- DL manuals
- Yamaha
- Boat
- FX High Output WaveRunner 2008
- Owner's/operator's Manual
Yamaha FX High Output WaveRunner 2008 Owner's/operator's Manual
Summary of FX High Output WaveRunner 2008
Page 1
2008 waverunner fx high output fx cruiser high output owner’s/operator’s manual read this manual carefully before operation! F1x-f8199-12 u.S.A. Edition lit-18626-07-50
Page 2
Uf1x12e0.Book page 1 thursday, june 14, 2007 10:24 am.
Page 3: To The Owner/operator
Important manual information eju30180 to the owner/operator thank you for choosing a yamaha watercraft. This owner’s/operator’s manual contains in- formation you will need for proper operation, maintenance, and care. A thorough under- standing of these simple instructions will help you to obtain max...
Page 4: Table Of Contents
Table of contents general and important labels........... 1 identification numbers .................... 1 primary identification (pri-id) number ........................................... 1 hull identification number (hin) ........ 1 engine serial number ........................ 1 emission control ...
Page 5: Table Of Contents
Table of contents reverse on waterways .................... 76 rough water operation .................... 77 post-operation care ...................... 77 transporting ................................. 78 maintenance and care..................... 79 storage ......................................... ...
Page 6: Identification Numbers
General and important labels 1 eju30260 identification numbers record the primary identification (pri-id) number, hull identification number (hin), and engine serial number in the spaces provided for assistance when ordering spare parts from a yamaha dealer. Also record and keep these id numbers in ...
Page 7: Emission Control Information
General and important labels 2 eju30340 emission control information this engine conforms to 2008 u.S. Environ- mental protection agency (epa) regulations for marine si engines. Eju30390 approval label of emission control certificate this label is attached to the top of the cylinder head and to the ...
Page 8: Important Labels
General and important labels 3 eju30450 important labels uf1x12e0.Book page 3 thursday, june 14, 2007 10:24 am.
Page 9
General and important labels 4 eju35910 warning labels uf1x12e0.Book page 4 thursday, june 14, 2007 10:24 am.
Page 10
General and important labels 5 uf1x12e0.Book page 5 thursday, june 14, 2007 10:24 am.
Page 11
General and important labels 6 eju35923 other labels uf1x12e0.Book page 6 thursday, june 14, 2007 10:24 am.
Page 12
General and important labels 7 the following label indicates the correct direction to upright a capsized watercraft. Uf1x12e0.Book page 7 thursday, june 14, 2007 10:24 am.
Page 13: Safety Information
Safety information 8 eju30670 the safe use and operation of this water- craft is dependent upon the use of proper riding techniques, as well as upon the common sense, good judgment, and ex- pertise of the operator. Every operator should know the following requirements before riding the watercraft. ●...
Page 14: Safety Information
Safety information 9 teristics of the watercraft before trying any difficult maneuvers. Eju30760 cruising limitations ● scan constantly for people, objects, and other watercraft. Be alert for conditions that limit your visibility or block your vision of others. ● operate defensively at safe speeds a...
Page 15: Safety Information
Safety information 10 kles, and other bones. Do not jump wakes or waves. ● do not operate the watercraft in rough wa- ter, bad weather, or when visibility is poor; this may lead to an accident causing injury or death. Be alert to the possibility of ad- verse weather. Take note of weather fore- casts...
Page 16: Safety Information
Safety information 11 eju30811 operation requirements ● all riders must wear a u.S. Coast guard (uscg) approved personal flotation device (pfd) that is suitable for personal water- craft use. ● wear protective clothing. Severe internal injuries can occur if water is forced into body cavities as a re...
Page 17: Safety Information
Safety information 12 ● never operate the watercraft after con- suming alcohol or taking other drugs. ● for reasons of safety and proper care of the watercraft, always perform the pre-opera- tion checks listed on page 55 before operat- ing the watercraft. ● the operator and passengers should al- way...
