1. DL manuals
  2. Yamaha
  3. Amplifier
  4. P5000S - Amplifier
  5. Service Manual

Yamaha P5000S - Amplifier Service Manual

Other manuals for P5000S - Amplifier: Owner's Manual, Owner's Manual, Owner's Manual, Service Manual

Summary of P5000S - Amplifier

  • Page 1

    Service manual hamamatsu, japan copyright (c) yamaha corporation. All rights reserved. Pdf-k765 04.11 pa 011756 contents （目次） specifications （総合仕様）........................................................ 3/4 dimensions （寸法図） ..................................................................... 5 per...

  • Page 2

    2 p5000s/p7000s important notice this manual has been provided for the use of authorized yamaha retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry , and more specifically yamaha products, are already known and under- stood by the users, ...

  • Page 3

    3 p5000s/p7000s ■ specifications 0 dbu=0.775 vrms, half power=1/2 power output level (rated power) power output level (rated power) 8 Ω /stereo 1 khz 4 Ω /stereo thd + n = 1% 8 Ω /bridge 8 Ω /stereo 20 hz 20 khz 4 Ω /stereo thd + n = 0.1% 8 Ω /bridge 1 khz 2 Ω /stereo 20 ms non-clip 4 Ω /bridge p700...

  • Page 4

    4 p5000s/p7000s ■ 総合仕様 0 dbu = 0.775 vrms , half power = 1/2 power output level (rated power) p5000s 出力レベル 8 Ω /stereo 525 w × 2 1 khz 4 Ω /stereo 750 w × 2 thd ＋ n = 1 % 8 Ω /bridge 1500 w × 1 8 Ω /stereo 500 w × 2 20 hz 〜 20 khz 4 Ω /stereo 700 w × 2 thd ＋ n = 0.1 % 8 Ω /bridge 1400 w × 1 1 khz 2 ...

  • Page 5

    5 p5000s/p7000s ■ dimensions （寸法図） ■ perfomance graphs （特性図） unit: mm p5000s mode:stereo both ch driven rl=4 , f=1 khz power consumption [w] output power [w] 1 10 100 10000 1000 1 10 100 1000 Ω p7000s mode:stereo both ch driven rl=4 , f=1 khz power consumption [w] output power [w] 1 10 100 10000 100...

  • Page 6

    6 p5000s/p7000s q [power] switch and indicator w [temp] indicator e [protection] indicator r [clip] indicator t [signal] indicator y volume control knobs u [ ]indicator i air intakes ■ panel layout （パネルレイアウト） q [power] スイッチ/ インジケーター w [temp] インジケーター e [protection] インジケーター r [clip] インジケーター t [signal]...

  • Page 7

    7 p5000s/p7000s ・ rear pane l（リアパネル） q filter switch and[frequency] adjustment knob (one pair for each channel) w [ ] on/off switch e [input] jacks (channels a, b) r [stereo/parallel/bridge] switch t [speakers] jacks y gnd terminal q filter スイッチ、[frequency]調整つまみ （チャンネルa、b） w [ ]切り替えスイッチ e [input]端子 ...

  • Page 8

    8 p5000s/p7000s ■ circuit board la yout&wiring （ユニットレイアウト＆結線図） pah pah ps in vr led coil out2 out1 psw in out1 out2 rear panel （リアパネル） vr led led psw the figure which looked at the front panel from the inner side （フロントパネルを内側から見た図） front panel （フロントパネル）.

  • Page 9

    9 p5000s/p7000s • detail drawing this point has a wire harness tie. * the following "wiring ass'y" are tied. (wd35970,wd35950, wd36080) see page 9 see page 11 see page 11 see page 10 see page 10 see page 10 see page 10 see page 10 see page 10 see page 10 see page 11 see page 11 see page 12 see page ...

  • Page 10

    10 p5000s/p7000s • detail drawing • detail drawing • detail drawing * the following "wiring ass'y" are tied. * the following "wiring ass'y" are tied. ＊ ch00440 is not a service parts. （ch00440はサービス部品ではありません） * the following "wiring ass'y" are tied. (wd35970) (wd35970) (wd35950,wd35970) (wd35950,wd35...

