1. DL manuals
  2. Yamaha
  3. Music Mixer
  4. SP1000
  5. Service Manual

Yamaha SP1000 Service Manual

Other manuals for SP1000: Owner's Manual, Owner's Manual
Manual is about: DIGITAL PRODUCTION CONSOLE/ PEAK METER BRIDGE/WOODEN SIDE PANELS

Summary of SP1000

  • Page 1

    Dm1000/mb1000/sp1000 1 service manual pa 011681 1.329k-6554 printed in japan ’03.03 hamamatsu, japan this document is printed on chlorine free (ecf) paper with soy ink. Digital production console/ peak meter bridge/wooden side panels /mb1000/sp1000 contents specifications ..............................

  • Page 2: Warning

    Dm1000/mb1000/sp1000 2 impor tant notice this manual has been provided for the use of authorized yamaha retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically yamaha products, are already known and under- stood by the ...

  • Page 3

    Dm1000/mb1000/sp1000 3 take care not to trap your fingers. Lithium battery handling this product uses a lithium battery for memory back-up. Warning : lithium batteries are dangerous because they can be exploded by improper handling. Observe the following pre- cautions when handling or replacing lith...

  • Page 4: Specifications

    Dm1000/mb1000/sp1000 4 specifications general spec number of scene memories 99 sampling frequency internal 44.1 khz, 48 khz, 88.2 khz, 96 khz external normal rate: 44.1 khz–10% to 48 khz+6% double rate: 88.2 khz–10% to 96 khz+6% signal delay fs=48 khz less than 1.6 ms ch input to omni out fs=96 khz ...

  • Page 5

    Dm1000/mb1000/sp1000 5 input channel ch1–48 input patch — phase normal/reverse gate-type* 3 on/off key in: 12 ch group (1–12, 13–24, 25–36, 37–48)/aux1–8 comp-type* 4 on/off key in: self /stereo link pre eq/pre fader/post fader attenuator –96.0 to +12.0 db (0.1 db step) eq 4-band peq (type1) * 5 on/...

  • Page 6

    Dm1000/mb1000/sp1000 6 stereo comp-type* 4 on/off pre eq/pre fader/post fader attenuator –96.0 to +12.0 db (0.1 db step) eq 4-band peq * 5 on/off on/off — fader 100 mm motorized balance 127 positions (left=1–63, center, right=1–63) delay 0–29100 samples metering displayed on lcd peak hold on/off 32-...

  • Page 7

    Dm1000/mb1000/sp1000 7 eq parameters gate parameters power requirements u.S./canada 120 v, 60 hz 135 w japan 100 v, 50/60 hz 135 w other 220–240 v, 50/60 hz 135 w dimensions (h x d x w) 200 x 585 x 436 mm (7.8" x 23.0" x 17.1") with mb1000 and sp1000 installed: 295 x 635 x 486 mm (11.6" x 25.0" x 19...

  • Page 8

    Dm1000/mb1000/sp1000 8 compressor threshold –54 db to 0 db (0.1 db step) ratio (x :1) x=1, 1.1, 1.3, 1.5, 1.7, 2, 2.5, 3, 3.5, 4, 5, 6, 8, 10, 20, ∞ (16 points) out gain 0 db to +18 db (0.1 db step) knee hard, 1, 2, 3, 4, 5 (6 step) attack 0 ms–120 ms (1 ms step) release 5 ms–42.3 s (160 points) @ 4...

  • Page 9

    Dm1000/mb1000/sp1000 9 in these specifications, when db represents a specific voltage, 0 db is referenced to 0.775 vrms. All input ad converters (input 1–16, omni input 1–4, talkback) are 24-bit linear, 128-times oversampling. (@fs=44.1, 48 khz) +48 v dc (phantom power) is supplied to ch input (1–16...

  • Page 10

    Dm1000/mb1000/sp1000 10 input format data length level connector 2tr in digital 1 aes/ebu 24-bit rs422 xlr-3-31 type (balanced)* 1 * 1. Xlr-3-31 type connectors are balanced (1=gnd, 2=hot, 3=cold). 2 iec-60958 24-bit 0.5 vpp/75 Ω phono output format data length level connector 2tr out digital 1 aes/...

  • Page 11

    Dm1000/mb1000/sp1000 11 each i/o slot accepts a digital interface card. Slot #1 has a serial interface. Maker model function input output * 1 * 1. Selectable from stereo/bus/aux/direct/ext insert/surround monitor/cr monitor. Details depend on each interface card. Format resolution frequency the numb...

  • Page 12

    Dm1000/mb1000/sp1000 12 remote port pin signal pin signal 1 gnd 6 rx+/gnd* 1 2 rx–/rx– * 1 1. Rs422 (for ad824)/sony 9 pin protocol (p2) 7 rts/rx+* 1 3 tx–/tx+ * 1 8 cts/tx– * 1 4 tx+/gnd* 1 9 gnd 5 n.C. Pin signal pin signal 1 gpo0 14 gpo1 2 gpo2 15 gpo3 3 gpo4 16 gpo5 4 gpo6 17 gpo7 5 gnd 18 gnd 6...

  • Page 13: Dimensions

    Dm1000/mb1000/sp1000 13 436(included screw heads) 430(not included screw heads) 112 32 565 585 156 280 200 374 101 154 87 154 355 dimensions top view side view front view units: mm （単位） 486 295 635 top view side view front view units: mm （単位） with mb1000 and sp1000 installed （mb1000/sp1000 取り付け時） （寸...

  • Page 14: Panel Layout

    Dm1000/mb1000/sp1000 14 control panel panel layout dm1000 aux pan displ ay assign encoder mode equalizer low high gain q frequency low mid high mid routing 1 2 3 4 5 6 7 8 stereo direct displ ay displ ay selected channel 16 bus 8 32 48 15 bus 7 31 47 14 bus 6 30 46 13 bus 5 29 45 12 bus 4 28 44 1 1 ...

  • Page 15

    15 dm1000/mb1000/sp1000 q [+48v on/off] switches 1-16 w [pad] switches 1-16 e [gain] controls 1-16 r [peak] indicators 1-16 t [signal] indicators 1-16 ad input section channel strip section q encoders 1-16 w [sel] buttons 1-16 e [solo] buttons 1-16 r [on] buttons 1-16 t channel faders 1-16 20db on o...

  • Page 16

    Dm1000/mb1000/sp1000 16 aux select section q [display] button w [aux 1]–[aux 8] buttons encoder mode section q [display] button w [pan] button e [aux] button r [assign] button fader mode section q [fader/aux] button w [fader] indicator e [aux] indicator stereo section q [auto] button w [sel] button ...

  • Page 17

    17 dm1000/mb1000/sp1000 display access section q [automix] button w [dio] button e [setup] button r [utility] button t [midi] button y [remote] button u [meter] button i [view] button o [pair/group] button !0 [ Ø /insert/delay] button !1 [input patch] button !2 [output patch] button !3 [pan/surround...

  • Page 18

    Dm1000/mb1000/sp1000 18 selected channel section q routing [display] button w routing [1]–[8] buttons e routing [stereo] button r routing [direct] button t equalizer [display] button y equalizer [high] button u equalizer [high-mid] button i equalizer [low-mid] button o equalizer [low] button !0 equa...

  • Page 19

    19 dm1000/mb1000/sp1000 user defined keys section q [display] button w [1]-[12] buttons q parameter wheel w [enter] button e [dec] & [inc] buttons r left, right, up, down ([ ]/[ ]/[ ]/[ ]) cursor buttons data entry section headphones & talkback section q [talkback level] control w talkback mic e [ph...

  • Page 20

    Dm1000/mb1000/sp1000 20 input omni in 2 3 4 5 6 7 8 1 10 1 1 12 13 14 15 9 2 1 1 3 4 5 6 7 8 1 10 1 1 12 9 2 1 3 16 4 word clock in out control in out to host usb remote midi smpte in coaxial aes/ebu coaxial aes/ebu 2 2 1 2tr in digital meter 1 slot slot input omni in 2 3 4 5 6 7 8 1 10 1 1 12 13 14...

  • Page 21

    21 dm1000/mb1000/sp1000 slot section q [slot 1] & [slot 2] digital i/o & control section q [meter] connector w [control] connector e [smpte time code input] connector r [remote] connector t [midi in & out] ports y [to host usb] port u [word clock out] connector i [word clock in] connector o [2tr out...

  • Page 22

    Dm1000/mb1000/sp1000 22 q channel indicators w [input metering position] indicators e [output metering position] indicators r [peak hold] button t [time code] display y [1-16] / [17-32] / [33-48] / [remote 1] / [remote 2] / [master] buttons u level meters i bus meters controls mb1000 1- 1 6 master 1...

  • Page 23: Circuit Board Layout

    Dm1000/mb1000/sp1000 23 power transformer （電源トランス） dca 1/5 dca 3/5 dca 4/5 dca 2/5 ac jk2 opt main opt dcd dca 4/5 dca 2/5 dca 3/5 jk1 bottom assembly dm1000 （ボトム ass'y） circuit board layout （ユニットレイアウト）.

  • Page 24

    Dm1000/mb1000/sp1000 24 power transformer （電源トランス） dca 1/5 ac jk2 main jk2 jk1 ac dcd jk1.

  • Page 25

    Dm1000/mb1000/sp1000 25 haad 1/2 haad 2/2 ada xlr xlr rear assembly u（リア上 ass'y）.

  • Page 26

    Dm1000/mb1000/sp1000 26 control panel asembly pn1 (1/4) (3/4) (2/4) (4/4) pn1 pn2 pn1 pn1 lcd fd （コンパネ ass y）.

  • Page 27

    Dm1000/mb1000/sp1000 27 mb1000 pn main rear panel assembly（リアパネル ass'y） front panel assembly（フロントパネルass'y）.

  • Page 28: Disassembly Procedure

    Dm1000/mb1000/sp1000 28 disassembly procedure [a]: bind head screw pw 4.0x20 mfzn2bl (va314000) fig.1 photo.1 photo.2 [b]: bind head screw a4.0x12 mfzn2bl (vp156900) [c]: bind head screw a4.0x12 mfzn2bl (vp156900) note: take care not to trap your fingers. After replacing the circuit board or fader o...

  • Page 29

    29 dm1000/mb1000/sp1000 fig.2 [40]: bind head tapping screw-b 4.0x8 mfzn2bl (eg340190) [60a]: bind head tapping screw-b 4.0x8 mfzn2bl (eg340190) [70a]: bind head tapping screw-b 3.0x6 mfzn2bl (ep600230) photo.3-1 [60a] [60a] [40a] [40b] [70a] [40b] [70a] [40a] side panel l （サイドパネルl) control panel as...

  • Page 30

    Dm1000/mb1000/sp1000 30 bottom assembly section 5. Dcd circuit board (time required: about 8 minutes) 5-1. Remove the sp1000. (see procedure 1.) 5-2. Remove the mb1000. (see procedure 2.) 5-3. Fasten the control panel assembly. (see procedure 3.) 5-4. Remove the four (4) screws marked [410] and the ...

  • Page 31

    31 dm1000/mb1000/sp1000 9. Main circuit board (time required: about 12 minutes) 9-1. Remove the sp1000. (see procedure 1.) 9-2. Remove the mb1000. (see procedure 2.) 9-3. Fasten the control panel assembly. (see procedure 3.) 9-4. Remove the rear assembly u. (see procedure 4-5.) 9-5. Remove the opt c...

  • Page 32

    Dm1000/mb1000/sp1000 32 dca 1/5 dca 4/5 dca 4/5 [411] [341] [335] [230] dcd dca 1/5 1/5 1/5 dcd [410] [110a] [350a] dca 2/5 dca 2/5 dca 3/5 dca 3/5 opt opt opt opt angle （opt金具） bottom stay （ボトムステイ） bottom stay （ボトムステイ） heat sink （ヒートシンク） dcaic angle （dcaicアングル） if plate （ifプレート） [110a] [12a] [12b] ...

  • Page 33

    33 dm1000/mb1000/sp1000 [145] [140] [150] [140] [145] [d] [e] main jk2 jk1 [12c] [130a] [12c] [160] battery vn103500 vn103600(battery holder for vn103500) notice for back-up battery removal push the battery as shown in figure, then the battery will pop up. Druk de batterij naar beneden zoals aangeve...

  • Page 34

    Dm1000/mb1000/sp1000 34 13. Ac shield plate (time required: about 10 minutes) 13-1. Remove the sp1000. (see procedure 1.) 13-2. Remove the mb1000. (see procedure 2.) 13-3. Fasten the control panel assembly. (see procedure 3.) 13-4. Fasten the rear assembly u. (see procedure 4-4.) 13-5. Remove the he...

  • Page 35

    35 dm1000/mb1000/sp1000 locking card spacer [255] [290a] power switch knob （pswノブ） ac （ロッキングカード スペーサ） [290b] ferrite core （フェライトコア） [265]: cord holder (underneath the ferrite core) （インシュロックタイ （フェライトコアの下側） ） photo.8 (写真8) photo.9 (写真9) photo.10 (写真10) [255]: bind head tapping screw-b 3.0x6 mfzn2bl (e...

  • Page 36

    Dm1000/mb1000/sp1000 36 ada [30] [30]: bind head tapping screw-b 3.0x8 mfzn2bl (ep600190) fig.5 (図5) (＋バインドＢタイト) rear assembly u section 17. Ada circuit board (time required: about 10 minutes) 17-1. Remove the sp1000. (see procedure 1.) 17-2. Remove the mb1000. (see procedure 2.) 17-3. Fasten the co...