Page 18: Safety Information
Safety information 13 ● according to the uscg, boats under 6.1 m (20 ft) in length like your watercraft must carry a fire extinguisher of a b-1 classifica- tion, with a capacity of two pounds or more when navigating in waters under uscg ju- risdiction. In addition, most state and local boating laws ...
Page 19: Safety Information
Safety information 14 eju30870 hazard information ● never start the engine or let it run for any length of time in an enclosed area. Exhaust fumes contain carbon monoxide, a color- less, odorless gas that may cause loss of consciousness and death within a short time. Always operate the watercraft in...
Page 20: Safety Information
Safety information 15 ● reverse can be used to slow down or stop during slow-speed maneuvering, such as when docking. Once the engine is idling, shift into reverse and gradually increase en- gine speed. Make sure that there are no ob- stacles or people behind you before shifting into reverse. ● keep...
Page 21: Safety Information
Safety information 16 eju30940 water-skiing you can use the watercraft for water-skiing if it has the seating capacity to carry the opera- tor, a rearward-facing spotter, and the water- skier when he or she is not skiing. The watercraft must also have a cleat de- signed to pull a ski rope; do not at...
Page 22: Safety Information
Safety information 17 watch the skier’s hand signals and condi- tion. Fx high output fx cruiser high output ● your control while pulling a water-skier is affected by the skier’s ability, as well as wa- ter and weather conditions. ● when preparing to pull a skier, operate the watercraft at the slowes...
Page 23: Safety Information
Safety information 18 eju30960 rules of the road your yamaha watercraft is legally consid- ered a powerboat. Operation of the water- craft must be in accordance with the rules and regulations governing the waterway on which it is used. Just as there are rules that apply when you are driving on stree...
Page 24: Safety Information
Safety information 19 give-way vessels). Both you and the meeting vessel must alter course to avoid each other. Meeting if you are meeting another power-driven ves- sel head on, and are close enough to run the risk of collision, neither of you has the right-of- way! Both of you should alter course t...
Page 25: Safety Information
Safety information 20 fishing vessel right-of-way all vessels fishing with nets, lines, or trawls are considered to be “fishing vessels” under the international rules. Vessels with trolling lines are not considered fishing vessels. Fish- ing vessels have the right-of-way regardless of position. Fish...
Page 26: Safety Information
Safety information 21 they signify speed zones, restricted areas, danger areas, and general information. Remember, markings may vary by geograph- ic location. Always consult local boating au- thorities before riding your watercraft in unfamiliar waters. Uf1x12e0.Book page 21 thursday, june 14, 2007 ...
Page 27: Safety Information
Safety information 22 eju30980 to get more boating safety information be informed about boating safety. Additional publications and information can be obtained from many organizations, including the follow- ing. United states coast guard consumer affairs staff (g-bc) office of boating, public, and c...
Page 28: Safety Information
Safety information 23 eju30990 enjoy your watercraft responsibly you share the areas you enjoy when riding your watercraft with others and with nature. So your enjoyment includes a responsibility to treat these other people, and the lands, wa- ters, and wildlife with respect and courtesy. Whenever a...
Page 29: Features And Functions
Features and functions 24 eju31010 location of main components front view 1 handlebars 2 rear seat 3 front seat 4 footwell 5 sponsons 6 gunwale 7 pull-up cleat (for fx cruiser high output) 8 cooling water pilot outlet 9 bow eye 10 hood uf1x12e0.Book page 24 thursday, june 14, 2007 10:24 am.
Page 30: Features And Functions
Features and functions 25 rear view 1 fuel tank filler cap 2 intake grate 3 speed sensor 4 stern eyes 5 stern drain plugs 6 reverse gate 7 ride plate 8 jet thrust nozzle 9 reboarding step 10 electric bilge pilot outlet 11 cleat 12 handgrip uf1x12e0.Book page 25 thursday, june 14, 2007 10:24 am.
Page 31: Features And Functions
Features and functions 26 control system 1 multifunction information center 2 beverage holder 3 rearview mirrors 4 throttle lever 5 shift lever 6 tilt lever 7 glove compartment 8 engine stop switch 9 engine shut-off cord (lanyard) 10 quick shift trim system (qsts) selector 11 qsts selector lock leve...
