFICIENCY section on page 59 in this manual) which increases the DC current draw. Divide the
maximum continuous current draw by the lowest efficiency to determine the DC current, a 25% safety
margin should be included to comply with the code requirements. When a breaker has been selected as
the overcurrent device, tighter sizing may be acceptable since the breaker is more easily reset when
compared to a high current, bolt-in type fuse.
Marine and RV installations typically do not require conduit or a means of disconnection, although
overcurrent protection (fuse) is required. Xantrex offers a fuseblock (TFB) that provides the code required
inverter overcurrent protection for residential, commercial, RV and Marine applications.
TFB’s include a fast acting, current limiting class-T fuse to protect your battery, inverter and high
amperage cables from damage by short circuits and overloads. This fuse provides extremely fast
protection when a short circuit occurs. When properly selected, it also has a time delay that allows the
inverter to surge to full power without blowing the fuse. A slide off cover prevents accidental contact with
the fuse’s live terminals. For maximum protection, install the fuseblock within 18 inches (45 cm) of the
battery. The fuses are available in 110, 200, 300, and 400 amp sizes.
Use Table 3 below, to determine the proper size disconnect (breaker) or fuse for the battery cables you
are using. These recommendations may not meet all local code or the NEC requirements, consult your
applicable electrical code for more information regarding acceptable fuse and cable sizes.
Table 3, Battery Cable To Maximum Breaker/Fuse Size
CABLE SIZE
REQUIRED
RATING IN
CONDUIT
MAXIMUM
BREAKER SIZE
RATING IN
“FREE AIR”
MAXIMUM
FUSE SIZE
# 2 AWG
115 amps
125 amps*
170 amps
175 amps*
00 AWG
175 amps
175 amps
265 amps
300 amps*
0000 AWG
250 amps
250 amps
360 amps
400 amps*
*The NEC allows rounding up to the next standard fuse size from the cable rating, i.e. 150-amp cable size
rounds up to a standard 175-amp fuse or breaker size. The term "free air" is defined by the NEC as cabling that
is not enclosed in conduit or a raceway. Cables enclosed in raceways or conduits have substantially lower
continuous current carrying ability due to heating factors.
Contact your Xantrex dealer to order the inverter disconnects/fuses or see the OTHER PRODUCTS
section in this manual on page 129 for more information.
Summary of 120 VAC/60
Page 1
2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 ™ sw series inverter/chargers with revision 4.01 software owner’s manual.
Page 2
2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 3: Product Materials Package
2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 product materials package thank you for choosing xantrex products to meet your powering need...
Page 4
2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 5: Table of Contents
Table of contents 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 table of contents important safety instructions .............................
Page 6: Table of Contents
Table of contents 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 appendix ....................................................................
Page 7: Table of Contents
Table of contents 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 index of figures figure 1, identification label .............................
Page 8: Table of Contents
Table of contents 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 index of tables table 1, ac input and output wiring connections .............
Page 9: Save These Instructions!
Important safety instructions 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 1 important safety instructions save these instructions! ...
Page 10
Important safety instructions page 2 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 3. Use of battery cable or custom attachment not recomm...
Page 11
Important safety instructions 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 3 10. Grounding instructions - this inverter/battery char...
Page 12
Important safety instructions page 4 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 13: Introduction
Introduction 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 5 introduction congratulations! You are the proud owner of the finest inve...
Page 14: Introduction
Introduction page 6 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 15: Unit Identification
Unit identification 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 7 unit identification this section describes the marking and loca...
Page 16: Unit Identification
Unit identification page 8 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 17
Controls, indicators and components 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 9 controls, indicators and components the sw series...
Page 18
Controls, indicators and components page 10 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 contrast control the contrast adjustment enables...
Page 19
Controls, indicators and components 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 11 ac1 in good (green) indicates that ac power is p...
Page 20
Controls, indicators and components page 12 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 ac side figure 4 shows the components located on...
Page 21
Controls, indicators and components 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 13 internal components and indicators additional co...
Page 22
Controls, indicators and components page 14 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 ac safety ground the ac safety ground is used to...
Page 23: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 15 installation this section is very important, since it tells you how to ...