  • Page 11

    11 p5000s/p7000s • detail drawing * the following "wiring ass'y" are tied. (wd36000,wd36010x2,wd36020 wd36060x2,wd36070,wd36100 wd36110) • (wd36100,wd36110): j,h,b,chn destination only. (wd35950,wd36000,wd36010 wd36020,wd36060x2,wd36070) (wd35950,wd36080) need twist of two rotations. （ !0!3!4 部詳細図） ...

  • Page 12

    12 p5000s/p7000s • detail drawing out 2 soldering earthfilm. （ out2 シートの詳細図） （アースフィルムを半田付けします） • detail drawing * the following "wiring ass'y" are tied. (wd35940,wd38950,wd36060x2 wd36070) (wd36060x2,wd36070,fan wiring) （ !1!2 部詳細図） （下記ワイヤーを束ねます） • the wiring ass'y(wd35950) has to be tense condition...

  • Page 13

    13 p5000s/p7000s • connect of coils. Please connect the red wire to cn406. Please connect the black wire to cn415. （コイルワイヤーの接続） （コイルワイヤーの接続について） （赤いワイヤーはcn406、黒いワイヤーは cn415へ接続してください） *regarding to connect the wire of coil..

  • Page 14

    14 p5000s/p7000s [410] [150] [150] 2. Top cover (time required: about 2 min.) 2-1 remove the eleven (11) screws marked [480]. The top cover can then be removed. (fig.1) (fig.2) 2. トップカバー （所要時間: 約2分） 2-1 [480] のネジ11 本を外し、トップカバーを外し ます。 （fig.1） 1. Rack angle (time required: about 1 min.) 1-1 remove the...

  • Page 15

    15 p5000s/p7000s [180] [410] 4. Ps circuit board (time required: about 5 min.) 4-1 remove the rack angle. (see procedure 1.) 4-2 remove the top cover. (see procedure 2.) 4-3 remove the nine (9) screws marked [180]. The ps circuit board can then be removed. (fig.3) (fig.3) 5. In circuit board (time r...

  • Page 16

    16 p5000s/p7000s (fig.6) 6. Out1 circuit board (time required: about 4 min.) 6-1 remove the rack angle. (see procedure 1.) 6-2 remove the top cover. (see procedure 2.) 6-3 remove the four (4) screws marked [320]. (fig.1) 6-4 remove the two (2) hexagonal nuts marked [c]. The out1 circuit board can th...

  • Page 17

    17 p5000s/p7000s [a] 8. Front panel part (time required: about 5 min.) 8-1 remove the rack angle. (see procedure 1.) 8-2 remove the top cover. (see procedure 2.) 8-3 cuts cord holder (5 point) of the connector assembly. (fig.7) 8-4 remove the six (6) screws marked [410]. (fig.2, fig.3) 8-5 draws out...

  • Page 18

    18 p5000s/p7000s [60] [70] [65] [50] coil [60] (fig.10) 10. Coil circuit board (time required: about 7 min.) 10-1 remove the front panel part. (see procedure 8.) 10-2 remove the ps circuit board. (see procedure 4.) 10-3 remove the four (4) screws marked [60]. The coil circuit board can then be remov...

  • Page 19

    19 p5000s/p7000s [100] 12. Psw circuit board (time required: about 10 min.) 12-1 remove the front panel part. (see procedure 8.) 12-2 remove the power switch escutcheon marked [400]. (fig.13) 12-3 it presses lightly from the panel back and remove the power switch knob marked [100]. * when it is hard...

  • Page 20

    20 p5000s/p7000s 14. Disassemble of front panel 1 and front panel 2 (time required: about 8 min.) 14-1 remove the front panel part. (see procedure 8.) 14-2 remove the handles. (see procedure 13.) 14-3 remove the eight (8) hex socket tapping screws marked [360]. The front panel 1 and the front panel ...