Page 32: Features And Functions
Features and functions 27 engine compartment 1 air filter case 2 water separator 3 fuel tank 4 battery 5 flushing hose connector 6 electrical box 7 oil tank 8 muffler 9 spark plugs/spark plug caps/ignition coils 10 spark plug lead uf1x12e0.Book page 27 thursday, june 14, 2007 10:24 am.
Page 33: Features And Functions
Features and functions 28 eju31020 operation of controls and other functions eju31040 seats to remove the rear seat: pull the rear seat latch up, and then pull the seat off. Fx high output fx cruiser high output to install the rear seat: insert the projections on the front of the seat into the stays...
Page 34: Features And Functions
Features and functions 29 to install the front seat: (1) insert the projections on the front of the seat into the stays on the deck, and then push the rear of the seat down to lock it in place. (2) install the rear seat. Note: make sure that the seats are securely in- stalled before operating the wa...
Page 35: Features And Functions
Features and functions 30 eju31090 fuel tank filler cap to remove the fuel tank filler cap, turn it coun- terclockwise. Note: make sure that the fuel tank filler cap is se- curely closed before operating the watercraft. Eju34842 remote control transmitter the yamaha security system and low-rpm mode ...
Page 36: Features And Functions
Features and functions 31 note: ● while the engine is running, input from the remote control transmitter is not received. ● refer to local hazardous waste regulations when disposing of transmitter batteries. This device complies with part 15 of the fcc rules. Operation is subject to the following tw...
Page 37: Features And Functions
Features and functions 32 eju36280 start switch push the start switch (green button) to start the engine. Note: the engine will not start when the lock mode of the yamaha security system has been se- lected, the clip is removed from the engine shut-off switch, or the throttle lever is squeezed. (see...
Page 38: Features And Functions
Features and functions 33 eju31260 steering system your watercraft can be steered by turning the handlebars in the direction you wish to travel. When the handlebars are turned, the angle of the jet thrust nozzle is changed, and the direc- tion of the watercraft is changed accordingly. Since the stre...
Page 39: Features And Functions
Features and functions 34 otherwise the handlebars may suddenly change position, which may lead to an accident. Eju31300 shift lever the shift lever is located on the starboard (right) side of the watercraft and is used to control the reverse gate, which allows the wa- tercraft to move in reverse or...
Page 40: Features And Functions
Features and functions 35 there are 5 positions: 2 bow-down positions (a) and (b), neutral “n”, and 2 bow-up posi- tions (c) and (d). To change the trim angle: (1) reduce engine speed to less than 4000 r/min. (2) squeeze the qsts selector lock lever, and then turn the qsts selector to the desired po...
Page 41: Features And Functions
Features and functions 36 ahead acceleration when on plane and top speed are enhanced. In some conditions, however, the watercraft may tend to “porpoise” (hop in the water). If the watercraft is porpoising, select neutral or bow down. Eju31360 handgrip the handgrip provides a handhold for board- ing...
Page 42: Features And Functions
Features and functions 37 the bow eye is used to attach a rope to the watercraft when transporting, mooring, or towing it in an emergency. Eju34880 stern eyes the stern eyes are located at the stern of the watercraft. The stern eyes are used to attach a rope to the watercraft when transporting or mo...
Page 43: Features And Functions
Features and functions 38 remote control transmitter or it does not oper- ate properly, contact a yamaha dealer. Eju31390 yamaha security system the yamaha security system functions to help prevent unauthorized use or theft of the watercraft. The engine cannot be started if the security system is in...
Page 44: Features And Functions
Features and functions 39 eju36221 selecting the normal mode/low-rpm mode the normal mode and low-rpm mode can only be selected when the engine is stopped in the unlock mode. Press the unlock button on the remote control transmitter for more than 4 seconds to switch between the normal mode and the l...