  • Page 37

    37 dm1000/mb1000/sp1000 xlr xlr [120a] [120a] [120a] [120a] [110b] [110b] [110b] [110b] [110b] [130b] [130b] [130b] [130b] [110b] [130b] [120a] [120a] [120a] [120a] [120a] [120a] [120a] [110b] [240a] [200] [190] headt sink （ヒートシンク） insulation sheet （放熱シート） knob x18 （ノブ） knob x18 （ノブ） shield fingers ...

  • Page 38

    Dm1000/mb1000/sp1000 38 19. Heat sink (time required: about 8 minutes) 19-1. Remove the sp1000. (see procedure 1.) 19-2. Remove the mb1000. (see procedure 2.) 19-3. Fasten the control panel assembly. (see procedure 3.) 19-4. Remove the two (2) screws marked [70a]. (fig.2) 19-5. Remove the four (4) s...

  • Page 39

    39 dm1000/mb1000/sp1000 control panel assembly section when removing the circuit board, if it is hard to handle while the control panel assembly is fixed slantwise at the stay, open it widely at 180 ° for the work. 23. Fd circuit board (time required: about 9 minutes) 23-1. Remove the sp1000. (see p...

  • Page 40

    Dm1000/mb1000/sp1000 40 24. Lcd circuit board (time required: about 8 minutes) 24-1. Remove the sp1000. (see procedure 1.) 24-2. Remove the mb1000. (see procedure 2.) 24-3. Fasten the control panel assembly. (see procedure 3.) 24-4. Remove the two (2) screws marked [120b] and the two (2) screws mark...

  • Page 41

    41 dm1000/mb1000/sp1000 fig.8 (図8) fader knob x17 （フェーダーノブ） encoder knob （エンコーダーツマミ） [310]: encoder knob x16 （エンコーダーノブ） [300]: encoder knob [350b]: （エンコーダーノブ） knob （ノブ）.

  • Page 42

    Dm1000/mb1000/sp1000 42 lcd fd pn2 pn1 (1/4) (1/4) (4/4 encoder) pn1 pn1 (2/4 meter) pn1 (3/4 joystick) [260] [240b] [218] [220a] [220b] [220b] [220b] [220b] [120d] [220a] cord holder （インシュロックタイ） cord holder （インシュロックタイ） cord holder （インシュロックタイ） cord holder （インシュロックタイ） insulation sheet （絶縁シート） hexagon...

  • Page 43

    43 dm1000/mb1000/sp1000 lcd lcd shield plate （lcdシールド板） lcd （液晶ディスプレイ） lcd shield film （lcdシールドフィルム） [120b] [170] [80] [80] [80] [120c] [f] (four (4) places) pn1 2/4 photo.15 (写真15) photo.16 (写真16) photo.17 (写真17) [120b]: bind head tapping screw-b 3.0x8 mfzn2bl (ep600190) [170]: bind head tapping sc...

  • Page 44

    Dm1000/mb1000/sp1000 44 disassembling the mb1000 28. Rear panel (time required: about 3 minutes) 28-1. Remove the mb1000. (see procedure 2.) 28-2. Remove the sixteen (16) screws marked [40c]. The rear panel can then be removed from the front panel. (fig.10) 29. Pn circuit board (time required: about...

  • Page 45

    45 dm1000/mb1000/sp1000 [40c]: bind head tapping screw-b 3.0x8 mfzn2bl (ep600190) fig.10 (図10) (＋バインドＢタイト) [70b] [50] [70c] dsub cable （dsubケーブル） bushing （ワンタッチブッシュ） main pn meter angle r （メーターアングルr） meter angle l （メーターアングルl） cable holder （ケーブルホルダー） front panel （フロントパネル） rear panel （リアパネル） [40c] [40...

  • Page 46: Installing An Optional Card

    Dm1000/mb1000/sp1000 46 installing an optional card wo rd clo ck in ou t co ntr ol in ou t to h ost usb rem ote mid i sm pte in co axia l aes /eb u co axia l aes /eb u 2 2 1 2tr in dig ital me ter pow er on off 1 slo t slo t inp ut om ni in 2 3 4 5 6 7 8 1 10 11 12 13 14 5 9 2 3 4 5 6 7 8 1 10 11 12...

  • Page 47: Lsi Pin Description

    47 dm1000/mb1000/sp1000 lsi pin description m37641m8-141fp (x2485200) cpu (usb 32k) .......................................................................... 47 hd6417709sf133 (x2081a00) cpu (sh-3) ................................................................................. 48 sh7042 (x4409a00...

  • Page 48

    Dm1000/mb1000/sp1000 48 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78...

  • Page 49

    49 dm1000/mb1000/sp1000 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 pe14 pe15 vss a0 a1 a2 a3 a4 a5 a6 a7 a8 a9 a10 a11 a12 a13 a14 a...

  • Page 50

    Dm1000/mb1000/sp1000 50 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 d5 d6 d7 /irq0 /irq1 vss /irq2 irq3 /rd /wr /ce /astb testsio rx0 tx0 rx1 tx1 vss vdd rx2 tx2/bo2 rx30 tx30 tx31 i/o i/o i/o i/o i/o i/o i/o i i i i i i o i o i ...

  • Page 51

    51 dm1000/mb1000/sp1000 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78...

  • Page 52

    Dm1000/mb1000/sp1000 52 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78...

  • Page 53

    53 dm1000/mb1000/sp1000 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 v dd xtst v ss wt...

  • Page 54

    Dm1000/mb1000/sp1000 54 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 daux hdlt dout vfl opt sync mcc wc mcb mca sksy xi xo p256 lock vss tc dim1 dim0 dom1 dom0 km1 i o o o o o o o o o i i o o o o i i i i i auxiliary input for audio data...

  • Page 55

    55 dm1000/mb1000/sp1000 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 corev dd /wait db15 db14 db13 db12 db11 db10 db9 iov dd db8 db7 db6 db5 db4 db3 db2 db1 db0 v ss corev dd gpio0 f...

  • Page 56

    Dm1000/mb1000/sp1000 56 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 intr reset frame click ltcin- ltcin+ ltcout lfc xtal2 xtal1 avdd avss cout yout c2 y2 c1 y1 sthresh cthresh dthresh rxd o i i i i i o i o i - - o o i i i i i i i i int...

  • Page 57

    57 dm1000/mb1000/sp1000 mb1000 pin no. I/o function name pin no. I/o function name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 pe14 pe15 vss a0 a1 a2 a3 a4 a5 a6 a7 a8 a9 a10 a11 a12 a1...

  • Page 58: Ic Block Diagram

    Dm1000/mb1000/sp1000 58 ic block diagram tc74vhc00f (xt229a00) main: ic138 sn74hc00nsr (xe165a00) fd: ic106 quad 2 input nand hd74lv02afpel (is000200) main: ic020-022 quad 2 input nor tc74vhc04f-el (xm332a00) main: ic131 hex inverter tc74vhc11f (el) (xt812a00) main: ic029 triple 3 input and tc74vhc1...

  • Page 59

    59 dm1000/mb1000/sp1000 tc74vhc138f (xt015a00) fd: ic301, 401, 501 3 to 8 demultiplexer tc74vhc157f (el) (xt475a00) main: ic503-506 quad 2 to 1 multiplexer tc74hc238af (xt163a00) pn1: ic101 3 to 8 line decoder hd74hc123ap (ir012310) dca: ic350 dual retriggerable single shot 1a 1b 1 1q 2q 2 cext 2 re...

  • Page 60

    Dm1000/mb1000/sp1000 60 74vhc245sjx (xy874a00) ada: icic955, 956 haad: ic952, 953 tc74hc245af (xs720a00) fd: ic404, 405, 408 tc74vhc245f (xt487a00) main: ic102-106, 113-116, 132, 133, 314, 901 jk1: ic302, 402-404 tc74vhct245af (xv242a00) main: ic014, 028, 109, 110, 140, 141, 147, 653, 801-803 octal ...

  • Page 61

    61 dm1000/mb1000/sp1000 sn75c1168nsr (xu073a00) jk1: ic203 jk2: ic701 line driver/receiver ds26c32atmx (xu815a00) jk1: ic001 quad differential line receiver mc26ls30dr2 (xl334a00) jk1: ic002 line driver 1 2 3 4 5 6 7 vcc input a input b/ enable ab gnd input c/ enable cd input d v ee mode 16 15 14 13...

  • Page 62

    Dm1000/mb1000/sp1000 62 cy2305 (xy937a00) main: ic003 clock buffer upc319g2 (ig156700) jk1: ic252 voltage comparator njm2904v (te1) (xr532a00) fd: ic105 main: ic015 dual operational amplifier njm4556al (xp844a00) ada: ic155, 156, 255, 256, 355, 356, 455, 456, 555, 556, 655, 656 haad: ic004 dual oper...

  • Page 63

    63 dm1000/mb1000/sp1000 tlc2932ipwr (xv064a00) main: ic143 pll 1 2 3 4 5 6 7 logic v dd select vco out f in -a f in -b pfd out logic gnd 14 13 12 11 10 9 8 vco v dd r bias v coin vco gnd vco inhbit pfd inhibit nc 7 logic gnd 4 f in -a 6 pfd out 12 v coin 13 r bias 11 vco gnd 8 nc 1 logic v dd 5 f in...

  • Page 64

    Dm1000/mb1000/sp1000 64 tc74hc238af (xt163a00) main: ic109 3 to 8 line decoder tc74hc245af (xs720a00) main: ic108 pn: ic201 octal 3-state bus transceiver sn75c1168n sr (xu073a00) main: ic103 line driver/receiver td62m8600f (xv014a00) pn: ic202, 206 source driver tb62705cf (el) (xv013a00) pn: ic203-2...

  • Page 65: Circuit Boards

    65 dm1000/mb1000/sp1000 note: see parts list for details of circuit board component parts. Dccom (ac) circuit board (x3434c0) ........................................ 66 dccom (dca 1/5) circuit board (x3434c0) ............................... 67 dccom (dca 2/5) circuit board (x3434c0) ..................

  • Page 66

    Dm1000/mb1000/sp1000 66 component side dccom (ac) circuit board component side to ac inlet assembly to bottom chassis (for ground) power on/off to power transformer to dca 1/5-ic301 to dca 1/5-ic302 to dca 1/5-ic303 dccom (dca 2/5) circuit board dccom (dca 3/5) circuit board component side （部品側） com...

  • Page 67

    67 dm1000/mb1000/sp1000 to dca 4/5 -cn403 to dca 3/5 -cn402 to dca 2/5 -cn401 to jk1-cn653 to opt -cn807 to haad 1/2 -cn952 to power transformer to fd-cn202 to ada -cn954 dccom (dca 1/5) circuit board component side （部品側） 2nap-v990110-2 2 (j, u, v models) 2nap-v990110-2a 2 (h, b, w kmodels).

  • Page 68

    Dm1000/mb1000/sp1000 68 dcd circuit board to fd-cn201 to pn1 (1/4)-cn105 to main-cn006 to power transformer not installed component side （部品側） 2nap-v990130-2 1.

  • Page 69

    69 dm1000/mb1000/sp1000 pattern side （パターン側） dcd circuit board 2nap-v990130-2 1.

  • Page 70

    Dm1000/mb1000/sp1000 70 a a' to main-cn003 to pn1 (1/4)-cn101 not installed 1 fader 2 fader 3 fader 4 fader 5 fader 6 fader 7 fader 8 fader 9 fader to pn1 (1/4)-cn102 fd circuit board 2nap-v989990-2 4.

  • Page 71

    71 dm1000/mb1000/sp1000 a a' fader 10 fader 11 fader 12 fader 13 fader 14 fader 15 fader 16 fader stereo fader to pn1 (1/4)-cn103 to dcd-cn202 to dca 1/5-cn306 to pn1 (1/4)-cn104 component side （部品側） 2nap-v989990-2 4.

  • Page 72

    Dm1000/mb1000/sp1000 72 b b' to pn1 (1/4)-cn103 to dcd-cn202 to dca 1/5-cn306 to pn1 (1/4)-cn104 fd circuit board 2nap-v989990-3 4.

  • Page 73

    73 dm1000/mb1000/sp1000 b b' to main-cn003 to pn1 (1/4)-cn101 not installed to pn1 (1/4)-cn102 pattern side （パターン側） 2nap-v989990-3 4.

  • Page 74

    Dm1000/mb1000/sp1000 74 c c' to main-cn901 to xlr-cn151 to xlr-cn551 d d' hacom (ada) circuit board hacom (ada) circuit board 2nap-v989910-2 1 2nap-v989910-3 1.

  • Page 75

    75 dm1000/mb1000/sp1000 c c' to dca 1/5-cn305 to xlr-cn951 to xlr-cnd51 d d' component side （部品側） pattern side （パターン側） 2nap-v989910-2 1 2nap-v989910-3 1.

  • Page 76

    Dm1000/mb1000/sp1000 76 e e' to xlr-cn101 phones gain 1 gain 2 gain 3 gain 4 gain 5 gain 6 gain 7 gain 8 gain 9 gain 10 gain 11 pad 20db 1 pad 20db 2 pad 20db 3 pad 20db 4 pad 20db 5 pad 20db 6 pad 20db 7 pad 20db 8 pad 20db 9 pad 20db 10 pad 20db to haad 1/2-cn003 to main-cn902 to xlr-cn501 hacom (...

