Summary of 240 RS Cabin
Page 1
1.
Page 2
2 w w w. Xoboat s.Fi.
Page 3
3 xo boats preface congratulations on your new finnish xo boat! We want to thank you for choosing xo and we hope you enjoy the time you spend aboard. The purpose of this manual is to help you operate your boat with safety and pleasure. The manual contains the details of the boat and the associated o...
Page 4
4.
Page 5
5 1 before departure 9 2 general 11 3 warranty 12 4 before using your boat 12 4.1 registration 12 4.2 insurance 12 4.3 training 12 5 boat characteristics and operation 13 5.1 general 13 5.2 principal boat data 13 5.3 maximum recommended number of persons 13 5.4 load capacity 14 5.5 engine and propel...
Page 6
6.
Page 7
7 boat model: xo 240 rs cabin craft identification number – cin: engine make and model: engine serial number: 1st owner first name: last name: place of domicile: year of purchase: 2nd owner first name: last name: place of domicile: year of purchase: 3rd owner first name: last name: place of domicile...
Page 8
8.
Page 9
9 1 before departure read this user manual carefully. Before each departure, check at least the following: weather and weather forecast take the wind, waves and visibility into account. Is your boat's design category, size and equipment, as well as the skills of the helmsman and crew adequate for th...
Page 10
10
Page 11
11 2 general the purpose of this user manual is to help you familiarise yourself with the characteristics of your new boat. Separate manuals for the equipment installed on the boat are attached and also referred to in a number of sections of this manual. Naturally, you can complement this manual wit...
Page 12
12 3 warranty this boat and the equipment installed by the boatbuilder are covered by a warranty as specified in detail below. The engine, trim tabs, compass, any navigation devices and other ret- rofitted devices are subject to any warranty of their respec- tive manufacturers. Separate warranty car...
Page 13
13 5 boat characteristics and operation 5.1 general this user manual is not intended to be a comprehen- sive maintenance guide or repair manual. Instead, the pur- pose is to help you familiarise yourself with the characteris- tics of your new boat and show you how to use it properly. 5.2 principal b...
Page 14
14 5.4 load capacity the maximum recommended load for xo 240 rs cabin is 915 kg. An adult's weight is taken to be 75 kg and a child's 37.5 kg. The maxi- mum recommended total weight of the persons on board is 600 kg. In addition to the maximum recommended weight of persons men- tioned above, the boa...
Page 15
15 loading and seating (figure 1) bilge pumps and drainage (figure 2) seat alternative seat (5-person seat configuration) electric bilge pump manual bilge pump bilge pump intake and intake hose bilge pump discharge hose.
Page 16
16 of water remains in the bilge so that it cannot be discharged by the bilge pump. Xo 240 rs cabin is equipped with an automatic, elec- tric bilge pump. It discharges water accumulated in the bilge when the level sensor detects water. The automatic pump is always in the standby mode irrespective of...
Page 17
17 the boat, and do not keep any equipment containing fuel in a place that is not specifically designed for it. At least once a year, visu- ally check the condition of the hoses through the plexiglass screen. 5.7.2 fire-fighting and prevention whenever the xo 240 rs cabin is used, it must be equippe...
Page 18
18 • smoke or use a naked flame when handling fuel • keep fuel in a space that is not designed for such purpose. If the boat is not equipped with a heater, a spare fuel tank can be stored in place of the heater's tank. • leave the boat unattended when a cooker or heater is in use. 5.8 electrical sys...
Page 19
19 electrical equipment (figure 4) location of electrical equipment: battery compartment main switch bilge pump mast light, white, 360° navigation lights, red and green switch panel power outlet, 12 v, max. 10 a fuse panel (see figure 6) windscreen wiper.
Page 20
20 controls (figure 5) switch panel: bilge pump switch horn windscreen wiper, port windscreen wiper, starboard navigation light switch aux trimtab control, port trimtab control, starboard.
Page 21
21 fuse panel (figure 6) f1 navigation lights f2 trim tabs f3 horn f4 12 v power outlet f5 radio f6 automatic fire extinguisher f7 windscreen wiper, starboard f8 windscreen wiper, port f9 aux f10 bilge pump f11 extra f12 chart plotter f13 spare f13 spare.
Page 22
22 note! • when retrofitting optional equipment on the boat, use the ‘extra 1’ or ‘extra 2’ circuits. Connect the device to both the power supply and negative wire. Never earth the device to the hull. • if you leave the boat for a longer period, turn the main switch to the off position. Disconnect t...
Page 23
23 warning! Waves impair the boat's handling and can cause it to heel. Take this into account and reduce speed when waves become higher. Learn and obey the rules of navigation on waterways, and also familiarise yourself with the rules known as colregs (internatio- nal regulations for preventing coll...
Page 24
24 5.10 safe operation – other recommendations and information 5.10.1 protection from falling overboard and means of reboarding your boat's working decks are indicated in figure 6. Do not sit, stand or stay on any other section of the boat when moving. Before you get underway, make sure that the aft...