Page 45: Features And Functions
Features and functions 40 note: ● when the multifunction information center starts operating, the analog speedome- ter/tachometer makes one sweep, all dis- plays light up for 2 seconds, and then the meter starts to operate normally. ● the multifunction information center will continue to operate for...
Page 46: Features And Functions
Features and functions 41 eju34951 “speed” indicator light the “speed” indicator light comes on when the analog speedometer is selected. The “speed” indicator light blinks three times in the following instances: ● the analog speedometer/tachometer is switched to the speedometer function. ● the displ...
Page 47: Features And Functions
Features and functions 42 eju35010 “l-mode” indicator light the “l-mode” indicator light comes on when the low-rpm mode is selected. (see page 39 for more information.) eju35021 left multifunction display and operation buttons the left multifunction display is equipped with the following functions. ...
Page 48: Features And Functions
Features and functions 43 center starts operating, or if the display units are switched to miles. Eju31511 fuel level meter the fuel level meter is provided for convenient fuel level checking while riding. The fuel level meter has eight segments which show the amount of fuel remaining in the fuel ta...
Page 49: Features And Functions
Features and functions 44 the meter shows the hours of engine opera- tion that have elapsed since the watercraft was new. Voltmeter the voltmeter is provided to display the volt- age of the battery. When the battery voltage is normal, the volt- meter displays approximately 12 volts. If the battery v...
Page 50: Features And Functions
Features and functions 45 sounds, the engine speed is limited to help prevent damage. If this occurs, immediately reduce the engine speed, return to shore, and then check for wa- ter discharge at the port (left) cooling water pi- lot outlet while the engine is running. If there is no discharge of wa...
Page 51: Features And Functions
Features and functions 46 check engine warning indicator begin to blink, and the buzzer sounds intermittently. If this occurs, reduce the engine speed, return to shore, and have a yamaha dealer check the engine. Note: press any button on the multifunction informa- tion center to stop the buzzer. Eju...
Page 52: Features And Functions
Features and functions 47 ating, or if the display units are switched to miles/gallons/degrees fahrenheit. Compass this display shows the current direction of the watercraft using the 8 major compass points. Note: the accuracy of the compass varies depend- ing on the operating conditions. Use this f...
Page 53: Features And Functions
Features and functions 48 fuel consumption per hour this display shows the current fuel consump- tion in gallons per hour “g/hr” or liters per hour “l/hr”. Fuel consumption per kilometer/mile this display shows the current fuel consump- tion in gallons per mile “g/mile” or liters per kilometer “l/km...
Page 54: Features And Functions
Features and functions 49 surements are stopped. The beeper sounds twice. Note: ● the displays can be reset only when the measurements are stopped. ● the measurements are not saved if the en- gine is stopped. The displays are reset au- tomatically when they go off 25 seconds after the engine stops. ...
Page 55: Features And Functions
Features and functions 50 to close the front storage compartment, push down on the rear of the hood until it latches securely. Note: make sure that the front storage compartment is securely closed before operating the water- craft. Eju35161 glove compartment the glove compartment is located in front...
Page 56: Features And Functions
Features and functions 51 to open the seat storage compartment, re- move the rear seat. (see page 28 for rear seat removal and installation procedures.) eju35170 beverage holder the beverage holder is located on the star- board (right) side of the watercraft. Note: do not place beverages in the beve...
Page 57: Features And Functions
Features and functions 52 note: make sure that the watertight compartment cap is closed securely before operating the watercraft. Uf1x12e0.Book page 52 thursday, june 14, 2007 10:24 am.
Page 58: Operation
Operation 53 eju31820 fuel and oil this watercraft is equipped with a 4-stroke en- gine. Conventional 2-stroke engine oil cannot be used. The engine utilizes an electronic fuel injection system to deliver the optimal air-fuel ratio re- quired by the engine. By ensuring the optimal combustion conditi...
Page 59: Operation
Operation 54 eju31890 engine oil use a combination of the recommended sae and api engine oil classifications shown in the chart below. Caution: ecj00280 use only 4-stroke engine oil. Eju31951 filling the fuel tank caution: ecj00290 be careful when refueling. Avoid getting water and other contaminant...