  • Page 77

    77 dm1000/mb1000/sp1000 e e' gain 10 gain 11 gain 12 gain 13 gain 14 gain 15 gain 16 talkback level phones level 20db 10 pad 20db 11 pad 20db 12 pad 20db 13 pad 20db 14 pad 20db 15 pad 20db 16 to xlr-cn901 to xlr-cnd01 to dca 1/5-cn304 to haad 2/2 -cn003 component side （部品側） 2nap-v989910-2 1.

  • Page 78

    Dm1000/mb1000/sp1000 78 f f' hacom (haad 1/2) circuit board hacom (haad 2/2) circuit board pattern side （パターン側） 2nap-v989910-3 1.

  • Page 79

    79 dm1000/mb1000/sp1000 f f' pattern side （パターン側） 2nap-v989910-3 1.

  • Page 80

    Dm1000/mb1000/sp1000 80 g g' to dca 1/5-cn307 control smpte in remote midi in/out to main-cn651 g g' to host usb out word clock 2 coax 2tr in/out digital 1 aes/ebu 1 aes/ebu in to main-cn652 to main-cn701 meter jkcom (jk1) circuit board jkcom (jk2) circuit board component side （部品側） component side （...

  • Page 81

    81 dm1000/mb1000/sp1000 h h' h h' jkcom (jk1) circuit board jkcom (jk2) circuit board pattern side （パターン側） pattern side （パターン側） 2nap-v989800-2.

  • Page 82

    Dm1000/mb1000/sp1000 82 i i' to main-cn801 slot1 to main-cn802 i i' slot2 to main-cn803 to main-cn804 to dca 1/5-cn302 jkcom (opt) circuit board component side （部品側） 2nap-v989800-2.

  • Page 83

    83 dm1000/mb1000/sp1000 j j' j j' jkcom (opt) circuit board pattern side （パターン側） 2nap-v989800-2.

  • Page 84

    Dm1000/mb1000/sp1000 84 battery vn103500 vn103600(battery holder for vn103500) notice for back-up battery removal push the battery as shown in figure, then the battery will pop up. Druk de batterij naar beneden zoals aangeven in de tekening de batterij springt dan naar voren. Battery battery holder ...

  • Page 85

    85 dm1000/mb1000/sp1000 k k' to opt-cn804 to opt-cn803 to jk2 -cn701 to jk1 -cn651 to jk1 -cn652 to opt -cn801 to opt-cn802 component side （部品側） 2nap-v989750-2 3.

  • Page 86

    Dm1000/mb1000/sp1000 86 l l' main circuit board 2nap-v989750-2 3.

  • Page 87

    87 dm1000/mb1000/sp1000 l l' component side （部品側） 2 layer （2層） 2nap-v989750-2 3.

  • Page 88

    Dm1000/mb1000/sp1000 88 m m' main circuit board 2nap-v989750-2 3.

  • Page 89

    89 dm1000/mb1000/sp1000 m m' component side （部品側） 5 layer （5層） 2nap-v989750-2 3.

  • Page 90

    Dm1000/mb1000/sp1000 90 n n' main circuit board 2nap-v989750-3 2.

  • Page 91

    91 dm1000/mb1000/sp1000 n n' pattern side （パターン側） 2nap-v989750-3 2.

  • Page 92

    Dm1000/mb1000/sp1000 92 o o' to fd-cn403 to fd-cn404 pncom (pn1 (1/4)) circuit board 2nap-v990000-2 1.

  • Page 93

    93 dm1000/mb1000/sp1000 o o' to fd-cn401 to pn1 (2/4)-cn401 to pn1 (4/4) -cn111 to dcd -cn204 to pn2 -cn301 to fd-cn402 to pn1 (3/4)-cn109 component side （部品側） 2nap-v990000-2 1.

  • Page 94

    Dm1000/mb1000/sp1000 94 p p' pncom (pn1 (1/4)) circuit board 2nap-v990000-2 1.

  • Page 95

    95 dm1000/mb1000/sp1000 p p' pattern side （パターン側） 2nap-v990000-2 1.

  • Page 96

    Dm1000/mb1000/sp1000 96 to pn1 (1/4)-cn106 to lcd-cn503 to pn1 (1/4)-cn107 to pn1 (1/4)-cn108 joy stick lcd contrast parameter wheel to pn1 (1/4)-cn110 pncom (pn1 (2/4)) circuit board component side （部品側） pattern side （パターン側） component side （部品側） pattern side （パターン側） pncom (pn2) circuit board compon...

  • Page 97

    97 dm1000/mb1000/sp1000 to lcd module to pn1 (2/4)-cn402 to main-cn005 to lcd module pattern side （パターン側） pncom (lcd) circuit board component side （部品側） 2nap-v990000-2 1.

  • Page 98

    Dm1000/mb1000/sp1000 98 q q' to ada-cn752 to haad 1/2-cnd02 +48v on/off 16 +48v on/off 15 +48v on/off 14 +48v on/off 13 +48v on/off 12 +48v on/off 11 +48v on/off 10 +48v on/off 9 input 9 input 10 input 11 input 12 input 13 input 14 input 15 input 16 omni out 9 omni out 10 omni out 11 omni out 12 omn...

  • Page 99

    99 dm1000/mb1000/sp1000 main circuit board r r' to pn-cn201 not installed r r' to meter (dm1000) component side （部品側） 2nap-v990400-2 1.

  • Page 100

    Dm1000/mb1000/sp1000 100 s s' s s' main circuit board pattern side （パターン側） 2nap-v990400-2 1.

  • Page 101

    101 dm1000/mb1000/sp1000 t t' to main-cn102 t t' pn circuit board component side （部品側） 2nap-v990410-2 1.

  • Page 102

    Dm1000/mb1000/sp1000 102 u u' u u' pattern side （パターン側） pn circuit board 2nap-v990410-2 1.

  • Page 103: Inspections

    103 dm1000/mb1000/sp1000 inspections perform the check of dm1000. 1. Preparations 1-1. Parameters the parameters are as follows unless otherwise specified. Set word clock int to 96 khz. Only the channel being measured is on. Pan: center gain : min pad : on fader : nominal (0 db) 0 dbu = 0.775vrms 0 ...

  • Page 104

    Dm1000/mb1000/sp1000 104 e residual noise (omni out 1~12) parameter switch bus out off. R omni out 1~12 level difference the range of difference in the gain measured with q and w is regulated as follows. T crosstalk between odd channels and even channels parameter the measurement channel must be ass...

  • Page 105

    105 dm1000/mb1000/sp1000 e distortion ratio (ch 1~16) r noise level (ch 1~16) parameter short the ch in being measured with 150 Ω . However, if the permitted range above is not met, ein measurement value (gain at 1 khz) must be -128. T level difference (ch 1~16) the range of difference in the gain m...

  • Page 106

    Dm1000/mb1000/sp1000 106 3-3. Omni in 1~4 parameters inspect with omni out 1. Q distortion ratio (omni in 1~4) w residual noise (omni in 1~4) parameter short the omni in being measured with 150 Ω . 3-4. Ch in 1~16 parameters inspect with omni out 1. Gain min (ch1~16), pad on (ch1~16). Q distortion r...

  • Page 107

    107 dm1000/mb1000/sp1000 4-3. Word clock in, 2tr digital in 1 and 2 pll operation range parameters use parameter system two. For distortion measurement, select bw: 80khz. Inspect with omni out 1 and 2. Select the word clock as follows. Word clock in inspection: wc in 2tr digital in 1 inspection: 2tr...

  • Page 108

    Dm1000/mb1000/sp1000 108 judgment standard 1: the effect sounds must be output. Judgment standard 2: the output must not include any noise. In the same manner, recall and inspect scenes 2 through 16. The effect functions for scenes 2 through 16 work as follows. Scenes 2: symphonic scenes 3: hq pitch...

  • Page 109: 検査

    109 dm1000/mb1000/sp1000 検査 ※ dm1000 の検査を行います。 1. 準備 1-1. 条件 ◇特に指定しないときは以下の条件とします。 ・word clock は int96khz にします。 ・測定 ch のみ on とします。 pan: センター gain: min pad: on fader: nominal（0db） ・0dbu ＝ 0.775vrms ・0dbv ＝ 1vrms ＝ 2.2dbu ・0dbfs ＝ 0 デシベル・フルスケール ・発振器の出力インピーダンスは 150 Ωとします。 ・オシロスコープ、レベル計等の入力インピーダン スは 100...

  • Page 110

    Dm1000/mb1000/sp1000 110 ③残留ノイズ（omni out 1 〜 12） 条件 bus out を off にします。 ④ omni out 1 〜 12 間のレベル差 ①，②で測定した利得の差の範囲を以下の様に規定 します。 ⑤奇数チャンネル／偶数チャンネル間のクロストーク 条件 測定 ch は output patch で bus 2ch を アサインします。 偶数側も同様であることを確認します。 ⑥最大出力（omni out 1 〜 12） 2-2. Phones out l/r 条件 ch1 から入力します。 phones level は max。 ①利得（l/...

  • Page 111

    111 dm1000/mb1000/sp1000 ③歪率（ch1 〜 16） ④ノイズレベル（ch1 〜 16） 条件 測定するch in を 150 Ωでショートします。 ただし上記許容範囲に入らない場合は ein 測定値−（1khz における利得）≦− 128 であることを確認します。 ⑤レベル差（ch1 〜 16） ①で測定した利得の差の範囲を以下の様に規定します。 b. Gain min、pad on ①利得（ch1 〜 16） ②歪率（ch1 〜 16） ③ノイズレベル（ch1 〜 16） 条件 測定するch in を 150 Ωでショートします。 ④奇数チャンネル／偶数チャンネル間...

  • Page 112

    Dm1000/mb1000/sp1000 112 3-3. Omni in 1 〜 4 条件 omni out 1 で検査します。 ①歪率（omni in 1 〜 4） ②残留ノイズ（omni in 1 〜 4） 条件 測定するomni inを150Ωでショートします。 3-4. Ch in 1 〜 16 条件 omni out 1 で検査します。 gain min（ch1 〜 16） 、pad on（ch1 〜 16） 。 ①歪率（ch1 〜 16） ②ノイズレベル（ch1 〜 16） 条件 測定する ch inを 150 Ωでショートします。 4. Digital in/out の検査 4...

  • Page 113

    113 dm1000/mb1000/sp1000 4-3. Word clock in, 2tr digital in 1, 2 の pll 動作範囲 条件 system two を使用します。 歪み測定時、bw: 80khz を選択します。 omni out 1、2 で検査します。 word clock は以下を選択します。 word clock in の検査時: wc in 2tr digital in 1 の検査時: 2tr d1 2tr digital in 2 の検査時: 2tr d2 ch1 から入力します。 a. 96khz ＋ 6％（101.76khz） 条件 word clo...

  • Page 114

    Dm1000/mb1000/sp1000 114 シーン 11：hq pitch シーン 12：dynamic filter シーン 13：reverb シーン 14：symphonic シーン 15：hq pitch シーン 16：dynamic filter 7. プログラムの書き込み、初期化 7-1. プログラムのバージョンの確認方法 dm1000 の[sel]キーの ch5、ch9、ch6、ch3 を順 に押した後、 [store]キーを押すとlcd画面に本体プ ログラムおよびブートプログラムのバージョンが表示 されます。 7-2. プログラムの書き込み方法 以下の手順に従い、本体プロ...

  • Page 115

    Dm1000/mb1000/sp1000 115 (fig. 3) example b of individual check screen (when checking each one of multiple items automatically or visually) 1)after starting the check, the ok/ng selection items are displayed. Check the actions and results and then select ok/ng. Use the [ ] and [ ] keys to select the...

  • Page 116

    Dm1000/mb1000/sp1000 116 1-1. Pllp2 test contents: read/write the reg. (00, 0f, 10, 16) of the pllp2 to compare and check. Example of execution screen 1-2. Battery test contents: the voltage of the backup battery by a/d is measured and judgment is automatic. Example of execution screen 1-4. Dsp6 and...

  • Page 117

    Dm1000/mb1000/sp1000 117 1-13. Word clock test contents: word clock out → in is counted by pllp2 and automatically checked (fs = 44.1/48/88.2/96 khz). For the pll lock check, read the unlock signal and check when the clock is stable after the fs change (after about 200 ms). To confirm the unlock, di...

  • Page 118

    Dm1000/mb1000/sp1000 118 1-24. Panel sw test contents: check that all of the switches on the panel respond when pressed in the specified order (automatic judgement). Example of execution screen 1) see sw operation fig. 1 and 2 in “2. Supplement” for operation order. 2) when the check starts, the lcd...

  • Page 119

    Dm1000/mb1000/sp1000 119 2) explanation of the automatic judgment display of the fader up/down “ng: ch 1, 1020, (990...1023), 980” 1020: specified stop value (displayed in 1024 resolution) (990...1023): certified range when the fader detects the stop position using the built-in a/d (displayed in 102...

  • Page 120

    Dm1000/mb1000/sp1000 120 1-32. Meter sw test contents: check that the corresponding leds light/ tur n off when the mb1000 sws are pressed. Example of execution screen the sws and the corresponding leds are as follows: 1-98. Message log contents: the log of the check results is displayed. Example of ...

  • Page 121

    Dm1000/mb1000/sp1000 121 switches not pressed in the specified order display . If pressed in the specified order, the normal display will return. The [dec] sw is not displayed during the 1-24. Panel sw test. A pressed sw will disappear. The next sw to be pressed will flash. 2. Supplement lcd display...

  • Page 122

    Dm1000/mb1000/sp1000 122 sw operation fig. 1 group 1 sw operation fig. 2 group 2 1 1 3 6 8 9 7 4 2 5 2 3 5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 4.

