- DL manuals
- Yamaha
- Motorcycle
- ROADLINER XV19C
- Owner's Manual
Yamaha ROADLINER XV19C Owner's Manual
Summary of ROADLINER XV19C
Page 1
1d7-28199-11 xv19sw(c) xv19w(c) xv19mw(c) owner’s manual lit-11626-20-40
Page 2
Eau10041 u1d711e0.Book page 1 tuesday, june 27, 2006 1:24 pm.
Page 3: Introduction
Introduction eau10080 congratulations on your purchase of the yamaha xv19sw(c)/xv19w(c)/xv19mw(c). This model is the result of yamaha’s vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that ha...
Page 4: Important Manual Information
Important manual information eau10131 particularly important information is distinguished in this manual by the following notations: note: ● this manual should be considered a permanent part of this motorcycle and should remain with it even if the motorcycle is subsequently sold. ● yamaha continuall...
Page 5: Important Manual Information
Important manual information and until you have been trained in safe and proper riding techniques. Regular inspections and careful maintenance, along with good riding skills, will ensure that you safely enjoy the capabilities and the reliability of this motorcycle. *product and specifications are su...
Page 6: Important Manual Information
Important manual information eau10192 xv19sw(c)/xv19w(c)/xv19mw(c) owner’s manual ©2006 by yamaha motor corporation, u.S.A. 1st edition, june 2006 all rights reserved. Any reprinting or unauthorized use without the written permission of yamaha motor corporation, u.S.A. Is expressly prohibited. Print...
Page 7: Table of Contents
Table of contents safety information ..................1-1 location of important labels ...........1-5 description ..................................2-1 left view ..........................................2-1 right view ........................................2-2 controls and instruments ..............
Page 8: Table Of Contents
Table of contents troubleshooting ............................6-32 troubleshooting chart ...................6-33 motorcycle care and storage ..........................................7-1 matte color caution .........................7-1 care ................................................7-1 storage...
Page 9: Safety Information
1-1 1 safety information eau10281 motorcycles are single track vehicles. Their safe use and operation are dependent upon the use of proper riding techniques as well as the ex- pertise of the operator. Ev- ery operator should know the following requirements before riding this motor- cycle. He or she ...
Page 10: Safety Information
Safety information 1-2 1 due to excessive speed or un- dercornering (insufficient lean an- gle for the speed). • always obey the speed limit and never travel faster than warrant- ed by road and traffic conditions. • always signal before turning or changing lanes. Make sure that other motorists can s...
Page 11: Safety Information
Safety information 1-3 1 loading the total weight of the operator, pas- senger, accessories and cargo must not exceed the maximum load limit. When loading within this weight limit, keep the following in mind: ● cargo and accessory weight should be kept as low and close to the motorcycle as possible....
Page 12: Safety Information
Safety information 1-4 1 tor and may limit control ability, therefore, such accessories are not recommended. ● use caution when adding electri- cal accessories. If electrical acces- sories exceed the capacity of the motorcycle’s electrical system, an electric failure could result, which could cause ...
Page 13: Safety Information
Safety information 1-5 1 eau10381 location of important labels please read the following important labels carefully before operating this vehicle. U1d711e0.Book page 5 tuesday, june 27, 2006 1:24 pm.
Page 14: Safety Information
Safety information 1-6 1 4 5 1 2 3 california only premium unleaded gasoline only 91 min. Pump octane (r+m) 2 5pw-2415e-11 u1d711e0.Book page 6 tuesday, june 27, 2006 1:24 pm.
Page 15: Description
Description 2-1 2 eau10410 left view 1. Headlight (page 6-28) 2. Clutch fluid reservoir (page 6-18) 3. Seat lock (page 3-12) 4. Main fuse (page 6-26) 5. Battery (page 6-25) 6. Owner’s tool kit (page 6-1) 7. License plate light (page 6-31) 8. Tail/brake light (page 6-31) 9. Engine oil drain bolt b (c...
Page 16: Description
Description 2-2 2 eau10420 right view 1. Helmet holder (page 3-13) 2. Fuel injection system fuse (page 6-26) 3. Rear brake fluid reservoir (page 6-18) 4. Fuse box (page 6-26) 5. Engine oil filler cap (page 6-9) 6. Fuel tank cap (page 3-10) 7. Front brake fluid reservoir (page 6-18) 8. Brake pedal (p...