Page 24: Installation
Installation page 16 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 quick install this section provides installers, licensed electrical con...
Page 25: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 17 complete install unpacking before beginning, unpack the inverter/charge...
Page 26: Installation
Installation page 18 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 use 1/4" minimum diameter bolts for mounting. The mounting must be capa...
Page 27: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 19 note: the three neutral terminals are common to each other and can be u...
Page 28: Installation
Installation page 20 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 ac installation guidelines the following steps are a basic guideline fo...
Page 29: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 21 120 vac ground fault interrupt outlets (gfi’s) xantrex has tested the f...
Page 30: Installation
Installation page 22 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 dc wiring caution: the inverter’s maximum peak current requirements are...
Page 31: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 23 dc disconnect and overcurrent protection for safety and to comply with ...
Page 32: Installation
Installation page 24 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery cable connections cables must have crimped (or preferably, sold...
Page 33: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 25 control wiring more advanced installations will require additional wiri...
Page 34: Installation
Installation page 26 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 system grounding grounding instructions - this inverter/charger should ...
Page 35: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 27 in some countries, the neutral is not bonded to the grounding system. T...
Page 36: Installation
Installation page 28 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 figure 13, neutral-to-ground bond switching: external ac source connect...
Page 37: Installation
Installation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 29 grounding vs. Lightning this information is intended to provide basic g...
Page 38: Installation
Installation page 30 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 39: Functional Test
Functional test 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 31 functional test once the ac and dc wiring have been installed and co...
Page 40: Functional Test
Functional test page 32 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 41: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 33 menu system overview the operation of the inverter is determined by the ...
Page 42: Menu System
Menu system page 34 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 user menu map menu heading the values shown are the factory default valu...
Page 43: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 35 setup menu map the setup menu provides all the controls and settings nee...
Page 44: Menu System
Menu system page 36 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 user menu the user menu provides all the controls and settings needed on...
Page 45: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 37 inverter mode (1) menu heading set inverter off srch on chg allows turni...
Page 46: Menu System
Menu system page 38 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 • on - starts the generator that is controlled by the inverter. If this ...
Page 47: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 39 load start amps ready no if yes is displayed, it indicates that the auto...
Page 48: Menu System
Menu system page 40 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 meters (4) menu heading the current meters provided measure only the rea...
Page 49: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 41 grid (ac1) volts ac 120 grid (ac1) volts ac 230 grid (ac1) volts ac 105 ...
Page 50: Menu System
Menu system page 42 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 high battery voltage no battery voltage was above the high battery cut o...
Page 51: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 43 the error led can be used to indicate when the generator frequency is we...
Page 52: Menu System
Menu system page 44 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 setup menu the setup menu provides all the controls and settings needed ...
Page 53: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 45 inverter setup (9) menu heading set grid usage flt sell slt lbx • flt - ...
Page 54: Menu System
Menu system page 46 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 set low battery cut out vdc 11.0 set low battery cut out vdc 22.0 set lo...
Page 55: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 47 battery charging (10) menu heading note: see the battery section of this...
Page 56: Menu System
Menu system page 48 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 set max charge amps ac 20 set max charge amps ac 30 set max charge amps ...
Page 57: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 49 gen auto start setup (12) menu heading set load start amps ac 33 all mod...
Page 58: Menu System
Menu system page 50 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 set exercise period days 30 all models range: 00 to 255 sets a maximum n...
Page 59: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 51 set pre crank seconds 10 all models range: 00 to 255 sets the number of ...
Page 60: Menu System
Menu system page 52 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 set relay 9 volts dc 14.5 set relay 9 volts dc 29.0 set relay 9 volts dc...
Page 61: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 53 bulk charge trigger timer (15) menu heading set start bulk time 00:00 al...
Page 62: Menu System
Menu system page 54 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery selling (17) menu heading note: see the battery section of this ...
Page 63: Menu System
Menu system 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 55 in either mode, the set start bulk time menu item setting under the bulk...
Page 64: Menu System
Menu system page 56 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 65: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 57 operation the sw series inverter/charger can be configured as a simple sta...
Page 66: Operation
Operation page 58 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 figure 18, trace™ sw series inverter output waveform the inverter is able ...