  • Page 123

    Dm1000/mb1000/sp1000 123 led lighting order fig. 1 led lighting order fig. 2 1 1 8 2 4 3 7 6 5 2 3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 5 4.

  • Page 124

    Dm1000/mb1000/sp1000 124 3. Audio check caution! Be sure to press the [end] button to complete the audio check. If the [end] button is not pressed and the power is turned off, the current memory data of the unit will be erased and the unit will not return to the condition before the check. However, ...

  • Page 125

    Dm1000/mb1000/sp1000 125 mode changing the input/output terminals analog patches the analog i/o to the input/output. Slot 1 patches the slot 1 i/o to the input/output. Slot 2 patches the slot 2 i/o to the input/output. 2trd patches the 2trd 1, 2 i/o to the input/output. Clock changing the clock sour...

  • Page 126

    Dm1000/mb1000/sp1000 126 ch20 omni4 ch21 input1 ch22 input2 ch23 input3 ch24 input4 ch25 input5 ch26 input6 ch27 input7 ch28 input8 ch29 input9 ch30 input10 ch31 input11 ch32 input12 ch33 input13 ch34 input14 ch35 input15 ch36 input16 ch37 omni1 ch38 omni2 ch39 omni3 ch40 omni4 ch41 input1 ch42 inpu...

  • Page 127

    Dm1000/mb1000/sp1000 127 ch30 slot1-14 ch31 slot1-15 ch32 slot1-16 ch33 slot1-1 ch34 slot1-2 ch35 slot1-3 ch36 slot1-4 ch37 slot1-5 ch38 slot1-6 ch39 slot1-7 ch40 slot1-8 ch41 slot1-9 ch42 slot1-10 ch43 slot1-11 ch44 slot1-12 ch45 slot1-13 ch46 slot1-14 ch47 slot1-15 ch48 slot1-16 mode: patch settin...

  • Page 128

    Dm1000/mb1000/sp1000 128 ch40 slot2-8 ch41 slot2-9 ch42 slot2-10 ch43 slot2-11 ch44 slot2-12 ch45 slot2-13 ch46 slot2-14 ch47 slot2-15 ch48 slot2-16 mode: patch setting during 2trd input ch in port output ch(bus/aux) out port ch1 2trd1l bus1 2trd1l ch2 2trd1r bus2 2trd1r ch3 2trd2l bus3 2trd2l ch4 2...

  • Page 129

    Dm1000/mb1000/sp1000 129 (fig.3) 個別検査画面例Ｂ （多項目を個別に自動または目視判定す る場合） 1) 検査を開始するとok/ngの選択項目が表示されるので、 動作や結果を判定し ok/ng を選択します。 選択方法は[←], [→]キーを使い、 [enter]キーにて決定し ます。 2）okまたはngを選択すると次の検査項目に自動で移ります。 3）ok/ng判定の入力待ち時に[dec]キーを押すと「exit」 表示が反転し、 [enter]キーでこの画面を終了します。 ( 一部の検査項目は実行中にも[ d e c ] キーを押すと 「exit」処理可能です。...

  • Page 130

    Dm1000/mb1000/sp1000 130 1-1 pllp2 test 内容 pllp2 の reg.(00,0f,10,16)を w/r して比較判 定します。 実行画面例 1-2 batt test 内容 バックアップ用電池の電圧をa/dで測定し自 動判定します。 実行画面例 1-4 dsp6,sio test 1-5 dsp7,sio,atsc2 test 内容 各 d s p 6 , d s p 7 の r e g i s t e r を w / r して databus,addressbus の良否を判定します。 各dsp6,dsp7のdram,sdramにregister経...

  • Page 131

    Dm1000/mb1000/sp1000 131 1-21 lcd test 内容 lcd の画面全体を黒と白の繰り返し表示に し、目視判定します。 実行画面例 全画面が黒・白表示されることを確認します。 全画面が黒表示されているときに、ドットの欠けがな いことを確認します。 コントラストボリュームを回し、画面のコントラスト が変わることを確認します。 以上が確認できたら、 [dec]キーを押し、ok/ng を 選択します。 1-22 panel led test 内容 パネル上の led、7 セグ led が規定の順序で 点灯するかを目視で確認します。 1-13 word clock tes...

  • Page 132

    Dm1000/mb1000/sp1000 132 実行画面例 点灯順序は、 「2. 補足」の led 点灯順序図１，２を参照 してください。なお、7 セグ led は 1..9,0、ドットの順 で点灯します。また all led on では、パネル上の全 led が点灯します（sel スイッチは赤と緑の 2 色 led のため、オレンジになります） 。 1-23 panel all led test 内容 パネル上の全 led(２色 led は orange)の 明るさが 4 段階で点灯する事を確認します。 赤色の led(２色 led を含む)のみ点灯した 際、 違う色が点灯していないかを確...

  • Page 133

    Dm1000/mb1000/sp1000 133 実行画面例 1-28 encoder(etc.)test 内容 ch1 から ch16 以外の encoder の回転応答を 検査します。 encoderの操作方法は1-27と同様です。joystick は、始めに左から右、右から左へ動かした後、 下から上、上から下の順に動かします。 実行画面例 1-31 meter led test 内容 mb1000 の led、7 セグ led が規定の順序で 点灯するかを目視で確認します。 実行画面例 検査項目 5 から実施する場合。 q [enter]キーを押します。 w フェダーが自動的に動いてチェ...

  • Page 134

    Dm1000/mb1000/sp1000 134 点灯順序は以下の通りです。 1) channel バーグラフ点灯 (led 点灯順序 ch1 下→上 ..Ch16 下→上 , out bus1 下 →上 ..Out bus8 下→上) 2) time code h10 → h1 → m10 → m1 → s10 → s1 → f10 → f1 点灯繰り返し (点灯順序：0 → 1..9 → .(ドット)) 3) その他点灯 (input pre eq → pre fader → post fader → output pre eq → pre fader → post fader → ch1...

  • Page 135

    Dm1000/mb1000/sp1000 135 押されたsw が消えていきます。 次に押すswを 点滅表示します。 [dec] swは、 1-24 panel sw testに 表示されません。 指定順序に押されなかったswを＊表示します。 指定順序に押されれば通常表示に戻ります。 2. 補足 lcd 表示図１ panel sw 操作順序表示画面 (操作順序は sw 操作図１，２を参照してください。 ) lcd 表示 53 桁 x30 行(320x240dot font5x7 使用).

  • Page 136

    Dm1000/mb1000/sp1000 136 1 1 3 6 8 9 7 4 2 5 2 3 5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 4 sw 操作図１ group1 sw 操作図２ group2.

  • Page 137

    Dm1000/mb1000/sp1000 137 led 点灯順序図１ led 点灯順序図２ 1 1 8 2 4 3 7 6 5 2 3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 5 4.

  • Page 138

    Dm1000/mb1000/sp1000 138 操作方法 audio check に使用するパネル上のキー 起動方法 [aux select display]キー +[aux5]キーを押し ながら電源を on にします。 制限 ・操作可能なキーはdata entory sectionのみ です。 ・通信によるパラメータの変更は出来ません。 ・パネルに表示する led は stereo meter のみ です。 ・fader は無効です。 ・固定パラメータ ・input・bus/aux/stereo out level をすべ てノミナルに設定。 ・oscillator をすべての bus/a...

  • Page 139

    Dm1000/mb1000/sp1000 139 mode 入出力の端子の切り替え analog 入出力にアナログの i/o をパッチします。 slot1 入出力に slot1 の i/o をパッチします。 slot2 入出力に slot2 の i/o をパッチします。 2trd 入出力に 2trd1,2 の i/o をパッチすします。 clock クロックソースの切り替え int 44.1k int 48k int 88.2k int 96k fs 動作クロックを表示します。 end audiocheck モードを終了します。 input ボタン input channel の on/off...

  • Page 140

    Dm1000/mb1000/sp1000 140 ch19 omni3 ch20 omni4 ch21 input1 ch22 input2 ch23 input3 ch24 input4 ch25 input5 ch26 input6 ch27 input7 ch28 input8 ch29 input9 ch30 input10 ch31 input11 ch32 input12 ch33 input13 ch34 input14 ch35 input15 ch36 input16 ch37 omni1 ch38 omni2 ch39 omni3 ch40 omni4 ch41 input...

  • Page 141

    Dm1000/mb1000/sp1000 141 ch29 slot1-13 ch30 slot1-14 ch31 slot1-15 ch32 slot1-16 ch33 slot1-1 ch34 slot1-2 ch35 slot1-3 ch36 slot1-4 ch37 slot1-5 ch38 slot1-6 ch39 slot1-7 ch40 slot1-8 ch41 slot1-9 ch42 slot1-10 ch43 slot1-11 ch44 slot1-12 ch45 slot1-13 ch46 slot1-14 ch47 slot1-15 ch48 slot1-16 mode...

  • Page 142

    Dm1000/mb1000/sp1000 142 ch39 slot2-7 ch40 slot2-8 ch41 slot2-9 ch42 slot2-10 ch43 slot2-11 ch44 slot2-12 ch45 slot2-13 ch46 slot2-14 ch47 slot2-15 ch48 slot2-16 mode:2trd 時のパッチ設定 input ch in port output ch(bus/aux) out port ch1 2trd1l bus1 2trd1l ch2 2trd1r bus2 2trd1r ch3 2trd2l bus3 2trd2l ch4 2t...

  • Page 143: Mb1000 Test Program

    Dm1000/mb1000/sp1000 143 this executes the mb1000 test program. 1. Preparation 1) connect the d-sub 15-pin cable to the [meter] terminal on the rear of the dm1000. 2) if there is no dm1000, supply +16.5 v power with an external power supply to the +12v terminal and the ground terminal. Note: if a st...

  • Page 144

    Dm1000/mb1000/sp1000 144 ※ mb1000 のテストプログラムを行います。 1. 準備 1) dm1000 リア側の[meter]端子に、mb1000 の d-sub 15 ピンケーブルを接続します。 2) dm1000 が無い場合は、+12v 端子と gnd 端子に外部電源にて +16.5v を供給します。 注) dm1000 本体に取り付けた状態で単独検査を行った場合、loopback テストは error になります。 2. 検査プログラムの起動方法 1) [peak hold]スイッチ、 [33-48]スイッチ及び[master] スイッチを押しながら電源投入で...

  • Page 145: Initializing The Dm1000

    145 dm1000/mb1000/sp1000 initializing the dm1000 you can delete all currently-recorded settings and restore the factory-preset values, and reset the operation lock password to its initial setting. Follow the steps below. Tip: • if you want to keep the current internal data, be sure to first back up ...

  • Page 146

    Dm1000/mb1000/sp1000 146 transmitting parameter settings via midi (bulk dump) you can back up data stored in the dm1000, such as libraries and scenes, to an external midi device by using midi bulk dump. In this way, you can later restore previous dm1000 settings by transmitting this midi data back t...

  • Page 147

    147 dm1000/mb1000/sp1000 4 in the category section, move the cursor to the button of the data type you want to transmit, then press [enter]. The following options are available: • all................................. This button selects all data available for bulk dump. When this button is turned on...

  • Page 148

    Dm1000/mb1000/sp1000 148 ■内部設定を midi 経由で出力（バルクダンプ機能） 各種ライブラリーやシーンなどの本体内に記憶されているデータは、バルクダンプ機能を使って外部 midi 機器に送信で きます。この midi メッセージを dm1000 に送れば、内部設定を以前の状態に戻すことができます。 1 display access セクションの［setup］キーを繰り返し押して、setup 画面の midi/host ページを表示させ、midi メッセージを送受信する端子やポートを選択します。 2 手順 1 で選んだ端子を使って、dm1000 と外部機器との間で m...

  • Page 149

    149 dm1000/mb1000/sp1000 4 categoryフィールドの中からバルクダンプしたいデータに相当するボタンにカーソルを合わせ、 ［enter］キーを押し ます。 各ボタンの内容は次のとおりです。 ・all ボタン ...................... バルクダンプ可能なすべてのデータを選択します。このボタンがオンのときは、他のボタンは 自動的にオフになります。 ・scenemem ボタン ...... シーンメモリーを選択します。ボタン右側のパラメーターボックスを使ってバルクダンプする シーンを選択できます。 ・automix ボタン ........... オー...

  • Page 151: Midi Data Format

    151 dm1000/mb1000/sp1000 midi data format 1. Data format 1.1 channel message 1.2 system common message 1.3 system real time message 1.4 exclusive message 1.4.1 real time system exclusive 1.4.2 system exclusive message 1.4.2.1 bulk dump the following data types of bulk dump are used on the dm1000. 1....

  • Page 152

    Dm1000/mb1000/sp1000 152 transmission if [table] is selected, operating a parameter specified in the [control assign ta- ble] will cause these messages to be transmitted if [control change tx] is on. The parameters that can be specified are defined in the control change assign parameter list. If [nr...

  • Page 153

    153 dm1000/mb1000/sp1000 transmission this message is transmitted on the [tx ch] by key operations in the [mi- di]-[bulk dump] screen. A bulk dump is transmitted on the [rx ch] in response to a bulk dump request. The data area is handled by converting seven words of 8-bit data into eight words of 7-...

  • Page 154

    Dm1000/mb1000/sp1000 154 2.12.2.6 user defeined midi remote bulk dump request format the second and third bytes of the data name indicate the bank number. 2.12.2.7 user defined keys bulk dump format the second and third bytes of the data name indicate the bank number. Be aware that the state of the ...