Page 17: Description
Description 2-3 2 eau10430 controls and instruments 1. Clutch lever (page 3-9) 2. Left handlebar switches (page 3-7) 3. Multi-function meter unit (page 3-3) 4. Main switch/steering lock (page 3-1) 5. Right handlebar switches (page 3-7) 6. Throttle grip (page 6-13) 7. Brake lever (page 3-9) u1d711e0....
Page 18
Instrument and control functions 3-1 3 eau38390 main switch/steering lock the main switch/steering lock is locat- ed under the main switch/steering lock cover. To access the main switch/steering lock, slide the cover for- ward. The main switch/steering lock controls the ignition and lighting systems...
Page 19
Instrument and control functions 3-2 3 to unlock the steering push the key in, and then turn it to “off” while still pushing it. Warning ewa10060 never turn the key to “off” or “lock” while the vehicle is moving, otherwise the electrical systems will be switched off, which may result in loss of cont...
Page 20
Instrument and control functions 3-3 3 will flash eight times, and then go off for 3.0 seconds. If this occurs, have a yamaha dealer check the vehicle. Eau11530 engine trouble warning light “ ” this warning light comes on or flashes when an electrical circuit monitoring the engine is defective. When...
Page 21
Instrument and control functions 3-4 3 speedometer the speedometer shows the riding speed. When the key is turned to “on”, the speedometer needle will sweep once across the speed range and then return to zero in order to test the electrical cir- cuit. Tachometer the electric tachometer allows the ri...
Page 22
Instrument and control functions 3-5 3 fuel gauge the fuel gauge indicates the amount of fuel in the fuel tank. The needle moves towards “e” (empty) as the fuel level decreases. When the needle reaches “e”, approximately 3.0 l (0.79 us gal) (0.66 imp.Gal) remain in the fuel tank. If this occurs, ref...
Page 23
Instrument and control functions 3-6 3 to set the clock: 1. Push the “select” switch to change the display to the clock mode. 2. Push the “select” and “reset” switches together for at least two seconds. 3. When the hour digits start flashing, push the “reset” switch to set the hours. 4. Push the “se...
Page 24
Instrument and control functions 3-7 3 4. Adjust the multi-function meter unit panel brightness level by pushing the “reset” switch. 5. Push the “select” switch to se- lect the lcd. Item number “2” is displayed. Adjust the lcd brightness level by pushing the “reset” switch. 6. Push the “select” swit...
Page 25
Instrument and control functions 3-8 3 eau12400 dimmer switch “ / ” set this switch to “ ” for the high beam and to “ ” for the low beam. Eau12430 turn signal switch “ / ” to signal a right-hand turn, push this switch to “ ”. To signal a left-hand turn, push this switch to “ ”. When re- leased, the ...
Page 26
Instrument and control functions 3-9 3 eau12820 clutch lever the clutch lever is located at the left handlebar grip. To disengage the clutch, pull the lever toward the handle- bar grip. To engage the clutch, release the lever. The lever should be pulled rapidly and released slowly for smooth clutch ...
Page 27
Instrument and control functions 3-10 3 eau12941 brake pedal the brake pedal is on the right side of the motorcycle. To apply the rear brake, press down on the brake pedal. Eau13120 fuel tank cap to remove the fuel tank cap slide the lock cover open, insert the key into the lock, and then turn it 1/...
Page 28
Instrument and control functions 3-11 3 eau13211 fuel make sure that there is sufficient fuel in the tank. Fill the fuel tank to the bottom of the filler tube as shown. Warning ewa10880 ● do not overfill the fuel tank, oth- erwise it may overflow when the fuel warms up and expands. ● avoid spilling ...
Page 29
Instrument and control functions 3-12 3 eau13431 catalytic converter this model is equipped with a catalytic converter in the exhaust system. Warning ewa10860 the exhaust system is hot after op- eration. Make sure that the exhaust system has cooled down before do- ing any maintenance work. Caution: ...
Page 30
Instrument and control functions 3-13 3 eau38341 helmet holder the helmet holder is located under the rider seat. A helmet holding cable is provided beside the owner’s tool kit to secure a helmet to the helmet holder. To secure a helmet to the helmet holder 1. Remove the rider seat. (see page 3-12.)...
Page 31
Instrument and control functions 3-14 3 eau38401 adjusting the shock absorber assembly this shock absorber assembly is equipped with a spring preload adjust- ing nut. Caution: eca10100 never attempt to turn an adjusting mechanism beyond the maximum or minimum settings. Adjust the spring preload as f...