Page 60: Operation
Operation 55 eju31980 pre-operation checks eju31990 pre-operation check list before operating this watercraft, perform the checks in the following check list. See the accom- panying text in this chapter for details on how to perform the checks. Warning ewj00410 if any item in the pre-operation check...
Page 61: Operation
Operation 56 note: pre-operation checks should be made each time the watercraft is used. These checks can be completed in a short time. It is worth the time spent to ensure safety and reliability. Uf1x12e0.Book page 56 thursday, june 14, 2007 10:24 am.
Page 62: Operation
Operation 57 eju32280 pre-operation check points eju32330 engine compartment ventilate the engine compartment before each use. To ventilate the engine compartment, remove the seats. (see page 28 for seat removal and installation procedures.) leave the engine compartment open for a few minutes to all...
Page 63: Operation
Operation 58 note: if the ambient temperature is 20 °c (68 °f) or less, warm up the engine for an additional 5 minutes. (3) remove the seats. (see page 28 for seat removal and installation procedures.) (4) remove the oil tank filler cap, wipe the dipstick clean, and then screw the filler cap into th...
Page 64: Operation
Operation 59 the water is discharged from the electric bilge pilot outlet at the stern. A small quantity of water will remain in the bilge and should be drained manually. To drain any residual water, beach the watercraft and perform the following procedure. Caution: ecj00350 if starting the engine a...
Page 65: Operation
Operation 60 also, check that the battery leads are tight- ened securely and that there is no corrosion on the battery terminals. Check that the breather hose is securely connected to the battery and that it is not pinched. Warning ewj00450 ● the battery must always be fully charged and in good cond...
Page 66: Operation
Operation 61 contact a yamaha dealer or a fire extin- guisher dealer to obtain one meeting the proper specifications. Eju32590 throttle lever check the throttle lever for proper operation. Squeeze and release the throttle lever several times to make sure that there is no hesitation in its travel. It...
Page 67: Operation
Operation 62 also, make sure that the reverse gate goes up completely when the shift lever is pushed down. Warning ewj00030 ● make sure that the throttle lever is com- pletely released and that the engine is at idle before shifting into reverse. ● do not use the reverse function to slow down or stop...
Page 68: Operation
Operation 63 shifted from neutral to bow up or bow down. If the mechanism does not work properly, have a yamaha dealer service it. Eju32650 jet intake carefully check the jet intake for weeds, de- bris, or anything else that might restrict the in- take of water. If the jet intake is clogged, cavitat...
Page 69: Operation
Operation 64 eju32670 switches caution: ecj00410 do not run the engine for more than 15 seconds when checking the switches on land without supplying water, otherwise the engine could overheat. Check the start switch, the engine stop switch, and the engine shut-off switch for proper operation. Push t...
Page 70: Operation
Operation 65 eju32740 operation warning ewj00510 before operating your watercraft, become familiar with all of the controls. Consult a yamaha dealer about any control or func- tion that you do not fully understand. Fail- ure to understand how the controls work could cause an accident or prevent you ...
Page 71: Operation
Operation 66 (1) if the lock mode of the yamaha security system is selected, use the remote con- trol transmitter to select the unlock mode. (see page 38 for yamaha security sys- tem lock and unlock mode selection pro- cedures.) (2) launch the watercraft in water free from weeds and debris and at le...
Page 72: Operation
Operation 67 (4) push the start switch (green button), and then release it as soon as the engine starts to run. Note: the engine will not start if the throttle lever is squeezed. Caution: ecj00480 ● never push the start switch while the en- gine is running. ● do not operate the start switch for more...
Page 73: Operation
Operation 68 eju32900 operating your watercraft eju32951 getting to know your watercraft operating your watercraft requires skills ac- quired through practice over a period of time. Take the time to learn the basic techniques well before attempting more difficult maneu- vers. Operating your new wate...
