Summary of HK125RW
Page 1
Operation manual hk125rw hk300rw kerosene forced air heater.
Page 2
2.
Page 3: Safety
3 safety 6 safety rules 7 safety warnings specifications 12 specifications 13 wiring diagram pre-operation 14 general instructions assembly 15 assembling axle and wheels operation 16 fueling the heater 16 kerosene (1-k) 17 staring the heater 17 venting 19 reset after lockout-safety air pressure swit...
Page 4
4 using the operator’s manual the operating manual is an important part of your heater and should be read thoroughly before initial use, and referred to often to make sure adequate safety and service concerns are being addressed. Reading the owner’s manual thoroughly will help avoid any personal inj...
Page 5
5 product identification record identification numbers heater if you need to contact an authorized dealer or customer service line (1- 866-770-1711) for information on servicing, always provide the product model and identification numbers. You will need to locate the model and serial number for the ...
Page 6
6 safety the safety alert symbol ( ) is used with a signal word (danger, caution, warning), a pictorial and/or a safety message to alert you to hazards. Danger indicates a hazard which, if not avoided, will result in death or serious injury. Warning indicates a hazard which, if not avoided, could re...
Page 7: Warning
7 safety warning serious injury or death could occur if the portable heater is not properly grounded. Your heater is powered by electricity and may cause electric shock or electrocution if not used properly. Electrical shock may occur if the heater is not operated properly. Serious injury or death m...
Page 8: Warning
8 safety warning serious injury or death may occur from normal electrical sparks in motor and pressure switch. Serious injury may occur if the heater air inlet or outlet is blocked. Serious injury or death may occur if improper fuels are used, if heater is running while refilling. Serious injury may...
Page 9: Warning
9 safety warning serious injury or death could occur from failure to provide proper ventilation according to this manual. • this is a kerosene, indirect-fired, forced air heater. It is primarily intended for use for temporary heating of buildings under construction,alteration or repair. • early sign...
Page 10: Warning
10 safety warning • fire, burn, inhalation, and explosion hazard. Keep combustibles, such as building materials, paper or cardboard, a safe distance away from the heater as recommended by these instructions. Never use the heater in spaces which contain products such as gasoline, solvents, paint thin...
Page 11: Warning
11 safety warning • massachusetts residents: massachusetts state law prohibits the use of this heater in any building which is used in whole or in part for human habitation. Use of this heating device in massachusetts requires local fire department permit (m.G.L.C.148, section 10a). Warning • califo...
Page 12: Specifications
12 specifications specifications specifications model hk125rw hk300rw rating btu/hr 125,200 288,700 fuel consumption gal/hr 0.833 2.04 fuel tank capacity gallons 14.0 36.0 pump pressure psi 175 175 volt/hz 115v/60hz 115v/60hz amps 7.0 12.5 phase single single size (l x w x h) 47” x 24” x 31” 68” x 2...
Page 13
13 wiring diagram specifications kerosene portable heaters manual 9 portable heater specifications wiring diagram model mh-0125-0mih mh-0300-0mih rating btu/hr 125,200 288,700 fuel consumption gal/hr 0.883 2.04 fuel tank capac- ity gallons 14.0 36.0 pump pressure psi 175 175 volt/hz 115v / 60 hz 115...
Page 14: Pre-Operation
14 pre-operation • floors and ceilings must be made of fireproof materials in the place where the heater is operated. • the air inlet and outlet must never be blocked for any reason. • install the heater on a flat, level floor in a steady position. Pre-operation general instructions 1. The installat...
Page 15: Assembly
15 assembly assembly assembling axle and wheels before operating the heater, assemble axle, wheels and lower support following the diagram below: kerosene portable heaters manual 11 assembling axle and wheels • before operating the heater, assemble axle, wheels and lower support following the diagra...
Page 16: Caution
16 operation caution • never fill the fuel tank indoors. Always fill the tank outdoors. • be sure that the heater is on level ground when fueling, and never overfill the fuel tank. Warning • never leave heater unattended while burning or while connected to a fuel source. Operation fueling the heater...
Page 17: Warning
17 operation venting staring the heater risk of indoor air pollution. Use heater only in well ventilated areas. Always provide a fresh air opening in the heated space of at least three square feet (2,800 sq. Cm) for each 100,000 btu/hr. Of heater output. Provide a larger opening if more heaters are ...
Page 18: Operation
18 operation kerosene portable heaters manual 13 operation venting connect the heater to a flue pipe or to a exhaust duct. To get a proper draft (at least 0,1 mbar) in the flue pipe, the exhaust gas path must rise. Avoid any elbows and bends in the first part of the flue pipe for at least 10 ft. For...
Page 19: Warning
19 operation the heater is equipped with a reset push button. When the heater locks out, the red lamp on the push button (number 2 below) lights up. In this case push the reset button (see troubleshooting) to restart the heater. The heater is also equipped with an air pressure switch that controls t...
Page 20: Maintenance
20 maintenance maintenance use only original equipment replacement parts. The use of alternate or third party components can cause unsafe operating conditions, and will void your warranty. 1. Before carrying out any maintenance operation, disconnect the power cord. 2. Maintenance must be carried out...
Page 21: Troubleshooting
21 troubleshooting problem possible case solution heater does not start no power check main distribution board and power supply line faulty cable/connections check/have cable replaced by a qualified electrician burnt fuse check and replace if required room thermostat set too low set room thermostat ...
Page 22
22 if you need assistance with the assembly or operation of this heater please call 1-866-770-1711.