Page 32
Instrument and control functions 3-15 3 caution: eca10120 always tighten the locknut against the adjusting nut, and then tighten the locknut to the specified torque. Warning ewa10220 this shock absorber contains highly pressurized nitrogen gas. For prop- er handling, read and understand the followin...
Page 33
Instrument and control functions 3-16 3 eau15301 sidestand the sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. Note: the built-in sidestand switch is part of the ignition circuit cut-off system, which cuts the igni...
Page 34
Instrument and control functions 3-17 3 with the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? With the engine still runni...
Page 35
Instrument and control functions 3-18 3 eau38350 auxiliary dc connector a 12-v accessory connected to the auxiliary dc connector under the rider seat can be used when the key is in the “on” position. Caution: eca15310 the accessory connected to the auxiliary dc connector should not be used with the ...
Page 36: Pre-Operation Checks
Pre-operation checks 4-1 4 eau15591 the condition of a vehicle is the owner’s responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air p...
Page 37: Pre-Operation Checks
Pre-operation checks 4-2 4 eau15605 pre-operation check list item checks page fuel • check fuel level in fuel tank. • refuel if necessary. • check fuel line for leakage. 3-11 engine oil • check oil level in oil tank. • if necessary, add recommended oil to specified level. • check vehicle for oil lea...
Page 38: Pre-Operation Checks
Pre-operation checks 4-3 4 control cables • make sure that operation is smooth. • lubricate if necessary. 6-21 wheels and tires • check for damage. • check tire condition and tread depth. • check air pressure. • correct if necessary. 6-14, 6-16 brake and shift pedals • make sure that operation is sm...
Page 39
Operation and important riding points 5-1 5 eau15950 warning ewa10270 ● become thoroughly familiar with all operating controls and their functions before riding. Consult a yamaha dealer re- garding any control or function that you do not thoroughly un- derstand. ● never start the engine or oper- ate...
Page 40
Operation and important riding points 5-2 5 caution: eca11130 for maximum engine life, always warm the engine up before starting off. Never accelerate hard when the engine is cold! Note: the engine is warm when it quickly re- sponds to the throttle. Eau16671 shifting shifting gears lets you control ...
Page 41
Operation and important riding points 5-3 5 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (make sure not to shift the transmission into the neutral posi- tion.) ...
Page 42
Operation and important riding points 5-4 5 caution: eca10891 after 1000 km (600 mi) of operation, the engine oil and transfer case oil must be changed, and the oil filter cartridge or element replaced. 1600 km (1000 mi) and beyond the vehicle can now be operated nor- mally. Caution: eca10310 ● keep...
Page 43
Periodic maintenance and minor repair 6-1 6 eau17231 safety is an obligation of the owner. Pe- riodic inspection, adjustment and lubri- cation will keep your vehicle in the safest and most efficient condition pos- sible. The most important points of motorcycle inspection, adjustment, and lubrication...
Page 44
Periodic maintenance and minor repair 6-2 6 warning ewa10340 modifications not approved by yamaha may cause loss of perfor- mance, excessive emissions, and render the vehicle unsafe for use. Consult a yamaha dealer before at- tempting any changes. U1d711e0.Book page 2 tuesday, june 27, 2006 1:24 pm.
Page 45
Periodic maintenance and minor repair 6-3 6 eau17600 periodic maintenance chart for the emission control system * since these items require special tools, data and technical skills, have a yamaha dealer perform the service. No. Item routine initial odometer readings 600 mi (1000 km) or 1 month 4000 ...
Page 46
Periodic maintenance and minor repair 6-4 6 eau32183 general maintenance and lubrication chart no. Item routine initial odometer readings 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months 8000 mi (13000 km) or 12 months 12000 mi (19000 km) or 18 months 16000 mi (25000 km) or 24 months 20000 ...
Page 47
Periodic maintenance and minor repair 6-5 6 9 * swingarm pivot bearings • check bearing assemblies for looseness. √ √ √ √ √ 10 * drive belt • check belt tension. • adjust if necessary. √ every 2500 mi (4000 km) 11 * steering bearings • check bearing assemblies for looseness. • moderately repack with...
Page 48
Periodic maintenance and minor repair 6-6 6 * since these items require special tools, data and technical skills, have a yamaha dealer perform the service. 18 * shock absorber as- sembly • check operation and for oil leak- age. • replace if necessary. √ √ √ √ √ 19 * rear suspension link pivots • app...