Page 25
25 working decks and bathing ladder (figure 6) bathing ladder working decks.
Page 26
26 5.10.4 anchoring, mooring and towing always moor your boat carefully, even in sheltered places, because conditions can change rapidly. The mooring lines should be equip- ped with appropriate absorbers to dampen shocks. For the location of fastening points, see figure 7. Do not use other boat comp...
Page 27
27 note! • the tensile strength of the lines or chains should normally not exceed the strength of the fastening point in question. • always attach the tow line so that it can be detached under load. • when towing another boat or being towed, always drive slowly. If the boat you are towing is of the ...
Page 28
28 5.10.5 trailering before lifting your xo boat onto the trailer, make sure that the trai- ler is suitable for your boat: there is a sufficient number of supports to distribute the weight properly without excessive point loads, and the capacity and dimensions of the trailer are sufficient to carry ...
Page 29
29 6 service, repairs and winter storage for information on your boat's maintenance, winter storage, service and repairs, please consult your local xo dealer. If you detect any major damage on the aluminium or surface finish, you should have it repaired by an authorised xo dealer. In case of a probl...
Page 30
30 7 optional equipment 7.1 general note! If not carried out properly, many installation and modification ope- rations can damage the boat structure or create a safety hazard. Please contact the manufacturer before you or somebody else does any of the following: construct new earthing points or hat-...
Page 31
31.
Page 32
32 the boat is marked with a running serial number known as the cin (craft identification number). The cin is marked on the hull, on the starbo- ard side of the stern, on the outer surface of the transom beside the edge strip. You can record the cin of your boat in the table below. When contacting t...
Page 33
33 control cables hydraulic steering hoses: 4.50 m (15 ft) engine control cables: 4.50 m (15 ft) additional load components basic equipment: 25 kg contents of the fixed tanks: 175 kg/195 kg (i/o version) liferaft: 40 kg other load or equipment: 75 kg due to reasons associated with the production tec...
Page 34
34 1 appendix 2 xo 240 rs cabin – general layout the general layout diagrams of the boat are not to scale. Due to con- stant development of our boats, the information is subject to change without prior notice. Mast light; white, 360°, 10 w a) battery compartment, b) fuse panel, and c) main switch na...
Page 35
35 principal data; en iso 8666:2002 2.1 craft identification; iso 10087:1996 / a1:2000 2.2 builder's plate; rcd, annex i, 2.2 2.5 owner's manual; en iso 10240:2004 layout and equipment 2.3 man-overboard prevention; en iso 15085:2003 3.7 liferaft stowage; rsg guidelines 3.8 escape; - 3.9 anchoring an...
Page 36
36 appendix 4 wiring diagram project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 5 24 xo 1.6.2010 rn 8 f 1 diagram 1 2 ...
Page 37
37 a3 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 5 24 xo 31.5.2010 rn 8 f 2 diagram 1 2 f.1 10a nav./anch. Lt...
Page 38
38 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 5 24 xo 31.5.2010 rn 8 f 3 diagram 1 2 f.7 7a wiper stb 1 2 1 2 ...
Page 39
39 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 5 24 xo 31.5.2010 rn 8 f 4 diagram 1 2 f.12 10a plotter 1 2 1 2 ...
Page 40
40 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 5 24 xo d2: a new panel f2: not modified rn rn 2.6.2010 rn 2 f 17...
Page 41
41 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo e5: h30 added, h5 relocated, x8 removed c3: aux/cab_l...
Page 42
42 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo b2: x.9 bundle extended, m2 & h3 butted splice added ...
Page 43
43 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo b2: butted splices added rn 2.6.2010 rn 2 e 26.11.2010 9...
Page 44
44 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo b2: battery terminals added d3: battery terminals type: ...
Page 45
45 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo 2.6.2010 rn 1 e 11 10086 battery cables io 10 input+ m_...
Page 46
46 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo 2.6.2010 rn 1 e 12 10087 battery cables ob 10 input+ b2...
Page 47
47 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo b2: comp. L. Wire removed d3: spare > fire ext., a new ...
Page 48
48 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo d2: switch type changed rn 8.2.2011 rn 2 e 12.5.2011 15 ...
Page 49
49 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo d2: switch type changed rn 17.3.2011 rn 2 e 12.5.2011 6 ...
Page 50
50 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo d2: battery terminals type: bolt > angle e3: several ca...
Page 51
51 project rev. Sheet rev. Drawing by date modified by description a b c d e f 1 2 3 4 5 6 7 8 date of modification sheet loc hl / project id boat boat model product code copyright by subproduct code title 1 2 3 4 5 6 7 8 a b c d e f 16 24 xo 29.8.2011 rn 1 e 16 12037 roof harness 1 aux/cab_l_out ...
Page 52
52 xo boats oy www.Xoboats.Fi info@xoboats.Fi rantalinna, rantakatu fi-65100 vaasa finland.
Page 53
53.