  • Page 21

    21 p5000s/p7000s ■ ic block diagram （ic ブロック図） • njm2068md-te2 (x3505a00) dual operational amplifier p5000s in: ic301, ic302, ic303, ic304, ic305, ic306, ic307 pah: ic201 p7000s in: ic301, ic302, ic303, ic304, ic305, ic306, ic307 pah: ic201 p5000s ps: ic402 p7000s ps: ic402 ir2110 (x2382a00) driver ...

  • Page 22

    22 p5000s/p7000s contents （目次） ● pah circuit board (x3850b0) ....................................................................................... 23 ● ps circuit board (x5600a0) ......................................................................................... 25 ● in circuit board (x3501c...

  • Page 23

    23 p5000s/p7000s ● pah circuit board to ps- ( cn412(ach) cn411(bch) to in-cn301(ach,bch) a a’ b b’ to out2- ( w604(ach) w606(bch) to ps- ( w401(ach) w406(bch) to ps- ( w402(ach) w407(bch) to ps- ( w403(ach) w408(bch).

  • Page 24

    24 p5000s/p7000s 2nap-wd35140 (p5000s) 2nap-wd35140 (p7000s) a a’ b b’ ref. P5000s p7000s d124 d125 d126 d127 q112 q113 q114 q115 q117n q117p q118n q118p q119n q119p q120n q120p q121n q121p q122n q122p q123n q123p q124n q124p q125n q125p q126n q126p q218 pr201 pr202 following semi-conductors are ins...

  • Page 25

    25 p5000s/p7000s ● ps circuit board to led-cn601 to fan(ach) temp led test point to psw-w602(or w601) a a' to in-cn301 to fan(bch) to pah-cn103(bch) to pah-cn104(bch) to pah-cn105(bch) to pah-cn105(ach) to pah-cn104(ach) to pah-cn103(ach) fan test point to pah-cn201(ach) to pah-cn201(bch).

  • Page 26

    26 p5000s/p7000s t a a' to coil-w701 to coil-w702 to ac in to ac in to psw-w603 to psw-w601(or w602) component side （部品側）.

  • Page 27

    27 p5000s/p7000s b b'.

  • Page 28

    28 p5000s/p7000s ps: 2nap-wd35180 1 (p5000s) ps: 2nap-wd35180 1 (p7000s) b b' pattern side （パターン側）.

  • Page 29

    29 p5000s/p7000s 2nap-wd35520 ● in circuit board to vr-cn602 to out2-w301b to ( pah-cn202(ach,bch) ps-cn408 component side （部品側） pattern side （パターン側）.

  • Page 30

    30 p5000s/p7000s ● led circuit board 2nap-wd35390 component side （部品側） ※ as for ver b, some silk prints are different. Ver. B はシルク印刷が若干異なります。 pattern side （パターン側） to ps-cn410 clp a b temp protection power signal.

  • Page 31

    31 p5000s/p7000s ● out1 circuit board 2nap-wd35390 component side （部品側） pattern side （パターン側） to out2-w607b ※ as for ver b, some silk prints are different. Ver. B はシルク印刷が若干異なります。.

  • Page 32

    32 p5000s/p7000s ● out2 circuit board 2nap-wd35390 component side （部品側） pattern side （パターン側） to in-w301a to out1-w607a to pah-cn102(ach) to pah1-cn102(bch) to ps-cn416 ※ as for ver b, some silk prints are different. Ver. B はシルク印刷が若干異なります。.

  • Page 33

    33 p5000s/p7000s ● vr circuit board pws:2nap-wd35390 vr:2nap-wd35390 ● psw circuit board component side （部品側） pattern side （パターン側） component side （部品側） pattern side （パターン側） power on/off to ps-cn403 to ps-cn404 (or cn405) to ps-cn405 (or cn404) to in-cn302 b a ※ as for ver b, some silk prints are dif...

  • Page 34

    34 p5000s/p7000s ● coil circuit board 2nap-wd35490 to ps-cn415 pattern side （パターン側） component side （部品側） to ps-cn406 h destination （h 仕向） component side solder side l701, l702 insulock-tie put insulock-tie through the hols of pcb. （インシュロックタイを基板の穴に通して コイルを固定します。）.