  • Page 155

    155 dm1000/mb1000/sp1000 2.12.2.11 control change table bulk dump format 2.12.2.12 control change table bulk dump request format 2.12.2.13 program change table bulk dump format 2.12.2.14 program change table bulk dump request format 2.12.2.15 equalizer library bulk dump format the second and third b...

  • Page 156

    Dm1000/mb1000/sp1000 156 2.12.2.17 compressor library bulk dump format the second and third bytes of the data name indicate the library number. 0:library no.1 – 127:library no.128, 256:ch1 – 303:ch48, 384:bus1 – 391:bus8, 512:aux1 – 519:aux8, 768:ste- reo, 8192:undo 256 and following are data for th...

  • Page 157

    157 dm1000/mb1000/sp1000 2.12.2.22 effect library bulk dump request format the second and third bytes of the data name indicate the library number. (see above) 2.12.2.23 channel library bulk dump format the second and third bytes of the data name indicate the library number. 0:library no.0 – 128:lib...

  • Page 158

    Dm1000/mb1000/sp1000 158 2.12.2.28 output patch library bulk dump request format the second and third bytes of the data name indicate the library number. (see above) 2.12.2.29 bus to stereo library bulk dump format the second and third bytes of the data name indicate the library number. 0:library no...

  • Page 159

    159 dm1000/mb1000/sp1000 2.12.2.33 automix bulk dump format the second byte of the data name indicates the library number. 0:library no.1 – 15:library no.16, 256:current automix data 2.12.2.34 automix bulk dump request format the second and third bytes of the data name indicate the library number. (...

  • Page 160

    Dm1000/mb1000/sp1000 160 2.12.3.1.2 parameter change basic format (universal format) *) for parameters with a data size of 2 or more, data for that size will be transmitted. 2.12.3.1.3 parameter request basic format 2.12.3.1.4 parameter request basic format (universal format) 2.12.3.1.5 parameter ad...

  • Page 161

    161 dm1000/mb1000/sp1000 2.12.3.8 parameter change (backup memory) 2.12.3.9 parameter request (backup memory) 2.12.3.10 parameter change (cascade data) reception this message is echoed if [parameter change echo] is on. Data received from a port that is assigned to [cascade link] and whose device num...

  • Page 162

    Dm1000/mb1000/sp1000 162 2.12.3.13 parameter change (function call: title) reception when this is received, the title of the specified memory/library will be changed. If this is received from studio manager or cascade link, the operation will be executed, and then the result of execution will be tra...

  • Page 163

    163 dm1000/mb1000/sp1000 transmission in response to a request, a parameter change message will be transmitted on the [rx ch]. If [parameter change echo] is on, this message will be retransmitted without change. 2.12.3.19 parameter request (function call: attribute) reception this is received if [pa...

  • Page 164

    Dm1000/mb1000/sp1000 164 2.12.3.24 parameter change (function call: pair, copy) reception this is received if [parameter change rx] is on and the [rx ch] matches the device number included in the sub status. This is echoed if [parameter change echo] is on. When this is received, pairing will be enab...

  • Page 165

    165 dm1000/mb1000/sp1000 2.12.3.30 parameter request (remote meter) reception this is received if [parameter change rx] is on and the [rx ch] matches the device number included in the sub status. This is echoed if [parameter change echo] is on. When this is received, data of the specified address is...

  • Page 166

    Dm1000/mb1000/sp1000 166 yamaha [digital mixing console-internal parameters] date: 26 aug. 2002 model: dm1000 midi implementation chart version: 1.0 function... Transmitted recognized remarks basic channel default changed 1—16 1—16 1—16 1—16 memorized mode default messages altered x x **************...

  • Page 167: Parts List

    Parts list contents overall assembly .............................................. 2 bottom assembly ..................................... 5 rear assembly u ....................................... 9 control panel assembly ................ 12 electrical parts ...................................... 1...

  • Page 168

    Dm1000 2 overall assembly digital production console model dm1000 made in japan 120v 135w 60hz upc label avis warning to reduce the risk of fire or electric shock, do not expose this apparatus to rain or moisture. Risk of electric shock do not open risque de choc electrique-ne pas ouvrir. Audio equi...

  • Page 169

    Dm1000 3 200 30 15 50 10 13 control panel assembly: see page 12. （コンパネass'y） bottom assembly: see page 5. （ボトムass'y） pic．2 rear assembly u: see page 9. （リア上ass'y） 14 pic.1 main-jk1 wiring 210 pic.2.

  • Page 170

    Dm1000 4 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * overall assemby dm1000 overall assembly j (v968750) overall assembly u,v (v968760) overall assembly h,b,w (v968770) overall assembly k (v968780) 10 bottom assembly j (v968810) 10 bottom assembly u,v (wa33...

  • Page 171

    Dm1000 5 bottom assembly c d b view b a a view (cn402) (cn401) (cn403) 290 285 350 145 145 230 210 200 200 15 10 18 10c 10a 10d 10c 10d 190 220 120 170 262 265 250 330 330a 340 60 260 260a 300 310 285 270 130 290 140 140 150 160 280 40 20 10 335 320 350 370 410 411 341 420 375 360 345 50 255 333 330...

  • Page 172: Top View

    Dm1000 6 side panel r pic.1 pic.2 pic.3 pic．2 pic．1 pic．3 610 290 600 326 610 345 210 262 260 260a 265 510 190 200 520 370 10 top view.

  • Page 173

    Dm1000 7 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * * * * bottom assembly dm1000 bottom assembly j (v968810) bottom assembly u,v (wa33150) bottom assembly h,b,w,k (wa33170) 10 bottom chassis 10a support angle, transformer (wa2...

  • Page 174

    Dm1000 8 : new parts ref no. Part no. Description remarks qty rank rank: japan only 610 cord holder bk-1 2 01 cb069250 部 品 名 イ ン シ ュ ロ ッ ク タ イ.

  • Page 175

    Dm1000 9 rear assembly u a view b view a b 60 50 220 150 210 160 240 230 180 200 260 190 176 175 174 130 100 120 110 120 170 70 50 260 10 20 30 x 16 x 18 x 18 haad 1/2 haad 2/2 （リ ア上 ass y）.

  • Page 176: Bottom View

    Dm1000 10 100 70 170 250 50 10 10 90 20 bottom view top view haad 1/2.

  • Page 177

    Dm1000 11 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * rear assembly u upper dm1000 (v968800) 10 shield sheet (wa04420) 20 circuit board dm1k ada (hacom) (v989910) 30 bind head tapping screw-b 3.0x8 mfzn2bl 7 01 50 circuit board dm1k haad (hacom) 1/2...

  • Page 178

    Dm1000 12 control panel assembly a view a 180 150 60b 60a 60 70 90 123 100 120 170 120 120 20 200 pn1 (2/4) 80 110 160 170 50 10 40 15 （コ ンパネ ass y）.

  • Page 179

    Dm1000 13 a 330 10 310 340 320 350 300 200 220 220 210 215 200 230 240 260 280 270 250 260 200 218 216 30 pn1 (3/4) pn1 (4/4) pn1 (1/4) see page 59 for the buttons of the pn1 and pn2 circuit boards. （※pn1、pn2シートのボタンは、59ページを参照してください。）.

  • Page 180: Bottom View

    Dm1000 14 pic.1 pic.1 pic.4 pic.4 pic.2 pic.3 pic.6 pic.5 465 440 525 420 250 435 100 60b 60a 60 415 400 230 450 200 10 pic.3 520 420 520 440 525 500 470 pic.2 pic.5 bottom view.

  • Page 181: Bottom View

    Dm1000 15 pic.8 pic.6 pic.7 480 200 250 535 545 545 490 535 510 545 600 465 bottom view.

  • Page 182

    Dm1000 16 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * * * * * * control panel assembly dm1000 (v968790) 10 control panel 15 sponge spacer, panel 3 02 20 adhesive tape w=4.5 (wb32820) 30 cover, 7 seg. Led scene memory 40 led len...

  • Page 183: Electrical Parts

    Dm1000 17 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * electrical parts electrical parts dm1000 circuit board dm1k ac (dccom) j,u,v (v990110)(x3434c0) circuit board dm1k ac (dccom) h,b,w,k (v990170)(x3434c0...

  • Page 184

    Dm1000 18 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * cn301 base post connector vh 8p te 01 cn302 wire trap 52147 11p te 01 cn304 wire trap 52147 13p te 01 cn305 wire trap 52147 12p te 01 cn306 wire trap 52147 6p te 01 cn307 wire trap 52147 3p te 01 cn401 b...

  • Page 185

    Dm1000 19 : new parts ref no. Part no. Description remarks qty rank rank: japan only v s 1 5 0 8 0 0 vm923000 i d 0 6 6 7 0 0 v 2 7 9 7 7 0 0 v 2 7 9 7 6 0 0 i b 0 6 4 7 3 0 -- -- -- wb101500 wb101500 wb101500 vq554100 vq558500 vq557800 v i 2 4 1 1 0 0 vq557100 v 9 9 0 1 3 0 0 v s 5 8 9 0 0 0 v s 5 ...

  • Page 186

    Dm1000 20 : new parts ref no. Part no. Description remarks qty rank rank: japan only -105 ceramic capacitor-sl(chip) 470p 50v j 01 c106 ceramic capacitor-b (chip) 0.0100 50v k 01 c107 ceramic capacitor-b (chip) 0.0100 50v k 01 c108 ceramic capacitor-ch(chip) 47p 50v j 01 c109 ceramic capacitor-b (ch...

  • Page 187

    Dm1000 21 : new parts ref no. Part no. Description remarks qty rank rank: japan only * c713 ceramic capacitor-b (chip) 0.0100 50v k 01 -723 ceramic capacitor-b (chip) 0.0100 50v k 01 c724 electrolytic cap. (chip) 220 16v uur1c2 01 c725 monolithic mylar capacitor 0.33 50v j 01 -727 monolithic mylar c...

  • Page 188

    Dm1000 22 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * -706 zener diode nncd6.2mf 6.2v smd da800 zener diode nncd6.2mf 6.2v smd -805 zener diode nncd6.2mf 6.2v smd da900 zener diode nncd6.2mf 6.2v smd -904 zener diode nncd6.2mf 6.2v s...

  • Page 189

    Dm1000 23 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * r102 carbon resistor (chip) 10.0k 63m j 01 r103 carbon resistor (chip) 10.0k 63m j 01 r104 carbon resistor (chip) 12.0k 63m j 01 r105 carbon resistor 2.0k 1/4 j 01 r106 carbon resistor (chip) 1.1k 63m j 01 r...

  • Page 190

    Dm1000 24 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * r729 carbon resistor (chip) 47.0k 63m j 01 r730 carbon resistor (chip) 47.0k 63m j 01 r731 carbon resistor (chip) 160.0k 63m j r732 carbon resistor (chip) 47.0k 63m j 01 r733 carbon resistor (chi...

  • Page 191

    Dm1000 25 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * r827 carbon resistor (chip) 160.0k 63m j r828 carbon resistor (chip) 47.0k 63m j 01 r829 carbon resistor (chip) 47.0k 63m j 01 r830 carbon resistor (chip) 160.0k 63m j r831 carbon resistor (chi...

  • Page 192

    Dm1000 26 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * -926 carbon resistor (chip) 100.0k 63m j 01 r927 carbon resistor (chip) 160.0k 63m j r928 carbon resistor (chip) 47.0k 63m j 01 r929 carbon resistor (chip) 47.0k 63m j 01 r930 carbon resistor (chip) ...

  • Page 193

    Dm1000 27 : new parts ref no. Part no. Description remarks qty rank rank: japan only tr718 transistor 2sb1181f5 p,q,r 01 tr719 digital transistor dtc143xka tp 01 -721 digital transistor dtc143xka tp 01 tr722 digital transistor dta143zua 01 -724 digital transistor dta143zua 01 tr725 transistor 2sd173...

  • Page 194

    Dm1000 28 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * tr923 transistor 2sb1181f5 p,q,r 01 tr924 transistor 2sd1733f5 p,q,r 01 tr925 transistor 2sb1181f5 p,q,r 01 tr926 transistor 2sd1733f5 p,q,r 01 tr927 transistor 2sb1181f5 p,q,r 01 tr928 transistor 2sd1733f5 ...

  • Page 195

    Dm1000 29 : new parts ref no. Part no. Description remarks qty rank rank: japan only * c034 electrolytic cap. 10.00 50.0v 01 c035 electrolytic cap. 10.00 50.0v 01 c036 electrolytic cap. 47.00 25.0v 01 c037 electrolytic cap. 47.00 25.0v 01 c038 ceramic capacitor-b (chip) 0.0100 50v k 01 c039 mylar ca...

  • Page 196

    Dm1000 30 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * c183 electrolytic cap. 100.00 50.0v 01 -186 electrolytic cap. 100.00 50.0v 01 c202 electrolytic cap.-kl 10.00 50.0v 01 c203 electrolytic cap.-kl 10.00 50.0v 01 c204 ceramic capacitor-sl(chip) 220p 50v j 01 c205 ...

  • Page 197

    Dm1000 31 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * -359 ceramic capacitor-f (chip) 0.1000 25v z 01 c360 monolithic ceramic cap. F 0.220 25v z 01 c361 ceramic capacitor-sl(chip) 100p 50v j 01 -364 ceramic capacitor-sl(chip) 100p 50v j 01 c365 mylar capacitor 3300...

  • Page 198

    Dm1000 32 : new parts ref no. Part no. Description remarks qty rank rank: japan only * c536 mylar capacitor 1000p 50v j 01 c537 electrolytic cap. 1.00 50.0v 01 c539 ceramic capacitor-f (chip) 0.1000 25v z 01 -543 ceramic capacitor-f (chip) 0.1000 25v z 01 c544 electrolytic cap. 1.00 50.0v 01 c545 el...