Page 74: Operation
Operation 69 fabrics, like those used in bicycle shorts. A full wetsuit can also protect against hypothermia (subnormal body temperature) and abra- sions. Footwear and gloves are recommended. Eye protection is recommended to keep wind, water, and glare from the sun out of your eyes while you operate...
Page 75: Operation
Operation 70 ● practice reboarding in shallow water be- fore riding in deep water. Eju33091 boarding and starting in shallow water (1) launch the watercraft in water free from weeds and debris and at least 60 cm (2 ft) deep. Warning ewj00570 never operate in water that is less than 60 cm (2 ft) deep...
Page 76: Operation
Operation 71 eju36350 boarding alone (1) swim to the rear of the watercraft and place both hands on the boarding plat- form, pull yourself up, and then grasp the handgrip with one hand. (2) pull yourself up to a kneeling position on the platform, and then move to the seat and sit astride. (3) attach...
Page 77: Operation
Operation 72 (1) climb on board as noted in the previous section, and sit astride the seat. (2) attach the engine shut-off cord to your left wrist, and then attach the clip to the en- gine shut-off switch. (3) have the passengers move to the rear of the watercraft. (4) have a passenger board and sit...
Page 78: Operation
Operation 73 tion, and then move to the seat and sit astride to balance the watercraft. (2) have a passenger pull him or herself up onto the boarding platform into a kneeling position, then move to the seat and sit astride to balance the watercraft. (3) attach the engine shut-off cord to your left w...
Page 79: Operation
Operation 74 ride plate while pushing down on the gun- wale with your right hand or foot. Note: if the port (left) side of the capsized watercraft is tilting up, push down on the gunwale so that the port (left) side is down before turning the watercraft clockwise. Caution: ecj00540 do not turn the w...
Page 80: Operation
Operation 75 b. Less throttle produces lower thrust, so the watercraft will turn more gradually. C. Releasing the throttle lever completely produces only minimum thrust. If you are traveling at speeds above trolling, you will have rapidly decreasing ability to steer without throttle. You may still h...
Page 81: Operation
Operation 76 put until you apply throttle again or you reach trolling speed. Eju33290 stopping the watercraft the watercraft is not equipped with a sepa- rate braking system. It is stopped by water re- sistance when the throttle lever is released. From full speed, the watercraft comes to a complete ...
Page 82: Operation
Operation 77 once the engine is idling, shift into reverse and gradually increase engine speed. Make sure that there are no obstacles or people be- hind you before shifting into reverse. Eju33350 rough water operation the force of landing after jumping can cause a strong impact on both the watercraf...
Page 83: Operation
Operation 78 (5) flush the cooling system to prevent it from clogging with salt, sand, or dirt. (see page 79 for flushing procedures.) (6) drain residual water from the exhaust system by alternately squeezing and re- leasing the throttle lever for 10 to 15 sec- onds while the engine is running. Caut...
Page 84: Maintenance And Care
Maintenance and care 79 eju33490 storage warning ewj00330 always place the watercraft upright in a horizontal position when storing it, other- wise fuel could leak out into the engine or engine compartment, which could create a fire hazard. Storage for long periods of time, such as win- ter storage,...
Page 85: Maintenance And Care
Maintenance and care 80 water passages by alternately squeezing and releasing the throttle lever for 10 to 15 seconds. (8) stop the engine. (9) remove the garden hose adapter and in- stall the flushing hose connector cap. Eju33592 lubrication warning ewj00260 do not spray flammable rust inhibitor pr...
Page 86: Maintenance And Care
Maintenance and care 81 leave it in direct sunlight. Leave it in a well-ventilated area with the watercraft in a horizontal position. ● tighten the fuel tank filler cap securely after refueling. ● if you should swallow some gasoline, in- hale a lot of gasoline vapor, or get gaso- line in your eyes, ...
Page 87: Maintenance And Care
Maintenance and care 82 eju33751 maintenance and adjustments periodic inspection, adjustment, and lubrica- tion will keep your watercraft in the safest and most efficient condition possible. Safety is an obligation of the watercraft owner. Proper maintenance must be carried out to keep the exhaust e...