  • Page 35

    35 p5000s/p7000s 1. Scope • this inspection specifications is applied to the powe r amplifier p5000s/p7000s. ∗ refer to p42 “the switch and adjustment part” for details in the adjustment part. 2. Preparation for stereo/parallel mode attenuator : "0"(max) input terminal : cannon connector 2pin-hot/3p...

  • Page 36

    36 p5000s/p7000s *sub woofer position(off/sub woofer/low cut switch) input signal is 25hz, -10dbu, and set frequency to 25hz. The output voltage shall be -3.0 +/- 2.0db compared to the 1khz at the switch off. Input signal is 150hz, -10dbu, and set frequency to 150hz. The output voltage shall be -3.0...

  • Page 37

    37 p5000s/p7000s 3.10 stability input the rectangular waveform of 10khz at -10dbu. Connect only capacitance of 0.01uf (polyester film capacitance) to output terminal. Input signal is 10khz, -10dbu sqare wave. The overshoot and the ringing should be as follows. Overshoot : vp/vo ringing : within 7 wa...

  • Page 38

    38 p5000s/p7000s 4. Preparation for bridge mode attenuator :"0"(max) effective only channel a. Input terminal : cannon connector 2pin-hot/3pin-cold/1pin-gnd mode switch : bridge subwoofer/low cut switch : off ys processing switch : off load resistor : 8+8 ohms +/- 1% connection for measuring : measu...

  • Page 39

    39 p5000s/p7000s 5.4 output noise level shunt the input terminal with 600 ohms (2pin-hot, 3pin-cold). The noise level of output terminal shall be less than -60 dbu. Next, set the input attenuator to min. The noise level shall be less than -65 dbu. 6. Ps sheet trouble repair guide 6.1 the application...

  • Page 40

    40 p5000s/p7000s 6.4 repair concrete instance at the trouble part check the following instruction. Q confirm the resistor value of r416, r451(6.8 Ω 5 w). Exchange if open the resistor value. W confirm the resistor value of q406, q407 between c-e. If short or several value( Ω ), remove the part and t...

  • Page 41

    41 p5000s/p7000s ac-in power sw 22k 3w 22k 3w 10k 1/4w 10k 1/4w psw w603 vi(pk) w601 gy gy cn404 ic403 ic401 r429 r430 ic402 r421 r419 r420 ∗ q407 q406 pr401 f401 wh be cn402 bl or cn401 cn406 re cn415 bl r451 r416 gy cn405 vi(pk) cn403 w602 gy sw601 +b g - b -15v g +15v w407 bl w406 re cn408 w408 w...

  • Page 42

    42 p5000s/p7000s 7. Preparation of delivery attenuator : min mode switch : stereo subwoofer/low cut switch : off ys processing switch : on frequency : 25hz ● the switch and adjustment part vr201(channel b) vr201(channel a) cn101(channel a) cn101(channel b) tm-c fan-c front side: temp ted, protection...

  • Page 43

    43 p5000s/p7000s 1. 適用範囲 ･パワーアンプ p5000s/p7000s について規定します。 * 調整箇所の詳細については p50 スイッチ及び調整箇所 を参照してください。 2. Stereo/parallel モード用の準備 アッテネータ ："0"(max) 入力端子 ：cannon connector 2pin-hot/3pin-cold/1pin-gnd モードスイッチ ：stereo subwoofer/low cut スイッチ ：off ys processing スイッチ ：off 負荷抵抗 ：8 Ω +/- 1% 特に指定の無い場合、両チャンネル駆動としま...

  • Page 44

    44 p5000s/p7000s *[off/sub woofer/low cut] *[off/sub woofer/low cut] *[off/sub woofer/low cut] *[off/sub woofer/low cut] *[off/sub woofer/low cut] ス イ ッ チ を ス イ ッ チ を ス イ ッ チ を ス イ ッ チ を ス イ ッ チ を sub woofer sub woofer sub woofer sub woofer sub woofer に し ま す 。 に し ま す 。 に し ま す 。 に し ま す 。 に し ま す ...