  • Page 199

    Dm1000 33 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * c709 ceramic capacitor-ch(chip) 10p 50v d 01 c710 ceramic capacitor-sl(chip) 220p 50v j 01 c711 ceramic capacitor-ch(chip) 22p 50v j 01 c712 ceramic capacitor-ch(chip) 10p 50v d 01 c713 ceramic capacitor-ch(chip...

  • Page 200

    Dm1000 34 : new parts ref no. Part no. Description remarks qty rank rank: japan only * c868 mylar capacitor 1000p 50v j 01 c869 ceramic capacitor-b (chip) 0.0100 50v k 01 -874 ceramic capacitor-b (chip) 0.0100 50v k 01 c875 electrolytic cap. 1.00 50.0v 01 c877 ceramic capacitor-f (chip) 0.1000 25v z...

  • Page 201

    Dm1000 35 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * ca17 ceramic capacitor-b (chip) 0.0100 50v k 01 ca31 electrolytic cap. 47.00 25.0v ca32 ceramic capacitor-sl(chip) 220p 50v j 01 ca33 ceramic capacitor-sl(chip) 220p 50v j 01 ca34 ceramic capacitor-b (chip) ...

  • Page 202

    Dm1000 36 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * cd32 ceramic capacitor-sl(chip) 220p 50v j 01 cd33 ceramic capacitor-sl(chip) 220p 50v j 01 cd34 ceramic capacitor-b (chip) 0.0100 50v k 01 cd35 ceramic capacitor-b (chip) 0.0100 50v k 01 cd36 mylar capacitor 10...

  • Page 203

    Dm1000 37 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * cg11 ceramic capacitor-ch(chip) 22p 50v j 01 cg12 ceramic capacitor-ch(chip) 10p 50v d 01 cg13 ceramic capacitor-ch(chip) 47p 50v j 01 cg16 ceramic capacitor-b (chip) 0.0100 50v k 01 cg17 ceramic capacit...

  • Page 204

    Dm1000 38 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * ic452 ic njm78l05ua regulator +5v 02 ic453 ic upc4570g2 op amp 03 ic454 ic upc4570g2 op amp 03 ic455 ic njm4556al op amp 02 ic456 ic njm4556al op amp 02 ic501 ic upc4570g2 op amp 03 ic502 ic upc4570g...

  • Page 205

    Dm1000 39 : new parts ref no. Part no. Description remarks qty rank rank: japan only r002 carbon resistor (chip) 2.2k 0.1 j 01 r003 carbon resistor (chip) 2.2k 0.1 j 01 r004 carbon resistor (chip) 220.0 0.1 j 01 r005 carbon resistor (chip) 47.0k 0.1 j 01 r006 carbon resistor (chip) 220.0 0.1 j 01 r0...

  • Page 206

    Dm1000 40 : new parts ref no. Part no. Description remarks qty rank rank: japan only r133 metal film resistor (chip) 1.0k 1/10 d 01 r135 metal film resistor (chip) 2.0k 1/10 d r136 metal film resistor (chip) 2.0k 1/10 d r138 carbon resistor (chip) 150.0 0.1 j 01 r139 carbon resistor (chip) 150.0 0.1...

  • Page 207

    Dm1000 41 : new parts ref no. Part no. Description remarks qty rank rank: japan only r263 carbon resistor (chip) 39.0 0.1 j 01 r264 carbon resistor (chip) 39.0 0.1 j 01 r265 carbon resistor (chip) 100.0k 0.1 j 01 r266 carbon resistor (chip) 100.0k 0.1 j 01 r267 metal film resistor (chip) 10.0k 1/10 ...

  • Page 208

    Dm1000 42 : new parts ref no. Part no. Description remarks qty rank rank: japan only r376 metal film resistor (chip) 10.0k 1/10 d 01 r377 metal film resistor (chip) 20.0k 1/10 d 01 -380 metal film resistor (chip) 20.0k 1/10 d 01 r381 metal film resistor (chip) 18.0k 1/10 d 01 -384 metal film resisto...

  • Page 209

    Dm1000 43 : new parts ref no. Part no. Description remarks qty rank rank: japan only r509 carbon resistor (chip) 10.0 0.1 j 01 r510 carbon resistor (chip) 10.0 0.1 j 01 r511 metal film resistor (chip) 47.0k 1/10 d 01 r512 metal film resistor (chip) 47.0k 1/10 d 01 r513 carbon resistor (chip) 10.0 0....

  • Page 210

    Dm1000 44 : new parts ref no. Part no. Description remarks qty rank rank: japan only r620 metal film resistor (chip) 9.1k 1/10 d 01 r621 metal film resistor (chip) 9.1k 1/10 d 01 r622 metal film resistor (chip) 4.7k 1/10 d 01 r623 metal film resistor (chip) 4.7k 1/10 d 01 r624 carbon resistor (chip)...

  • Page 211

    Dm1000 45 : new parts ref no. Part no. Description remarks qty rank rank: japan only -754 carbon resistor (chip) 1.0m 0.1 j 01 r755 metal film resistor (chip) 10.0k 1/10 d 01 -758 metal film resistor (chip) 10.0k 1/10 d 01 r759 metal film resistor (chip) 5.1k 1/10 d 01 -762 metal film resistor (chip...

  • Page 212

    Dm1000 46 : new parts ref no. Part no. Description remarks qty rank rank: japan only r884 carbon resistor (chip) 100.0 0.1 j 01 -889 carbon resistor (chip) 100.0 0.1 j 01 r890 metal film resistor (chip) 10.0k 1/10 d 01 r891 metal film resistor (chip) 10.0k 1/10 d 01 r905 metal film resistor (chip) 2...

  • Page 213

    Dm1000 47 : new parts ref no. Part no. Description remarks qty rank rank: japan only ra16 metal film resistor (chip) 2.2k 1/10 d 01 ra17 metal film resistor (chip) 18.0 1/10 d 01 ra18 metal film resistor (chip) 18.0k 1/10 d 01 ra19 metal film resistor (chip) 18.0k 1/10 d 01 ra20 metal film resistor ...

  • Page 214

    Dm1000 48 : new parts ref no. Part no. Description remarks qty rank rank: japan only rc32 metal film resistor (chip) 6.2k 1/10 d 01 rc33 metal film resistor (chip) 1.0k 1/10 d 01 rc35 metal film resistor (chip) 2.0k 1/10 d rc36 metal film resistor (chip) 2.0k 1/10 d rc38 carbon resistor (chip) 150.0...

  • Page 215

    Dm1000 49 : new parts ref no. Part no. Description remarks qty rank rank: japan only rf11 metal film resistor (chip) 47.0k 1/10 d 01 rf12 metal film resistor (chip) 47.0k 1/10 d 01 rf13 carbon resistor (chip) 10.0 0.1 j 01 rf14 carbon resistor (chip) 10.0 0.1 j 01 rf15 metal film resistor (chip) 2.2...

  • Page 216

    Dm1000 50 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * tr101 transistor 2sc2240 gr,bl 01 tr102 transistor 2sc2240 gr,bl 01 tr151 transistor 2sd1915(f) s,t 01 -154 transistor 2sd1915(f) s,t 01 tr201 transistor 2sc2240 gr,bl 01 tr202 transistor 2sc2240 gr,bl 01 tr25...

  • Page 217

    Dm1000 51 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * circuit board dm1k jk1 (jkcom) (v989800)(x3429b0) circuit board dm1k jk2 (jkcom) (v989800)(x3429b0) circuit board dm1k opt (jkcom) (v989800)(x3429b0) c001 ceramic capacitor-f (chip) 0.1000 25v z 01 -010 cerami...

  • Page 218

    Dm1000 52 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * da102 diode array 1ss372 te85l 01 da701 diode array dan217 0.3a x2 01 -704 diode array dan217 0.3a x2 01 em051 emi filter (chip) nfm3dcc101u1h3l 01 em052 emi filter (chip) nfm3dcc101u1h3l 01 em201 emi ...

  • Page 219

    Dm1000 53 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * r053 carbon resistor (chip) 4.7 63m j 01 r054 carbon resistor (chip) 75.0 63m j 01 r101 carbon resistor (chip) 10.0k 63m j 01 r102 carbon resistor (chip) 10.0k 63m j 01 r103 carbon resistor (chip) 1.0k 63m j...

  • Page 220

    Dm1000 54 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * c022 electrolytic cap. (chip) 100 6.3v 01 c023 ceramic capacitor-ch(chip) 22p 50v j 01 c024 ceramic capacitor-ch(chip) 22p 50v j 01 c025 ceramic capacitor-b (chip) 1000p 50v k 01 c026 ceramic capacitor-f (ch...

  • Page 221

    Dm1000 55 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * -294 ceramic capacitor-f (chip) 0.1000 25v z 01 c295 electrolytic cap. (chip) 100 16v 01 c296 ceramic capacitor-f (chip) 0.1000 25v z 01 -300 ceramic capacitor-f (chip) 0.1000 25v z 01 c303 ceramic capacitor-f...

  • Page 222

    Dm1000 56 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * ic002 ic upc2918t-e1 regulator +1.8v 03 ic003 ic cy2305 clock buffer 07 ic004 ic w986416dh-7 sdram 64m ic005 ic w986416dh-7 sdram 64m ic006 ic m5m5w816tp-55hi sram 8m -009 ic m5m5w816tp-55hi sr...

  • Page 223

    Dm1000 57 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * ic604 ic tc74vhc08f and 01 ic605 ic cs8405a-cs dit 06 ic606 ic cs8405a-cs dit 06 ic607 ic 74vhc541sjx buffer 03 ic651 ic mbcg46183-129pfv-g gate array(sio4) 06 ic652 ic tc74vhc74f-el d-ff 01 ic653 ic tc74vhct2...

  • Page 224

    Dm1000 58 : new parts ref no. Part no. Description remarks qty rank rank: japan only r166 carbon resistor (chip) 47.0k 63m j 01 r167 metal film resistor (chip) 3.3k 1/10 d 01 r168 metal film resistor (chip) 3.3k 1/10 d 01 r169 metal film resistor (chip) 330.0 1/10 d 01 r170 metal film resistor (chip...

  • Page 225

    Dm1000 59 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * ra652 resistor array 22x4 01 ra653 resistor array 10kx4 01 ra801 resistor array 22x4 01 ra802 resistor array 22x4 01 ra803 resistor array 10kx4 01 ra804 resistor array 10kx4 01 ra805 resistor...

  • Page 226

    Dm1000 60 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * -120 electrolytic cap. (chip) 10 16v 01 c501 electrolytic cap. (chip) 100 25v uur1e1 01 c502 electrolytic cap. (chip) 100 16v 01 c503 ceramic capacitor-f (chip) 0.1000 25v z 01 -505 ceramic capacitor-f (...

  • Page 227

    Dm1000 61 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld106 led yellow lt1h40a on 6 01 ld107 led yellow lt1h40a on 7 01 ld108 led yellow lt1h40a on 8 01 ld109 led yellow lt1h40a on 9 01 ld110 led yellow lt1h40a on 10 01 ld111 led yellow lt1h40a on 11 01 ld112 led yello...

  • Page 228

    Dm1000 62 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld201 led red lt1d40a peak 5 01 ld202 led red lt1d40a peak 6 01 ld203 led red lt1d40a peak 7 01 ld204 led red lt1d40a peak 8 01 ld205 led yellow lt1h40a 1 01 ld206 led yellow lt1h40a 3 01 ld207 led yellow lt1h40a 5 ...

  • Page 229

    Dm1000 63 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld409 led yellow lt1h40a l -7 01 ld410 led yellow lt1h40a l -8 01 ld411 led yellow lt1h40a l -9 01 ld412 led yellow lt1h40a l -10 01 ld413 led yellow lt1h40a l -11 01 ld414 led yellow lt1h40a l -12 01 ld415 led yell...

  • Page 230

    Dm1000 64 : new parts ref no. Part no. Description remarks qty rank rank: japan only sw102 tact switch skqnaed010 on 2 01 sw103 tact switch skqnaed010 on 3 01 sw104 tact switch skqnaed010 on 4 01 sw105 tact switch skqnaed010 on 5 01 sw106 tact switch skqnaed010 on 6 01 sw107 tact switch skqnaed010 o...

  • Page 231

    Dm1000 65 : new parts ref no. Part no. Description remarks qty rank rank: japan only sw188 tact switch skqnaed010 output patch 01 sw189 tact switch skqnaed010 2 01 sw190 tact switch skqnaed010 4 01 sw191 tact switch skqnaed010 6 01 sw192 tact switch skqnaed010 8 01 sw193 tact switch skqnaed010 direc...

  • Page 232

    Dm1000 66 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * sw312 tact switch skqnaed010 12 01 sw313 tact switch skqnaed010 display 01 t501 inverter transformer clf16a 07 ta101 transistor array td62309f(el) 04 -106 transistor array td62309f(el) 04 ta107 trans...

  • Page 233

    Dm1000 67 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * em701 lc filter dss6nb32a271q93a 01 em702 lc filter dss6nb32a271q93a 01 em751 lc filter dss6nb32a271q93a 01 em752 lc filter dss6nb32a271q93a 01 em801 lc fi...

  • Page 234

    Dm1000 68 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * jkg01 cannon connector jack nc3fbv1 input 16 jkg51 cannon connector jack nc3fbv1 omni in 4 r101 metal film resistor 6.8k 1/4 f 01 r102 metal film resistor 6.8k 1/4 f 01 r103 flame proof c. Resistor 390.0...