Page 49
Periodic maintenance and minor repair 6-7 6 note: from 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. Eau38440 note: ● air filter • this model’s air filter is equipped with a disposable oil-coated paper element, which must not be cle...
Page 50
Periodic maintenance and minor repair 6-8 6 eau19642 checking the spark plugs the spark plugs are important engine components, which should be checked periodically, preferably by a yamaha dealer. Since heat and deposits will cause any spark plug to slowly erode, they should be removed and checked in...
Page 51
Periodic maintenance and minor repair 6-9 6 eau19681 canister (for california only) this model is equipped with a canister to prevent the discharging of fuel vapor into the atmosphere. Before operating this vehicle, make sure to check the fol- lowing: ● check each hose connection. ● check each hose ...
Page 52
Periodic maintenance and minor repair 6-10 6 5. If the engine oil is at or below the minimum level mark, add sufficient oil of the recommended type to raise it to the correct level. Note: when adding oil, be careful not to over- fill the engine oil tank; the oil level rises faster starting from the ...
Page 53
Periodic maintenance and minor repair 6-11 6 note: skip steps 7–9 if the oil filter cartridge is not being replaced. 7. Remove the oil filter cartridge with an oil filter wrench. Note: an oil filter wrench is available at a yamaha dealer. 8. Apply a thin coat of engine oil to the o-ring of the new o...
Page 54
Periodic maintenance and minor repair 6-12 6 11. Pour only 2.5 l (2.6 us qt) (2.2 imp.Qt) of the specified amount of recommended engine oil through the filler hole, insert the dipstick, and then tighten the oil filler cap. 12. Start the engine, rev it several times, and then turn it off. 13. Remove ...
Page 55
Periodic maintenance and minor repair 6-13 6 eau36762 air filter element the air filter element must be replaced at the intervals specified in the periodic maintenance and lubrication chart. Have a yamaha dealer replace the air filter element. Eau21381 checking the throttle cable free play the throt...
Page 56
Periodic maintenance and minor repair 6-14 6 eau21750 tires to maximize the performance, durabil- ity, and safe operation of your motor- cycle, note the following points regarding the specified tires. Tire air pressure the tire air pressure should be checked and, if necessary, adjusted before each r...
Page 57
Periodic maintenance and minor repair 6-15 6 always check the tires before operating the motorcycle. If a tire tread shows crosswise lines (minimum tread depth), if the tire has a nail or glass fragments in it, or if the sidewall is cracked, con- tact a yamaha dealer immediately and have the tire re...
Page 58
Periodic maintenance and minor repair 6-16 6 warning ewa10600 this motorcycle is fitted with super- high-speed tires. Note the following points in order to make the most ef- ficient use of these tires. ● use only the specified replace- ment tires. Other tires may run the danger of bursting at super ...
Page 59
Periodic maintenance and minor repair 6-17 6 any consequences caused by the use of items which have not been approved by yamaha. Eau22072 clutch lever since this model is equipped with a hy- draulic clutch, adjusting the clutch lever free play is not needed. However, it is necessary to check the clu...
Page 60
Periodic maintenance and minor repair 6-18 6 eau22390 checking the front and rear brake pads the front and rear brake pads must be checked for wear at the intervals spec- ified in the periodic maintenance and lubrication chart. Eau22430 front brake pads each front brake pad is provided with wear ind...
Page 61
Periodic maintenance and minor repair 6-19 6 clutch insufficient brake or clutch fluid may al- low air to enter the brake or clutch sys- tems, possibly causing them to become ineffective. Note: the rear brake fluid reservoir is located under the rider seat. (see page 3-12.) before riding, check that...
Page 62
Periodic maintenance and minor repair 6-20 6 eau22750 changing the brake and clutch fluids have a yamaha dealer change the brake and clutch fluids at the intervals specified in the note after the periodic maintenance and lubrication chart. In addition, have the oil seals of the brake and clutch mast...
Page 63
Periodic maintenance and minor repair 6-21 6 eau23091 checking and lubricating the cables the operation of all control cables and the condition of the cables should be checked before each ride, and the ca- bles and cable ends should be lubricat- ed if necessary. If a cable is damaged or does not mov...
Page 64
Periodic maintenance and minor repair 6-22 6 eau23140 checking and lubricating the brake and clutch levers brake lever clutch lever the operation of the brake and clutch levers should be checked before each ride, and the lever pivots should be lu- bricated if necessary. Recommended lubricant: lithiu...