  • Page 45

    45 p5000s/p7000s 3.10 安定度 負荷を純容量 0.01uf（フィルムコンデンサ）のみとします。 10khz, -10dbu の矩形波を入力した時、発振せずに以下の条件を満足することを確認します。 オーバーシュート ：vp/vo リンギング ：7 波以内に収束し、発振などを生じないこと。 3.11 プロテクション回路 出力端子から負荷抵抗の接続を外します。 10hz、+9.0dbu の信号を入力し、protection led が点灯しないことを確認します。 1hz,+5.0dbu の信号を入力した時、2 秒以内に電源がシャットダウンすることを確認します。 パワースイッチを ...

  • Page 46

    46 p5000s/p7000s 4. Bridge モード用の準備 アッテネーター ："0"(max)a チャンネルのみ有効 . 入力端子 ：cannon connector 2pin-hot/3pin-cold/1pin-gnd モードスイッチ ：bridge subwoofer/low cut スイッチ ：off ys processing スイッチ ：off 負荷抵抗 ：8+8 Ω +/- 1% 下図のとおりに接続して、各点における出力を測定します。 5. 検査 5.1 利得 1khz、-10.0dbu の信号を入力した時、+22.1 ± 1.0dbu の出力電圧を得ることを確認します...

  • Page 47

    47 p5000s/p7000s 6. Ps シート故障修理ガイド 6.1 適用シート部品番号及び電源電圧 6.2 正常動作時電気的性能 6-2-2 準備 ・ cn403,cn404,cn405 にシート psw(wd353900 sub シートの 1 部)を接続します。 ・ coil70j 又は coil70h シートが使用されている仕向においては、j410 〜 j413 を接続します。 (もしくは cn406 と cn415 をショートします) ・±Ｂ 電源、± 15v に負荷抵抗を接続します。＜表 2-1 ＞参照 ・電源コードを cn401,cn402 に挿入します。 ・電源電圧を各シー...

  • Page 48

    48 p5000s/p7000s 6.4 故障箇所の修理具体例 下記の部品をチェックして、指示に従って下さい。 q r416,r451(6.8 Ω 5 w)の抵抗値 オープンしていれば交換して下さい。 w q406,q407 c-e 間の抵抗値 ショートまたは、抵抗値が低下(数Ω 程度)していれば、その部品を外してください。 その場合、ic402 が壊れていますので交換してください。 e r420 、r421 の抵抗値 10 Ω の抵抗値であるか確認してください。 オープンまたは、抵抗値が増大していれば外して下さい。 r r419 の抵抗値 4.7 Ω の抵抗値であるか確認してください。 オー...

  • Page 49

    49 p5000s/p7000s • 接続図/チェック部品 ac-in power sw 22k 3w 22k 3w 10k 1/4w 10k 1/4w psw w603 vi(pk) w601 gy gy cn404 ic403 ic401 r429 r430 ic402 r421 r419 r420 ∗ q407 q406 pr401 f401 wh be cn402 bl or cn401 cn406 re cn415 bl r451 r416 gy cn405 vi(pk) cn403 w602 gy sw601 +b g - b -15v g +15v w407 bl w406 re...

  • Page 50

    50 p5000s/p7000s 7. 出荷時のセッティング アッテネーター ：min モードスイッチ ：stereo subwoofer/low cut スイッチ ：off ys processing スイッチ ：on frequency ：25hz vr201(channel b) vr201(channel a) cn101(channel a) cn101(channel b) tm-c fan-c front side: temp ted, protection led, poer led, clip led signal led, ysprocessing led, attenua...

  • Page 51: Power Amplifier

    P5000s / p7000s contents （目次） overall assembly （総組立） ............................................. 2 paunit （paユニット） ............................................................. 5 electrical parts （電気部品） ............................................ 7 power amplifier parts list note) destination abb...

  • Page 52

    P5000s / p7000s 2 ■ overall assembly （総組立） 30 5 480 470 490 495 180 440 170 160 80d 80e 290 20 40 70 210 65 50 190 200 270 280 250 270 220 450 510 310 10 20 40 240 80a 140 430 420 150 30 390 380 410 80c 80b 340 100 380 350 370 400 370 360 410 390 120 110 90 150 30 420 430 140 60 130 260 280 500 210 ...