Page 88: Maintenance And Care
Maintenance and care 83 pairs. The tools provided in the tool kit are suf- ficient for this purpose, except that a torque wrench may also be necessary to tighten nuts and bolts. 1 tool bag 2 screwdriver 3 16 mm box wrench 4 10/12 mm box wrench 5 pliers 6 open-end wrench 7 garden hose adapter uf1x12e...
Page 89: Maintenance And Care
Maintenance and care 84 eju33821 periodic maintenance chart the following chart gives general guidelines for periodic maintenance. However, maintenance may need to be performed more frequently depending on your operating conditions. This “ ” mark indicates maintenance that you may do yourself. This ...
Page 90: Maintenance And Care
Maintenance and care 85 * this operation should be performed after every use. Engine mount check — nuts and bolts check — air filter element check 87 engine oil replace 86 oil filter replace 86 valve clearance check, adjust — item operation initial thereafter every page 10 hours 50 hours 100 hours 1...
Page 91: Maintenance And Care
Maintenance and care 86 eju34210 checking the fuel system warning ewj00380 gasoline is highly flammable and explo- sive. Failure to check for and repair any fuel leakage could result in a fire or explo- sion. A fire or explosion can cause severe injury or death. Shut the engine off. Do not smoke. Av...
Page 92: Maintenance And Care
Maintenance and care 87 caution: ecj00190 if oil is leaking or the oil pressure warning indicator comes on when the engine is running, immediately shut the engine off and have a yamaha dealer check the wa- tercraft. Continuing to operate the engine under such conditions could cause severe engine dam...
Page 93: Maintenance And Care
Maintenance and care 88 eju34321 checking the jet thrust nozzle angle check the handlebars and jet thrust nozzle for smooth operation. Turn the handlebars as far as possible to the right and left and check that the difference of distances a and b between the jet thrust noz- zle and the nozzle is wit...
Page 94: Maintenance And Care
Maintenance and care 89 (2) slide the rubber cover away from the ad- juster, and then loosen the locknut. (3) adjust the free play by turning the adjust- er. (4) hold the adjuster with one wrench while tightening the locknut with another wrench. Slide the rubber cover to its orig- inal position. (5)...
Page 95: Maintenance And Care
Maintenance and care 90 (5) install the front and rear handlebar cov- ers as shown in the illustration, and then install the ten screws. Eju34381 cleaning and adjusting the spark plugs the spark plug is an important engine compo- nent and is easy to inspect. The condition of the spark plug can indic...
Page 96: Maintenance And Care
Maintenance and care 91 (3) install the spark plug, and then tighten it to the specified torque. (4) install the spark plug cap. Note: ● wipe off any water on the spark plug or in- side the spark plug cap before installing the cap. Push the spark plug cap down until it is securely installed. ● if a ...
Page 97: Maintenance And Care
Maintenance and care 92 ● steering cable (jet thrust nozzle end) ● qsts rod (jet thrust nozzle end) ● shift cable (shift lever end) ● shift cable (reverse gate end) ● intermediate housing fill the intermediate housing with water-re- sistant grease through the grease nipple using a grease gun. Eju344...
Page 98: Maintenance And Care
Maintenance and care 93 tilated. Always shield your eyes when working near batteries. Keep out of the reach of children. Caution: ecj00230 ● be careful not to place the battery on its side. ● be sure to remove the battery from the battery compartment when adding elec- trolyte or charging the battery...
Page 99: Maintenance And Care
Maintenance and care 94 eju34490 fuel injection system the fuel injection system was set at the yamaha factory. If the fuel injection system needs to be adjusted, have a yamaha dealer service the watercraft. Caution: ecj00220 do not attempt to adjust the fuel injection system. If the settings are di...
Page 100: Specifications
Specifications 95 eju34542 specifications watercraft capacity: maximum people on board: 3 person maximum load capacity: 240 kg (530 lb) dimensions: length: 3340 mm (131.5 in) width: 1230 mm (48.4 in) height: fx high output 1160 mm (45.7 in) fx cuiser high output 1240 mm (48.8 in) dry weight: fx high...