  • Page 235

    Dm1000 69 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * * * * sw501 slide switch ssaa110300 +48v on/off 5 sw601 slide switch ssaa110300 +48v on/off 6 sw701 slide switch ssaa110300 +48v on/off 7 sw801 slide switch ssaa110300 +48v on/off 8 sw901 sli...

  • Page 236: Parts List

    Parts list contents overall assembly .............................................. 2 front panel assembly ............... 4 rear panel assembly ........................ 5 electrical parts ........................................ 6-12 warning components having special characteristics are marked and ...

  • Page 237: Overall Assembly

    Mb1000 2 overall assembly peak meter bridge model mb1000 made in japan ser.No. Peak meter bridge model mb1000 made in japan j model y model upc label 40 40 40 20 10 40 30 20 50 10 front panel assembly: see page 4. （フロントパネルass'y） front panel assembly: see page 4. （フロントパネルass'y） rear panel assembly: s...

  • Page 238

    Mb1000 3 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * overall assembly mb1000 (v969000) 10 front panel assembly (v969010) 20 rear panel assembly (v969020) 30 panel sheet 40 bind head tapping screw-b 3.0x8 mfzn2bl 16 01 50 cable, ffc p=1.25-k-34-120 02 accessorie...

  • Page 239: Front Panel Assembly

    Mb1000 4 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * front panel assembly mb1000 (v969010) 10 front panel 20 adhesive tape #500 w=3 (ve36240) 30 led lens 3p 1-16,17-32,33-48,aux1-8, 6 02 bus1-8,pre eq,pre fader, post fader 40 circuit board mb1k pn 50 bind head tapp...

  • Page 240: Rear Panel Assembly

    Mb1000 5 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * rear panel assembly mb1000 (v969020) 10 rear panel 20 circuit board mb1k main 30 bushing tb-9513 01 40 dsub cable dsub15p 0.5m 07 50 cable holder 08 60 cord binder ckn-10 02 70 bind head tapping screw-b 3.0x8 mfz...

  • Page 241: Electrical Parts

    Mb1000 6 : new parts ref no. Part no. Description remarks qty rank rank: japan only * * * * * * * * * * * * electrical parts electrical parts mb1000 circuit board mb1k main (x3436b0) circuit board mb1k pn (x3437b0) circuit board mb1k main (x3436b0) c107 electrolytic cap. (chip) 100 25v uur1e1 01 c10...

  • Page 242

    Mb1000 7 : new parts ref no. Part no. Description remarks qty rank rank: japan only * x101 quartz crystal unit 6.7584mhz smd-49 03 circuit board mb1k pn (x3437b0) 10 button light gray s lens peak hold,1-16,17-32, 7 02 33-48,remote1,2,master 20 led lens 16p level meters 24 03 (input:1-48,aux1-8,bus1-...

  • Page 243

    Mb1000 8 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld242 led yellow lt1h40a 4/20/36/aux4 -15 (input) 01 ld243 led yellow lt1h40a 4/20/36/aux4 -12 (input) 01 ld244 led yellow lt1h40a 4/20/36/aux4 -9 (input) 01 ld245 led yellow lt1h40a 4/20/36/aux4 -6 (input) 01 ld246 ...

  • Page 244

    Mb1000 9 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld316 led yellow/green lt1e40a 10/26/42/bus2 -24 (input) 01 ld317 led yellow lt1h40a 10/26/42/bus2 -18 (input) 01 ld318 led yellow lt1h40a 10/26/42/bus2 -15 (input) 01 ld319 led yellow lt1h40a 10/26/42/bus2 -12 (inpu...

  • Page 245

    Mb1000 10 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld386 led yellow/green lt1e40a 16/32/48/bus8 -36 (input) 01 ld387 led yellow/green lt1e40a 16/32/48/bus8 -30 (input) 01 ld388 led yellow/green lt1e40a 16/32/48/bus8 -24 (input) 01 ld389 led yellow lt1h40a 16/32/48/b...

  • Page 246

    Mb1000 11 : new parts ref no. Part no. Description remarks qty rank rank: japan only ld460 led red lt1d40a bus5 over (output) 01 ld461 led yellow/green lt1e40a bus6 -48 (output) 01 ld462 led yellow/green lt1e40a bus6 -36 (output) 01 ld463 led yellow/green lt1e40a bus6 -30 (output) 01 ld464 led yello...

  • Page 247

    Mb1000 12 : new parts ref no. Part no. Description remarks qty rank rank: japan only r211 carbon resistor (chip) 1.0k 63m j 01 r212 carbon resistor (chip) 100.0 63m j 01 r213 carbon resistor (chip) 1.0k 63m j 01 r221 carbon resistor (chip) 100.0 63m j 01 -228 carbon resistor (chip) 100.0 63m j 01 r2...

  • Page 248: Parts List

    Parts list contents overall assembly ................................... 2 warning components having special characteristics are marked and must be replaced with parts having specification equal to those originally installed. The numbers “qty” show quantities for each unit. The parts with “--” in “p...

  • Page 249: Overall Assembly

    Sp1000 2 : new parts ref no. Part no. Description remarks qty rank rank: japan only overall assembly sp1000 overall assembly j (wa47920) overall assembly y (wa47930) bind head screw pw 4.0x20 mfzn2bl 10 01 side pad l left side pad r right mb side pad l left mb side pad r right -- -- va 3 1 4 0 0 0 w...

  • Page 250: Circuit Diagram

    Circuit diagram contents block diagram (002~007) .......... 3 overall connector circuit diagram ......................................................... 9 overall circuit diagram digital production console note: see parts list for details of circuit board component parts. Ac ..........................

  • Page 251

    Pllp2 atsc2a jk1 flash 32m lcd controller (s1d13704f) ic027 (80p) ic203 (112p) crystal 11mhz x001 wc slot1 wc slot2 dir cs8420 ic601(28p) dir cs8420 ic602(28p) dsp7 x6 dsp6 x4 sdram 16m x6 dram 4m x8 cpu_bus 2tr in digital (aes/ebu) cpu m37641 ic102(80p) 2ch/line 4ch/line 4 / / 4 4ch/line sci2(cpu) ...

  • Page 252

    6 5 4 3 1 2 4 a h g b c f e d block diagram 003 (dm1000) block diagram 003 (dm1000) dm1000 28ca1-8826678-3 dsp block fx2/3 rtn1/2 fx4/1 rtn1/2 sur.1 rtn1-4 si21 si22 si23 sur.1 rtn5-8 si20 si24 si25 si26 si27 si28 si29 si30 si31 si32 si33 si34 direct out 1-4 direct out 5-8 direct out 9-12 direct out...

  • Page 253

    Hard: digital block (panel display, operation control) monitor level joystick encoders w/sw (ch1-16) (see page 3) 100mm motorized faders with touch sense: ch1-16 & st motor position touch sense servo driver circuits ch1-16 & st ch1-16 & st sub cpu sh7042a ic203(112p) pe0-3 multiplexer (4:1) x 4 ch1-...

  • Page 254

    Input16 input13 input14 input15 icc01 icb01 ica01 ic501 ic601 ic701 ic801 ic901 ic401 ic301 ic201 ic101 ha gain 20db -1 -1 ic103(24p) ainl a/d cs5361-ks sdout ainr ic102 ic202 sdata-1/2 fs 64fs mclk ic302 ic303 (24p) ic402 ic503 (24p) ic502 ic602 ic703 (24p) ic702 ic802 ic903 (24p) ica02 ic902 icb02...

  • Page 255

    Stereo l stereo r solo l solo r a ux 1 a ux 8 b us1 b us2 b us3 b us4 b us5 b us6 b us7 b us8 output delay meter att 4band eq insert insert level stereo l input 1( ...48) att 4band eq input delay meter lfe solo pre/post on direct out 1(...48) keyin 12ch group(1-12,13-24....) aux 1-8 insert pan pan g...

  • Page 256

    6 5 4 3 1 2 8 a h g b c f e d block diagram 007 (dm1000) block diagram 007 (dm1000) dm1000 28ca1-8826678-7 level diagram da dsp noise floor phase gate ad dbu analog cascade in cascade out digital clipping level max. Output nominal output [+18dbu] [-2dbu] [+24dbu] [+4dbu] digital bit 0 0 1 2 3 4 5 6 ...

  • Page 257

    6 5 4 3 h a b c d e f g 1 2 overall connector circuit diagram (dm1000) overall connector circuit diagram (dm1000) 28ca2-8826679 9 dm1000 ac cord (meter) lcd module (parameter wheel) (joystick) cn204 cn202 cn203 cn201 cn102 power transformer cn101 cn301 cn306 cn307 cn302 cn304 cn305 cn101 cn501 cn901...

  • Page 258

    1 2 3 4 10 b c d e f g ac circuit diagram (dm1000) ac circuit diagram (dm1000) dm1000 28cc1-8826684-1 capacitor components having special characteristics are marked and must be replaced with parts having specifications equal to those originally installed. To service personnel critical components inf...

  • Page 259

    A b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 dca circuit diagram (dm1000) dca circuit diagram (dm1000) dm1000 28cc1-8826685-1 11 1 t4al 250v t4al 250v t3.15al 250v t3.15al 250v t500mal 250v regulator +15v µ pc24a15hf (x3506a00) 1 2 3 3: output 2: gnd 1: input njm7915fa(xd854a00) regu...

  • Page 260

    1 2 3 4 5 6 7 8 12 a b c d e f g h i j k dcd circuit diagram (dm1000) dcd circuit diagram (dm1000) dm1000 28cc1-8826686-1 2 components having special characteristics are marked and must be replaced with parts having specifications equal to those originally installed. To service personnel critical co...

  • Page 261

    Fd circuit diagram 002 (dm1000) fd circuit diagram 002 (dm1000) dm1000 28cc1-8826690-2 13 5 a b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 sh7042 : not installed (実装しない) x x buffer regulator +5v multiplexer cpu to dcd-cn202 to dca 1/5-cn306 to main-cn003 njm78m05dl1a(te1)(xs534a00) reg...

  • Page 262

    1 2 3 4 5 6 7 8 9 10 11 14 a b c d e f g h i j k l m n o p fd circuit diagram 003 (dm1000) fd circuit diagram 003 (dm1000) dm1000 28cc1-8826690-3 gate array gate array decoder panel (encoder) interface circuit （パネル（エンコーダ） インターフェース回路）.

  • Page 263

    A b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 fd circuit diagram 004 (dm1000) fd circuit diagram 004 (dm1000) dm1000 28cc1-8826690-4 15 2 decoder d-ff d-ff d-ff d-ff transceiver transceiver transceiver to pn1 (1/4)-cn103 to pn1 (1/4)-cn104 to pn1 (1/4)-cn101 to pn1 (1/4)-cn102 panel (...

  • Page 264

    1 2 3 4 5 6 7 8 9 10 11 16 a b c d e f g h i j k l m n o fd circuit diagram 005 (dm1000) fd circuit diagram 005 (dm1000) dm1000 28cc1-8826690-5 decoder d-ff multiplexer multiplexer d-ff d-ff fader position data and motor drive permission circuit （フェーダ ポジションデータ及びモータ駆動許可回路）.

  • Page 265

    B c d e f g h i j k l m n o p 1 2 3 4 5 6 7 8 9 10 11 fd circuit diagram 006 (dm1000) fd circuit diagram 006 (dm1000) dm1000 28cc1-8826690-6 17 d-ff op amp op amp op amp op amp op amp op amp op amp op amp op amp op amp multiplexer multiplexer multiplexer : ceramic capacitor (セラミックコンデンサー) ( セ ) motor...

  • Page 266

    1 2 3 4 5 6 7 8 9 10 11 12 18 a b c d e f g h i j k l m n o p q fd circuit diagram 007 (dm1000) fd circuit diagram 007 (dm1000) dm1000 28cc1-8826690-7 3 op amp op amp reguletor +6v reguletor +12v reguletor +12v op amp op amp op amp op amp op amp op amp op amp op amp op amp op amp 1 fader 2 fader 3 f...

  • Page 267

    A b 1 2 3 4 5 6 7 8 9 10 11 12 fd circuit diagram 008 (dm1000) fd circuit diagram 008 (dm1000) dm1000 28cc1-8826690-8 19 3 c d e f g h i j k l m n o p q op amp op amp reguletor +12v reguletor +12v op amp op amp op amp op amp op amp op amp op amp op amp op amp op amp 7 fader 8 fader 9 fader 10 fader ...

  • Page 268

    1 2 3 4 5 6 7 8 9 10 11 12 20 a b c d e f g h i j k l m n o p q fd circuit diagram 009 (dm1000) fd circuit diagram 009 (dm1000) dm1000 28cc1-8826690-9 3 µ pc2912t-e1(x2091a00) regulator +12v 1: input 2: gnd 3: output 4: gnd 1 4 3 2 op amp op amp reguletor +12v reguletor +12v op amp op amp op amp op ...

  • Page 269

    Fd circuit diagram 010 (dm1000) fd circuit diagram 010 (dm1000) dm1000 28cc1-8826690-10 21 4 5 6 7 8 9 10 11 4 3 1 2 j i h g f e d c b q p k l o n m multiplexer op amp nand op amp op amp op amp op amp multiplexer multiplexer touch sense detection circuit （タッチセンス検出回路）.

  • Page 270

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 22 a b ada circuit diagram 002 (dm1000) ada circuit diagram 002 (dm1000) dm1000 28cc1-8826692-2 2 c d e f g h i j k l m n o p q r s t u v w x op amp op amp op amp op amp op amp op amp op amp dac dac dac dac regulator +5v inverter transceiver transceiver r...