Page 67: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 59 power vs. Efficiency there are two primary losses that combine to create t...
Page 68: Operation
Operation page 60 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 inverter capacity vs temperature the current protection circuit in the sw ...
Page 69: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 61 operating modes the sw series inverter/charger can be used in a wide varie...
Page 70: Operation
Operation page 62 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 inverter mode in brief the inverter makes a stepped approximation to a sin...
Page 71: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 63 example a: if the search watts is set at 32 and a 30-watt incandescent lig...
Page 72: Operation
Operation page 64 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 charger mode in brief when ac power is available, the inverter can operate...
Page 73: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 65 battery temperature sensor (bts) figure 22, bts (battery temperature senso...
Page 74: Operation
Operation page 66 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 ac current level the maximum current draw into the ac hot in 1 terminal ca...
Page 75: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 67 once the battery voltage nears the bulk volts dc setting, the voltage will...
Page 76: Operation
Operation page 68 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 the battery manufacturer or supplier should be consulted before equalizing...
Page 77: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 69 inverter/charger mode in brief the sw series inverter/charger is capable o...
Page 78: Operation
Operation page 70 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 while connected to the utility, the battery charger will be engaged. Some ...
Page 79: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 71 generator support mode in brief the factory default settings are intended ...
Page 80: Operation
Operation page 72 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 generator support/overload protection this battery charger is quite powerf...
Page 81: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 73 automatic generator control mode in brief automatic start/stop control of ...
Page 82: Operation
Operation page 74 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 gen control relays caution: all circuits connecting the auto generator con...
Page 83: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 75 (3) time (exercise period days): the generator is automatically started at...
Page 84: Operation
Operation page 76 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 generator auto start requirements and types in order for the generator to ...
Page 85: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 77 three-wire start generators three-wire start generators do not include aut...
Page 86: Operation
Operation page 78 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 most diesel generators are controlled like the onan type, except that they...
Page 87: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 79 generator stop cool down period when the automatic generator stop system i...
Page 88: Operation
Operation page 80 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 equalization charging, automatic generator control system an automatic equ...
Page 89: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 81 utility backup mode in brief sw series inverter/chargers provide an excell...
Page 90: Operation
Operation page 82 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 utility support/overload protection this battery charger is very powerful ...
Page 91: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 83 utility interactive mode in brief in this mode, sw series inverter/charger...
Page 92: Operation
Operation page 84 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 theory of operation when sell mode is selected from the set grid usage men...
Page 93: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 85 selling power - from a dc charging source the simplest and default operati...
Page 94: Operation
Operation page 86 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 selling power - stored in the batteries power stored in the batteries can ...
Page 95: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 87 a system that includes 2400 watts of solar array is able to produce approx...
Page 96: Operation
Operation page 88 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 utility interactive operation with utility backup the sw series inverter/c...
Page 97: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 89 norm. Open rela solar array +p -n 120vac coil +p -n battery bank sw - seri...
Page 98: Operation
Operation page 90 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 energy management mode in brief the purpose of this mode is to manage how ...
Page 99: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 91 the system should be designed so that the battery is able to operate the l...
Page 100: Operation
Operation page 92 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 peak load shaving mode in brief the inverter can also be used to limit the...
Page 101: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 93 low battery transfer (lbx) mode low battery transfer mode is an alternativ...
Page 102: Operation
Operation page 94 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 once the system has transferred back to the battery, the battery voltage w...
Page 103: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 95 using multiple inverters multiple sw series inverter/chargers can be used ...
Page 104: Operation
Operation page 96 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 240 vac/60 hz only electrical systems two 120 vac / 60 hz inverters “serie...
Page 105: Operation
Operation 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 97 battery charging with multiple inverters the inverters can operate in para...
Page 106: Operation
Operation page 98 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 107: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 99 technical information battery type this section of the manual ...
Page 108: Technical Information
Technical information page 100 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 type 8d batteries are available with either cranking or deep ...
Page 109: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 101 battery sizing batteries are the inverter’s fuel tank. The la...
Page 110: Technical Information
Technical information page 102 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery bank sizing example complete the steps that follow to...