  • Page 53

    P5000s / p7000s 3 ref no . Part no. Description remarks qty rank 部 品 名 rank : japan only ∗ : new parts （新規部品） 10 15 20 30 40 50 50 60 65 70 80 80a 80b 80c 80d 80e 90 100 110 120 130 140 140 150 160 170 170 170 170 170 170 170 170 170 170 180 190 190 190 190 190 195 196 200 210 220 230 240 250 260 27...

  • Page 54

    P5000s / p7000s 4 ref no . Part no. Description remarks qty rank 部 品 名 ∗ : new parts （新規部品） rank : japan only 310 320 340 340 345 350 360 370 380 390 400 410 420 430 440 450 460 470 480 490 490 490 490 490 490 490 490 490 490 490 490 490 490 495 500 510 10 20 vq049800 ep600790 wd491100 wd491000 -- w...

  • Page 55

    P5000s / p7000s 5 note: 1. Quantity a type , b type and c type: ref er to a par ts list. 2.There is not an y b urrs and con v e x w ound in fitting of each types area. Read : max. 3.0mm pr201 q118p q119p q120p q121p q122p q123p q125p q126p q124p q113 d127 q115 d126 q117 pr202 q118n q218 q119n q120n ...

  • Page 56

    P5000s / p7000s 6 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 10 20 30 30 40 50 60 70 d124 d125 d126 d127 pr201 pr202 q112 -115 q218 q117n q117p q118n q118p q119n q119p q120n q120p q121n q121p q122n q122p q123n q123p q124n q124p q125n q125p q126n q126p...

  • Page 57

    P5000s / p7000s 7 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 10 20 30 40 50 l701 l702 w701 w702 230 l701 l702 w701 w702 c301 -304 c305 -308 c309 c310 -313 c314 -317 c318 -331 c332 c333 cn301 cn302 d301 -304 ic301 -307 j303 -306 jk301 jk302 jk303 jk304...

  • Page 58

    P5000s / p7000s 8 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r317 r318 r319 r320 r321 r322 r323 r324 r325 r326 r327 r328 r329 r330 r331 r332 r333 r334 r335 r336 r337 r338 r339 r340 r341 r342 r343 r344 r345 r346 r347 r348 r349 r350 r351 -353 sw301 sw30...

  • Page 59

    P5000s / p7000s 9 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 c413 c413 c414 c414 c415 c416 c416 c417 c417 c418 c420 c420 c420 c422 c423 c424 c425 c425 c426 c427 c428 c429 c430 c431 c432 c433 c434 c435 c436 c437 c438 c439 c440 c441 c442 c443 c444 c445 ...

  • Page 60

    P5000s / p7000s 10 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 d406 d407 d408 -411 d412 d413 d414 -417 d418 d419 d420 d421 d422 d423 d424 d425 -427 d428 d429 -432 d433 d434 d435 d436 d437 d438 f401 f401 f401 h401 h401 h402 h402 ic401 ic402 ic403 ic404 ...

  • Page 61

    P5000s / p7000s 11 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 q418 q419 q420 q421 q422 q423 q424 q425 q426 -429 r401 r402 r403 r404 r405 r406 r407 r408 r409 r410 r411 r412 r413 r414 r415 r416 r417 r418 r419 r420 r421 r422 r423 r424 -427 r428 r429 r430...

  • Page 62

    P5000s / p7000s 12 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r463 r464 r465 r466 r467 r468 r469 r470 r471 r472 r473 r474 r475 r476 r477 r478 r479 r480 r481 r482 ry401 t401 t401 t401 t401 t402 t402 t402 w401 w402 w403 w406 w407 w408 130 200 210 210 22...

  • Page 63

    P5000s / p7000s 13 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 c417 c417 c418 c420 c420 c420 c422 c423 c424 c425 c425 c426 c427 c428 c429 c430 c431 c432 c433 c434 c435 c436 c437 c438 c439 c440 c441 c442 c443 c444 c445 c446 c447 c448 c449 c450 c451 c452...