  • Page 271

    A b 1 2 ada circuit diagram 003 (dm1000) ada circuit diagram 003 (dm1000) dm1000 28cc1-8826692-3 23 1 c d e f g h i j k l m n o p 3 4 5 6 7 8 9 10 11 : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) adc op amp op amp op amp op amp op amp op amp op amp op amp adc to xlr-cnd51...

  • Page 272

    1 2 24 a b haad circuit diagram 002 (dm1000) haad circuit diagram 002 (dm1000) dm1000 28cc1-8826691-2 1 c d e f g h i j k l m n o p q r s t u v w x y 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 dfs_ad h: double rate h: normal rate 128fs mclk 256fs : not installed (実装しない) x x : mylar capacitor (マイラーコンデン...

  • Page 273

    B c 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 haad circuit diagram 003 (dm1000) haad circuit diagram 003 (dm1000) dm1000 28cc1-8826691-3 25 1 d e f g h i j k l m n o p q r s t u v w x y : not installed (実装しない) x x : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) to xlr-c...

  • Page 274

    1 2 26 a b c d e f g h i j k l m n o p q haad circuit diagram 004 (dm1000) haad circuit diagram 004 (dm1000) dm1000 28cc1-8826691-4 1 3 4 5 6 7 8 9 10 11 12 : not installed (実装しない) x x : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) reguletor +5v adc op amp op amp op amp op...

  • Page 275

    B c d e f g h i j k l m 1 2 3 4 5 6 7 8 9 jk1 circuit diagram 002 (dm1000) jk1 circuit diagram 002 (dm1000) dm1000 28cc1-8826682-2 27 line receiver line driver line receiver line driver 2tr in digital 1 aes/ebu 2tr in/out digital 2 coax r 2tr in/out digital 2 coax l 2tr out digital 1 aes/ebu word cl...

  • Page 276

    1 2 28 a b c d e f g h i j k l jk1 circuit diagram 003 (dm1000) jk1 circuit diagram 003 (dm1000) dm1000 28cc1-8826682-3 3 4 5 6 7 8 inverter inverter inverter cpu photo coupler midi in out to host usb to host usb midi in, out.

  • Page 277

    B c d e f g h i j k l m n o p q r 1 2 3 4 5 6 7 8 9 10 11 12 jk1 circuit diagram 004 (dm1000) jk1 circuit diagram 004 (dm1000) dm1000 28cc1-8826682-4 29 1 multiplexer op amp comparator or or d-ff t.C reader/generator transceiver inverter multiplexer line driver remote smpte in control remote time co...

  • Page 278

    1 2 3 4 5 6 7 8 30 a b c d e f g h i j k jk1 circuit diagram 005 (dm1000) jk1 circuit diagram 005 (dm1000) dm1000 28cc1-8826682-5 transceiver transceiver transceiver transceiver to main-cn652 to dca 1/5 -cn307 to main-cn651 i/f section.

  • Page 279

    A b 2 3 4 5 6 jk2 circuit diagram (dm1000) jk2 circuit diagram (dm1000) dm1000 28cc1-8826683-1 31 c d e f g h line driver to main-cn701 meter.

  • Page 280

    1 2 3 4 5 6 7 8 32 a b c d e f g h i j k l opt circuit diagram (dm1000) opt circuit diagram (dm1000) dm1000 28cc1-8826681-1 regulator -15v to main-cn803 to main-cn804 to main-cn801 to main-cn802 to dca 1/5-cn302 slot2-a slot1-a slot2-b slot2-b slot2 slot1 lm2990sx-15 (x3949a00) regulator -15v 1: gnd...

  • Page 281

    A b c d e f g h i j k l m n o p q r s t u v w x 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 main circuit diagram 002 (dm1000) main circuit diagram 002 (dm1000) dm1000 28cc1-8826680-2 33 5 cpu regulator +1.8v clock buffer op amp or transceiver system reset system reset and inverter nor nor nor sram 8m ...

  • Page 282

    1 2 3 4 5 6 7 8 34 a b c d e f g h i j k l main circuit diagram 003 (dm1000) main circuit diagram 003 (dm1000) dm1000 28cc1-8826680-3 lcd controller d-ff transceiver and dc-dc converter dc-dc converter to lcd-cn501 to dcd-cn203 (lcdc, power).

  • Page 283

    A b c d e f g h i j k l m n o p q r 1 2 3 4 5 6 7 8 9 10 11 12 main circuit diagram 004 (dm1000) main circuit diagram 004 (dm1000) dm1000 28cc1-8826680-4 35 inverter transceiver transceiver transceiver transceiver transceiver transceiver transceiver transceiver transceiver transceiver transceiver tr...

  • Page 284

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 36 a b c d e f g h i j k l m n o p q r s t u v w x y main circuit diagram 005 (dm1000) main circuit diagram 005 (dm1000) dm1000 28cc1-8826680-5 : film capacitor (フィルムコンデンサー) (フ) : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) pll...

  • Page 285

    A b c d e f g h i j k l m n o p q r s t u v w x y 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 main circuit diagram 006 (dm1000) main circuit diagram 006 (dm1000) dm1000 28cc1-8826680-6 37 sdram 16m dsp7 dsp7 dsp7 dsp7 sdram 16m sdram 16m sdram 16m : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resi...

  • Page 286

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 38 a b c d e f g h i j k l m n o p q r s t u v w x main circuit diagram 007 (dm1000) main circuit diagram 007 (dm1000) dm1000 28cc1-8826680-7 sdram 16m sdram 16m dsp7 dsp7 : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) : not instal...

  • Page 287

    A b c d e f g h i j k l m n o p q r s t u v w x 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 main circuit diagram 008 (dm1000) main circuit diagram 008 (dm1000) dm1000 28cc1-8826680-8 39 dram 4m dram 4m dram 4m dsp6 dsp6 dsp6 dsp6 transceiver dram 4m dram 4m dram 4m dram 4m dram 4m : not installed (実装し...

  • Page 288

    1 2 3 4 5 6 7 8 9 10 11 12 40 a b c d e f g h i j k l m n o p q main circuit diagram 009 (dm1000) main circuit diagram 009 (dm1000) dm1000 28cc1-8826680-9 multiplexer multiplexer multiplexer atsc2a atsc2a multiplexer (atsc2).

  • Page 289

    A b c d e f g h i j k l 1 2 3 4 5 6 7 8 main circuit diagram 010 (dm1000) main circuit diagram 010 (dm1000) dm1000 28cc1-8826680-10 41 : mylar capacitor (マイラーコンデンサー) ( マ ) : metal film resistor (金属被膜抵抗) ( f ) and inverter src buffer dit dit and and src (2tr digital i/o).

  • Page 290

    42 a b c d e f g h i j k main circuit diagram 011 (dm1000) main circuit diagram 011 (dm1000) dm1000 28cc1-8826680-11 3 1 2 3 4 5 6 7 8 to jk2-cn701 to jk1-cn651 to jk1-cn652 d-ff transceiver gate array (sio4, jk1 i/f, jk2 i/f).

  • Page 291

    A b c d e f g h i j k l m 1 2 3 4 5 6 7 8 9 main circuit diagram 012 (dm1000) main circuit diagram 012 (dm1000) dm1000 28cc1-8826680-12 43 2 slot2-b slot2-b slot1-a slot1-a to opt-cn804 to opt -cn803 to opt -cn802 to opt -cn801 transceiver transceiver buffer buffer transceiver (opt i/f).

  • Page 292

    1 2 3 4 5 6 7 8 44 a b c d e f g h i j k main circuit diagram 013 (dm1000) main circuit diagram 013 (dm1000) dm1000 28cc1-8826680-13 4 to ada-cn953 to haad 1/2-cn951 transceiver buffer buffer (ada i/f, ha i/f) : not installed (実装しない) x x.

  • Page 293

    A b c d e f g h 1 2 3 4 5 6 lcd circuit diagram (dm1000) lcd circuit diagram (dm1000) dm1000 28cc1-8826689-1 45 2 to main-cn005 to lcd module (back light) to pn1 (2/4)-cn402 to lcd module (lcd contrast volume) dc-dc converter regulator +12v µ pc2912t-e1(x2091a00) regulator +12v 1: input 2: gnd 3: ou...

  • Page 294

    1 2 3 4 5 6 7 8 9 10 11 12 46 a b c d e f g h i j k l m n o p q r pn1 circuit diagram 002 (dm1000) pn1 circuit diagram 002 (dm1000) dm1000 28cc1-8826687-2 to fd-cn403 to fd-cn404 to fd-cn401 to pn1 (2/4)-cn401 to pn2-cn301 to fd-cn402 monitor level joy stick to dcd-cn204 decoder : ceramic capacitor ...

  • Page 295

    A b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 pn1 circuit diagram 003 (dm1000) pn1 circuit diagram 003 (dm1000) dm1000 28cc1-8826687-3 47 aux1 aux1 aux2 aux2 aux3 aux3 aux4 autimix access> midi access> pair/group access> pan/ surround access> dynamics access> effect access> scene acce...

  • Page 296

    1 2 3 4 5 6 7 8 9 10 11 12 48 a b c d e f g h i j k l m n o p pn1 circuit diagram 004 (dm1000) pn1 circuit diagram 004 (dm1000) dm1000 28cc1-8826687-4 scene memory peak 9 peak 10 peak 11 peak 12 peak 13 peak 14 peak 15 peak 16 signal 9 signal 10 signal 11 signal 12 signal 13 signal 14 signal 15 sign...

  • Page 297

    A b c d e f g h i j k l m n o p 1 2 3 4 5 6 7 8 9 10 11 12 pn1 circuit diagram 005 (dm1000) pn1 circuit diagram 005 (dm1000) dm1000 28cc1-8826687-5 49 q frequency gain parameter wheel encoder pn1 (4/4) pn1 (1/4).

  • Page 298

    1 2 3 4 5 6 7 8 50 a b c d e f g h i j k pn1 circuit diagram 006 (dm1000) pn1 circuit diagram 006 (dm1000) dm1000 28cc1-8822687-6 to pn1 (1/4)-cn107 to lcd-cn503 lcd contrast meter led, lcd contrast volume pn1 (2/4).

  • Page 299

    A b c d e f g h 1 2 3 4 5 6 pn2 circuit diagram (dm1000) pn2 circuit diagram (dm1000) dm1000 28cc1-8826688-1 51 to pn1 (1/4)-cn106 display defined keys> defined keys> 1 2 3 4 defined keys> defined keys> defined keys> defined keys> 1 2 3 4 defined keys> defined keys> defined keys> defined keys> 5 6 7...

  • Page 300

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 52 a b c d e f g h i j k l m n o p q r s t u v w xlr circuit diagram (dm1000) xlr circuit diagram (dm1000) dm1000 28cc1-8826693-2 to ada-cn152 to haad 1/2-cn102 to ada-cn352 to haad 1/2-cn502 to ada-cn552 to ada-cn752 omni out 1 omni out 2 omni out 3 omni out 4...

  • Page 301: Circuit Diagram

    Circuit diagram contents block diagram ........................... 3 overall connector circuit diagram ......................................................... 4 overall circuit diagram peak meter bridge mb1000 note: see parts list for details of circuit board component parts. Main (002, 003) ........

  • Page 302

    6 5 4 3 h a b c d e f g 1 2 block diagram (mb1000) block diagram (mb1000) mb1000 28ca1-8826694-2 3 pn main from dm1000 led driver source dr iv er led matrix switch matrix driver/ receiver 5v regulator 3.3v regulator cpu sh2 7042a ic203-205,207-209(16p) ic202,206(16p) cn101 (14p) cn201 (34p) cn102 (3...

  • Page 303

    6 5 4 3 1 2 4 a h g b c f e d overall connector circuit diagram (mb1000) overall connector circuit diagram (mb1000) mb1000 cn101 cn201 cn102 14p 34p 34p main pn from meter (dm1000) d-sub cable.

  • Page 304

    Main circuit diagram 002 (mb1000) main circuit diagram 002 (mb1000) mb1000 28cc1-8826696-2 5 a b c d e f g h i j k l m n o p q 1 2 3 4 5 6 7 8 9 10 11 12 : not installed (実装しない) x x meter (dm1000) to pn-cn201 dc-dc converter dc-dc converter line transceiver dc-dc, rs-422 lm2596sx-3.3 (x3563a00) dc-d...

  • Page 305

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 6 a b c d e f g h i j k l m n o p q r s t u v w main circuit diagram 003 (mb1000) main circuit diagram 003 (mb1000) mb1000 28cc1-8826696-3 2 cpu decoder system reset transceiver not installed : ceramic capacitor (セラミックコンデンサー) ( セ ) cpu : not installed (実装しない) x...

  • Page 306

    A b c d e f g h i j k l m n o p q r s t u v w x 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 pn circuit diagram 002 (mb1000) pn circuit diagram 002 (mb1000) mb1000 28cc1-8826697-2 7 transceiver source driver led driver led driver led driver to main-cn102 bus1 bus2 bus3 bus4 bus5 bus6 bus7 bus8 meter bus 1...

  • Page 307

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 8 a b c d e f g h i j k l m n o p q r s t u v w x pn circuit diagram 003 (mb1000) pn circuit diagram 003 (mb1000) mb1000 28cc1-8826697-3 source driver led driver led driver led driver ch1 ch2 ch3 ch4 ch5 ch6 ch7 ch8 ch9 ch10 ch11 ch12 ch13 ch14 ch15 ch16 met...