Page 111: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 103 worksheet complete the steps that follow to calculate your in...
Page 112: Technical Information
Technical information page 104 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery care and maintenance if you have read the battery cha...
Page 113: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 105 monthly maintenance at the minimum, check the level of the el...
Page 114: Technical Information
Technical information page 106 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery installation caution: batteries can produce extremely...
Page 115: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 107 battery hook-up configurations battery banks of substantial s...
Page 116: Technical Information
Technical information page 108 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 parallel connection batteries are connected in parallel when ...
Page 117: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 109 each individual 6-volt battery capacity = 100 amp hours note:...
Page 118: Technical Information
Technical information page 110 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 battery cable inductance when current passes through a conduc...
Page 119: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 111 applications resistive loads these are the loads that the inv...
Page 120: Technical Information
Technical information page 112 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 troubleshooting guide page 1 inverter - if error led comes on...
Page 121: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 113 troubleshooting guide page 2 battery charger - if error led c...
Page 122: Technical Information
Technical information page 114 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 troubleshooting guide page 3 error causes - error led is on o...
Page 123: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 115 inverter/charger terminology the following is a glossary of t...
Page 124: Technical Information
Technical information page 116 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 load(s) - any electrical item which draws power. (i . E., lig...
Page 125: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 117 stacking: series - two inverters operating together to produc...
Page 126: Technical Information
Technical information page 118 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 specifications and features (60 hz models) note: all specific...
Page 127: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 119 specifications and features (50 hz models) note: all specific...
Page 128: Technical Information
Technical information page 120 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 dimensions figure 37, sw series dimensions: with ac access co...
Page 129: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 121 installation diagrams the following diagrams and information ...
Page 130: Technical Information
Technical information page 122 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 figure 39, installation diagram, 240 vac, 3 wire, grid connec...
Page 131: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 123 user settings worksheets your sw series inverter/charger may ...
Page 132: Technical Information
Technical information page 124 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 setup menu – 12 vdc (120 vac/60hz) models to access the setup...
Page 133: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 125 setup menu – 24 vdc (120 vac/60hz) models to access the setup...
Page 134: Technical Information
Technical information page 126 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 setup menu – 48 vdc (120 vac/60hz) models to access the setup...
Page 135: Technical Information
Technical information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 127.
Page 136: Appendix
Appendix page 128 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 appendix options options available for the sw series inverter/charger incl...
Page 137: Appendix
Appendix 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 129 other products contact your xantrex dealer for details of any of the produ...
Page 138: Appendix
Appendix page 130 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 reference tables and graphs table 9, power consumption of common appliance...
Page 139: Appendix
Appendix 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 131 note: sizes shown are for the conductor – do not include any insulation wh...
Page 140: Appendix
Appendix page 132 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 table 13, recommended minimum ac wire sizes (75 ° c) inverter model full p...
Page 141: Appendix
Appendix 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 133 storage checklist if the sw series inverter/charger is used in a vehicular...
Page 142: Appendix
Appendix page 134 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001.
Page 143: Warranty/repair Information
Warranty/repair information 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 135 warranty/repair information limited warranty xantrex te...
Page 144: Warranty/repair Information
Warranty/repair information page 136 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 warranty or repair service required if your product nee...
Page 145: Index
Index 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 137 index a absorption time ........................................................
Page 146: Index
Index page 138 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 reset to factory defaults button ................... 10 control wiring .........
Page 147: Index
Index 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 139 cool down period.................................................... 75, 79 e...
Page 148: Index
Index page 140 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 menu ( 1) inverter mode .................................................... ...
Page 149: Index
Index 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 page 141 set generator, menu ( 2)...................................................37...
Page 150: Index
Index page 142 2001 xantrex technology, inc. 5916 - 195th street n. E. Arlington, wa 98223 telephone: 360/435-8826 fax: 360/435-2229 www.Traceengineering.Com sw series inverter/charger part no. 2031-5 rev. C: february 2001 user settings .............................................................. ...
Page 152
5916 - 195th street n.E., arlington, wa 98223 phone: (360) 435-8826 fax: (360) 435-2229 visit our website at: www.Traceengineering.Com.