  • Page 64

    P5000s / p7000s 14 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 -417 d418 d419 d420 d421 d422 d423 d424 d425 -427 d428 d429 -432 d433 d434 d435 d436 d437 d438 f401 f401 f401 h401 h401 h402 h402 ic401 ic402 ic403 ic404 ic405 j401 j402 j403 j408 j409 j410...

  • Page 65

    P5000s / p7000s 15 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 q425 q426 -429 r401 r402 r403 r404 r405 r406 r407 r408 r409 r410 r411 r412 r413 r414 r415 r416 r417 r418 r419 r420 r421 r422 r423 r424 -427 r428 r429 r430 r431 r432 r433 r434 r435 r436 r437...

  • Page 66

    P5000s / p7000s 16 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r470 r471 r472 r473 r474 r475 r476 r477 r478 r479 r480 r481 r482 ry401 t401 t401 t401 t401 t402 t402 t402 w401 w402 w403 w406 w407 w408 10 20 30 40 50 cn602 vr601 vr602 sw601 w601 w602 w603...

  • Page 67

    P5000s / p7000s 17 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 q605 q606 -609 r601 r602 r603 r604 r605 r606 r607 r608 r609 r610 r611 r612 -615 r616 -623 jk601 jk602 sp602 sp603 w607 c608 -611 c612 -614 r624 r625 r626 r627 r628 sp601 w604 w605 w606 c101...

  • Page 68

    P5000s / p7000s 18 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 c127 c128 c129 c201 c202 c203 c204 c205 c206 c207 c208 c209 c210 c211 c212 c213 c214 c215 c216 c217 c218 c219 c220 c221 c222 -224 cn101 cn102 -105 cn201 cn202 d101 d102 d103 d104 d105 d106 ...

  • Page 69

    P5000s / p7000s 19 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 l105 q101 q102 q103 q104 q105 q106 q107 q108 q109 q110 q111 q127 q127 q128 q129 q129 q130 -132 q133 q134 q201 q201 q202 q202 q203 q203 q204 q204 q205 q206 q207 q208 q209 q210 q211 q212 q213...

  • Page 70

    P5000s / p7000s 20 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r128 r129 r130 r131 r132 r133 r134 r135 r136 r137 r138 r139 r140 r141 r142 r143 r144 r145 r146 r147 r148 r151 r156 r157 r158 r159 r160 r161 r162 r163 r164 r165 r166 r167 r168 r169 r170 r171...

  • Page 71

    P5000s / p7000s 21 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r209 r210 r211 r212 r213 r214 r215 r216 r217 r218 r219 r220 r221 r222 r223 r224 r225 r226 r228 r229 r230 r231 r232 -234 r235 r236 r237 r238 r239 r240 r241 r242 r243 r244 r245 r246 r247 r248...

  • Page 72

    P5000s / p7000s 22 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 c106 c107 c108 c109 c110 c111 c112 c113 c114 c115 c116 c117 c118 c119 c120 c121 c122 c123 c124 c125 c126 c127 c128 c129 c201 c202 c203 c204 c205 c206 c207 c208 c209 c210 c211 c212 c213 c214...

  • Page 73

    P5000s / p7000s 23 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 d122 d123 d128 d129 d201 d202 d203 -206 d208 d209 d210 d211 d212 d213 d214 ic201 ic202 l101 l102 l103 l104 l105 q101 q102 q103 q104 q105 q106 q107 q108 q109 q110 q111 q127 q127 q128 q129 q1...

  • Page 74

    P5000s / p7000s 24 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r107 r108 r109 r110 r111 r112 r113 r114 r115 r116 r117 r118 r119 r120 r121 r122 r123 r124 r125 r126 r127 r128 r129 r130 r131 r132 r133 r134 r135 r136 r137 r138 r139 r140 r141 r142 r143 r144...

  • Page 75

    P5000s / p7000s 25 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r177 r178 r179 r180 r181 r182 r183 r184 r185 r186 r187 r188 r189 r190 r191 r192 r193 r194 r195 r201 r202 r203 r204 r205 r206 r207 r208 r209 r210 r211 r212 r213 r214 r215 r216 r217 r218 r219...