Page 101: Trouble Recovery
Trouble recovery 96 eju34560 troubleshooting if you have any trouble with your watercraft, use this section to check for the possible cause. If you cannot find the cause, or if the procedure for replacement or repair is not described in this owner’s/operator’s manual, have a yamaha dealer perform th...
Page 102: Trouble Recovery
Trouble recovery 97 engine runs irregu- larly or stalls fuel empty refill as soon as pos- sible 54 stale or contaminat- ed have serviced by yamaha dealer 86 fuel tank water or dirt present have serviced by yamaha dealer 86 spark plug fouled or defective replace 90 incorrect heat range replace 90 gap...
Page 103: Trouble Recovery
Trouble recovery 98 eju34620 emergency procedures eju34630 cleaning the jet intake and impeller if weeds or debris get caught in the jet intake or impeller, cavitation can occur, causing jet thrust to decrease even though engine speed rises. If this condition is allowed to continue, the engine will ...
Page 104: Trouble Recovery
Trouble recovery 99 caution: ecj00660 ● place a suitable clean cloth or carpeting underneath the watercraft to protect it from abrasions and scratches. ● always turn the watercraft over onto its port (left) side. ● when turning the watercraft on its side, support the bow so that the handlebars are n...
Page 105: Trouble Recovery
Trouble recovery 100 gine. Any wrong connection could dam- age the electrical system. (4) start the engine, and then disconnect the jumper cables by reversing the steps above. Caution: ecj00480 ● never push the start switch while the en- gine is running. ● do not operate the start switch for more th...
Page 106: Trouble Recovery
Trouble recovery 101 tensive electrical system damage and pos- sible fire. Eju34710 towing the watercraft if the watercraft becomes inoperative in the water, it can be towed to shore. If the watercraft must be towed in an emer- gency using a towline, the operator should ride the watercraft, holding ...
Page 107: Trouble Recovery
Trouble recovery 102 (6) spray a rust inhibitor such as yamaha stor-rite engine fogging oil into each spark plug hole for 5 seconds. (7) crank the engine for 5 seconds at wide open throttle. Repeat this step several times. (8) install the spark plugs, and then connect the spark plug caps and fuel in...
Page 108: Consumer Information
Consumer information 103 eju34780 limited warranty yamaha motor corporation, u.S.A. Watercraft limited warranty yamaha motor corporation is proud of its heritage and reputation for producing products with high standards of quality and workman- ship. Product excellence provides the cornerstone for ou...
Page 109: Consumer Information
Consumer information 104 this warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Yamaha motor corporation, u.S.A. Post office box 6555 cypress, california 90630 warranty questions and answers q. What costs are my responsibility during the war...
Page 110: Consumer Information
Consumer information 105 eju34800 yamaha extended service (y.E.S.) keep your yamaha protected even after your warranty expires with genuine yamaha extended service (y.E.S.). • y.E.S. Is designed and administered by yamaha motor corporation to provide maximum owner satisfaction. You get uninterrupted...
Page 111: Index
Index a air filter element, checking ....................... 87 analog speedometer/tachometer ............. 40 analog speedometer/tachometer and indicator lights....................................... 40 approval label of emission control certificate ................................................ ...
Page 112: Index
Index limitations on who may operate the watercraft .......................................... 8 limited warranty..................................... 103 “l-mode” indicator light........................... 42 lubrication................................................ 80 lubrication points ...........
Page 113: Index
Index yamaha extended service (y.E.S.) ............................................... 105 yamaha security system......................... 38 yamaha security system and low-rpm mode ..................................... 37 yamaha security system lock and unlock modes....................................
Page 114
A5-tate_blank.Fm page 1 friday, may 16, 2003 9:00 am.
Page 115
A5-tate_blank.Fm page 1 friday, may 16, 2003 9:00 am.
Page 116
Printed in usa july 2007–0.7 × 2 cr yamaha motor corporation, usa.