Page 65
Periodic maintenance and minor repair 6-23 6 eau23200 checking and lubricating the sidestand the operation of the sidestand should be checked before each ride, and the sidestand pivot and metal-to-metal contact surfaces should be lubricated if necessary. Warning ewa10730 if the sidestand does not mo...
Page 66
Periodic maintenance and minor repair 6-24 6 caution: eca10590 if any damage is found or the front fork does not operate smoothly, have a yamaha dealer check or re- pair it. Eau23280 checking the steering worn or loose steering bearings may cause danger. Therefore, the operation of the steering must...
Page 67
Periodic maintenance and minor repair 6-25 6 eau23290 checking the wheel bearings the front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrica- tion chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a yamaha ...
Page 68
Periodic maintenance and minor repair 6-26 6 battery tends to discharge more quickly if the vehicle is equipped with optional electrical accessories. To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry...
Page 69
Periodic maintenance and minor repair 6-27 6 if a fuse is blown, replace it as follows. 1. Turn the key to “off” and turn off the electrical circuit in question. 2. Remove the blown fuse, and then install a new fuse of the specified amperage. Caution: eca10640 do not use a fuse of a higher amper- ag...
Page 70
Periodic maintenance and minor repair 6-28 6 eau38451 replacing a headlight bulb this model features a headlight equipped with two quartz bulbs. If the high beam or the low beam bulb burns out, replace it as follows. Removing the headlight unit 1. Remove the main switch/steering lock cover by removi...
Page 71
Periodic maintenance and minor repair 6-29 6 2. Disconnect the headlight coupler, and then unhook the headlight bulb holder. 3. Remove the defective bulb. Warning ewa10790 headlight bulbs get very hot. There- fore, keep flammable products away from a lit headlight bulb, and do not touch the bulb unt...
Page 72
Periodic maintenance and minor repair 6-30 6 warning ewa10790 headlight bulbs get very hot. There- fore, keep flammable products away from a lit headlight bulb, and do not touch the bulb until it has cooled down. 2. Install the bulb by turning it clock- wise. Caution: eca10650 take care not to damag...
Page 73
Periodic maintenance and minor repair 6-31 6 eau24180 tail/brake light this model is equipped with an led type of tail/brake light. If the tail/brake light does not come on, have a yamaha dealer check it. Eau38380 replacing a turn signal light bulb 1. Remove the turn signal light lens by removing th...
Page 74
Periodic maintenance and minor repair 6-32 6 eau24350 supporting the motorcycle since this model is not equipped with a centerstand, follow these precautions when removing the front and rear wheel or performing other maintenance requiring the motorcycle to stand up- right. Check that the motorcycle ...
Page 75
Periodic maintenance and minor repair 6-33 6 eau42600 troubleshooting chart warning ewa10840 keep away open flames and do not smoke while checking or working on the fuel system. Check the fuel level in the fuel tank. 1. Fuel there is enough fuel. There is no fuel. Check the compression. Supply fuel....
Page 76: Motorcycle Care and Storage
Motorcycle care and storage 7-1 7 eau37832 matte color caution caution: eca15192 some models are equipped with matte colored finished parts. Be sure to consult a yamaha dealer for advice on what products to use be- fore cleaning the vehicle. Using a brush, harsh chemical products or cleaning compoun...
Page 77: Motorcycle Care and Storage
Motorcycle care and storage 7-2 7 cleaning products, solvent or thinner, fuel (gasoline), rust re- movers or inhibitors, brake flu- id, antifreeze or electrolyte. ● do not use high-pressure wash- ers or steam-jet cleaners since they cause water seepage and deterioration in the following ar- eas: sea...
Page 78: Motorcycle Care and Storage
Motorcycle care and storage 7-3 7 5. Touch up minor paint damage caused by stones, etc. 6. Wax all painted and chrome-plat- ed surfaces. Avoid combination cleaner waxes, many of which contain abrasives that may mar the paint or protective finish. 7. Let the motorcycle dry completely before storing o...
Page 79: Motorcycle Care and Storage
Motorcycle care and storage 7-4 7 3. Perform the following steps to pro- tect the cylinders, piston rings, etc. From corrosion. A. Remove the spark plug caps and spark plugs. B. Pour a teaspoonful of engine oil into each spark plug bore. C. Install the spark plug caps onto the spark plugs, and then ...