  • Page 76

    P5000s / p7000s 26 ref no . Part no. Description remarks qty rank rank : japan only ∗ : new parts （新規部品） 部 品 名 r280 r281 r282 r283 r284 r285 r286 r287 r288 r289 r290 r291 r292 r293 r294 r295 -297 r298 r299 vr201 rf357200 rd357100 rf357620 hb028270 rf357100 rd358150 rd358100 rd357100 rd357200 rd35810...

  • Page 77: Power Amplifier

    Power amplifier ■ contents （目次） ic & diode outside figure （外形図）.............................................. 2 block diagram （ブロックダイアグラム）........................................ C1 wiring diagram （基板結線図）......................................................... C2 overall circuit diagram （総回路図） in ....

  • Page 78

    P5000s / p7000s 2 ic & diode outside figure （外形図） • fmu-36r (v8498700) diode stack 20.0a 600v ps: d413 • fmu-36s (vn399500) diode stack 20.0a 600v ps: d412 • njm7815fa (xd853a00) regulator +15v 1: input 2: common 3: output 3 2 1 ps: ic403, ic404 • njm7915fa (xd854a00) regulator -15v 1: common 2: inp...

  • Page 79

    P5000s/p7000s p5000s/p7000s p5000s/p7000s h g f e d c b a 1 2 3 4 5 jk301 ic302-2/2 sw302-3/4 sw303-1/2 ys processing ic304-1/2 1 3 2 jk303 ic301-1/2 ic301-2/2 ic304-2/2 ic305-1/2 ic305-2/2 sw302-4/4 vr301 sw303-2/2 sw304-2/2 sw304-1/2 sw301-2/2 ic301~307 sw301-1/2 q117n cn301-8p jk302 ic303 sw302-1...

  • Page 80

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s wiring led coil vr ps pa pah h pah out1 out2 psw pah b ch a ch (pk) in 28c99-8833621 j/h distination only j/h distination only ( ) ( ( ( ( ( ( ( ( ( ( ( ( ( ( ) ) ) ) ) ) ( ( ( ) ) ) ) ) ) ) ) ) ) ) ∗ connector assembly is not a service parts...

  • Page 81

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s overall circuit diagram 1/5 (in) in input input input input to out2-w301b 28cc1-8833619 frequency ach frequency bch op amp op amp op amp op amp op amp op amp op amp op amp op amp op amp op amp to vr-cn602 off sub.W. Low c. Off sub.W. Low c. ∗...

  • Page 82

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s overall circuit diagram 2/5 (pah 1/2) pah 1/2 to c5-l7 to c5-l7 to c5-l1 to c5-l3 to c5-l3 to c5-l5 to c5-l6 to c5-l7 to c5-l7 to c5-l7 to c5-l6 to c5-l4 to in-cn301 1p(ach) to in-cn301 3p(bch) to in-cn301 2p(ach) to in-cn301 4p(bch) to ps-cn...

  • Page 83

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s overall circuit diagram 3/5 (pah 2/2) pah 2/2 from c4-a1 from c4-a2 from c4-a5 from c4-a1 from c4-a4 from c4-a4 from c4-a5 from c4-a5 from c4-a5 from c4-h5 from c4-h5 from c4-a5 to out2-w604(ach) to ps-w403 (ach) to ps-w408 (bch) to ps-w402 (...

  • Page 84

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s overall circuit diagram 4/5 (ps) ps to psw-w603 to coil-w701 to coil-w702 to in-cn301 -5p~8p to fan (bch) to fan (ach) to led-cn601 to pah-cn201(bch) to pah-cn201(ach) to pah-cn103(ach) to out2-w605 to pah-cn104(ach) to pah-cn105(ach) to pah-...

  • Page 85

    P5000s/p7000s p5000s/p7000s p5000s/p7000s p5000s / p7000s overall circuit diagram 5/5 (led, out1, out2, coil, vr, psw) led vr psw coil out2 out1 28cc1-8833618 1 28cc1-8833618 1 28cc1-8833618 1 to ps-cn410 to pah-cn102(a) wd36080 wd36010 wd36090 to ps-cn416 to ps-cn406 to ps-cn415 to ps-cn405 to ps-c...