Page 80: Specifications
Specifications 8-1 8 dimensions: overall length: 2580 mm (101.6 in) overall width: 1100 mm (43.3 in) overall height: 1100 mm (43.3 in) seat height: 735 mm (28.9 in) wheelbase: 1715 mm (67.5 in) ground clearance: 155 mm (6.10 in) minimum turning radius: 3480 mm (137.0 in) weight: with oil and fuel: 3...
Page 81: Specifications
Specifications 8-2 8 caster angle: 31.30 ° trail: 152.0 mm (5.98 in) front tire: type: tubeless size: 130/70r18m/c 63h manufacturer/model: dunlop/d251f manufacturer/model: bridgestone/g851 radial g rear tire: type: tubeless size: 190/60r17m/c 78h manufacturer/model: dunlop/d251 manufacturer/model: b...
Page 82: Specifications
Specifications 8-3 8 high beam headlight: 12 v, 55.0 w × 1 tail/brake light: led front turn signal/position light: 12 v, 23 w/8.0 w × 2 rear turn signal light: 12 v, 21.0 w × 2 license plate light: 12 v, 5.0 w meter lighting: led neutral indicator light: led high beam indicator light: led turn signa...
Page 83: Consumer Information
Consumer information 9-1 9 eau26351 identification numbers record the key identification number, vehicle identification number and mod- el label information in the spaces pro- vided below for assistance when ordering spare parts from a yamaha dealer or for reference in case the vehi- cle is stolen. ...
Page 84: Consumer Information
Consumer information 9-2 9 eau26470 model label the model label is affixed to the frame under the rider seat. (see page 3-12.) record the information on this label in the space provided. This information will be needed when ordering spare parts from a yamaha dealer. 1. Model label u1d711e0.Book page...
Page 85: Consumer Information
Consumer information 9-3 9 eau26550 reporting safety defects if you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the national highway traffic safety administration (nhtsa) in addition to notifying yamaha motor corporat...
Page 86: Consumer Information
Consumer information 9-4 9 eau26560 motorcycle noise regulation tampering with noise control system prohibited: federal law prohibits the following acts or the causing thereof: (1) the removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of an...
Page 87: Consumer Information
Consumer information 9-5 9 eau26632 maintenance record copies of work orders and/or receipts for parts purchased and installed on your vehicle will be required to document that maintenance has been completed in accordance with the emissions warranty. The chart below is printed only as a reminder tha...
Page 88: Consumer Information
Consumer information 9-6 9 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months maintenance interval date of service mileage servicing dealer name and address remarks u1d711e0.Book page 6 tuesday, june 27, 2006 1:24 pm.
Page 89: Consumer Information
Consumer information 9-7 9 eau26663 yamaha motor corporation, u.S.A. Street and enduro motorcycle limited warranty a) b) c) d) e) f) 1. 2. Yamaha motor corporation, u.S.A. Hereby warrants that new yamaha motorcycles will be free from defects in material and workmanship for the period of time stated ...
Page 90: Consumer Information
Consumer information 9-8 9 warranty questions and answers what costs are my responsibility during the warranty period? The customer’s responsibility includes all costs of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs...
Page 91: Consumer Information
Consumer information 9-9 9 eau26750 yamaha extended service (y.E.S.) keep your yamaha protected even after your warranty expires with genuine yamaha extended service (y.E.S.). Y.E.S. Is designed and administered by yamaha motor corporation to provide maximum owner satisfaction. You get uninterrupted...
Page 92: Consumer Information
Consumer information 9-10 9 we urge you to act now. You’ll get the excellent benefits of trip coverage right away, and you’ll rest easy knowing you’ll have strong factory-backed protection even after your yamaha limited warranty expires. A special note: if visiting your dealer isn’t convenient, cont...
Page 93: Index
Index a accessories and replacement parts ..... 6-16 air filter element.................................... 6-13 auxiliary dc connector ......................... 3-18 b battery .................................................. 6-25 brake and clutch fluid levels, checking ..............................
Page 94: Index
Index v valve clearance .................................... 6-13 vehicle identification number .................. 9-1 w warranty, extended................................. 9-9 warranty, limited ..................................... 9-7 wheel bearings, checking..................... 6-25 wheels ........
Page 95
Printed in japan 2006.07-1.8 ×1 cr (e) printed on recycled paper yamaha motor co., ltd..