- DL manuals
- Yamaha
- Engine
- WB760 WaveBlaster 760
- Service Manual
Yamaha WB760 WaveBlaster 760 Service Manual - page 97
Summary of WB760 WaveBlaster 760
Page 7
Chapter 1 general information.
Page 8
Identification numbers primary id number engine serial number pump serial number hull identification number (hin).
Page 9
Safety while working good working practices.
Page 10
Disassembly and assembly.
Page 11
Special tools measur ing.
Page 12
Removal and installation.
Page 13
Chapter 2 specifications.
Page 14
General specifications.
Page 16
Maintenance specifications engine.
Page 17
Jet unit electrical.
Page 18
Tightening torque specified torque.
Page 19
General torque.
Page 20
Chapter 3 periodic inspection and adjustment.
Page 21
Maintenance interval chart.
Page 22
Periodic service control system pivot shaft bushing inspection steering cable inspection and adjustment.
Page 23
Throttle cable inspection and adjustment.
Page 24
Choke cable inspection and adjustment.
Page 25
Trim cable inspection and adjustment.
Page 27
Fuel system fuel filter inspection trolling speed inspection and adjustment.
Page 28
Carburetor adjustment.
Page 29
Oil injection system oil filter inspection oil injection pump air bleeding.
Page 30
Power unit spark plug inspection.
Page 31
Electrical battery inspection.
Page 33
Jet pump unit impeller inspection bilge strainer inspection.
Page 34
General drain plug inspection greasing point.
Page 38
Chapter 4 fuel system fuel line exploded diagram removal and installation chart.
Page 39
Service points fuel filter inspection fuel cock inspection.
Page 40
Oil tank exploded diagram removal and installation chart.
Page 41
Service points check valve inspection oil level sensor inspection oil tank inspection oil filter inspection.
Page 42
Fuel tank removal exploded diagram removal and installation chart.
Page 43
Fuel tank exploded diagram removal and installation chart.
Page 44
Service points check valve inspection fuel level sensor inspection fuel tank inspection pipe joint inspection pipe joint installation.
Page 45
Carburetor removal exploded diagram removal and installation chart.
Page 46
Carburetor removal exploded diagram removal and installation chart.
Page 47
Service points diaphragm inspection float arm inspection body assembly inspection.
Page 48
Needle valve inspection jet and carburetor body inspection high and low speed screws inspection high and low speed screws adjustment.
Page 49
Throttle valve synchronization inspection and adjustment.
Page 50
Choke valve synchronization inspection and adjustment carburetor assembly.
Page 51
Fuel pump exploded diagram removal and installation chart.
Page 52
Service points fuel pump inspection filter inspection.
Page 53
Oil pump exploded diagram removal and installation chart.
Page 54
Service points oil pump inspection oil hose inspection.
Page 55
Chapter 5 power unit.
Page 58
Reed valve exploded diagram removal and installation chart.
Page 59
Service points reed valve inspection.
Page 60
Exhaust ring exploded diagram removal and installation chart.
Page 61
Exhaust chamber exploded diagram removal and installation chart.
Page 62
Muffler exploded diagram removal and installation chart.
Page 63
Cylinder head exploded diagram removal and installation chart.
Page 64
Service points cylinder head inspection.
Page 65
Cylinder exploded diagram removal and installation chart.
Page 66
Service points cylinder inspection.
Page 67
Piston exploded diagram removal and installation chart.
Page 68
Service points piston pin clip removal and installation piston inspection.
Page 69
Piston ring inspection piston pin and bearing inspection.
Page 71
Engine unit removal exploded diagram removal and installation chart.
Page 72
Service points shim removal mount bracket inspection coupling clearance inspection pilot water hose installation.
Page 73
Flywheel magneto and base exploded diagram removal and installation chart.
Page 74
Service points coupling flange removal and installation flywheel magneto removal and installation coupling flange inspection flywheel magneto inspection idle gear assembly inspection.
Page 75
Electrical unit exploded diagram removal and installation chart.
Page 76
Starter motor exploded diagram removal and installation chart.
Page 77
Service points pinion inspection armature inspection.
Page 78
Brush holder inspection cover inspection.
Page 79
Crankcase exploded diagram removal and installation chart.
Page 80
Service points crankcase inspection crankcase installation.
Page 81
Crankshaft exploded diagram removal and installation chart.
Page 82
Service points crankshaft inspection.
Page 83
Intermediate housing removal exploded diagram removal and installation chart.
Page 84
Intermediate housing exploded diagram removal and installation chart.
Page 85
Service points coupling removal and installation bearing removal and installation bearing inspection coupling inspection.
Page 86
Oil seal installation.
Page 87
Chapter 6 jet pump unit.
Page 88
Jet pump unit removal exploded diagram removal and installation chart.
Page 89
Deflector and trim ring exploded diagram removal and installation chart.
Page 90
Nozzle and duct exploded diagram removal and installation chart.
Page 91
Impeller and drive shaft exploded diagram removal and installation chart.
Page 92
Service points impeller removal drive shaft and bearing removal impeller inspection drive shaft inspection bearing inspection.
Page 93
Oil seal and bearing installation impeller installation.
Page 94
Cooling and bilge system exploded diagram removal and installation chart service points bilge strainer inspection hose inspection chapter 7 electrical system.
Page 96
Electrical components.
Page 97
Service points spiral tube installation.
Page 98
Electrical analysis 3 inspection low resistance measurement.
Page 99
Ignition system wiring diagram.
Page 100
Ignition spark gap.
Page 101
Spark plug spark plug cap ignition coil.
Page 102
Engine stop switch charge coil pulser coil.
Page 103
Thermo switch cdi unit.
Page 104
Starting system wiring diagram.
Page 105
Battery starter motor wiring connection fuse starter switch.
Page 106
Starter relay.
Page 107
Charging system wiring diagram.
Page 108
Fuse battery lighting coil rectifier regulator.
Page 109
Indication system wiring diagram.
Page 110
Fuse battery lighting coil rectifier regulator oil level sensor fuel level sensor.
Page 111
Multi function meter.
Page 113
Chapter 8 hull and hood.
Page 116
Engine hood removal exploded diagram removal and installation chart.
Page 117
Handle exploded diagram removal and installation chart.
Page 118
Service points handle inspection handle switch installation handle holder installation.
Page 119
Trim grip and control cable exploded diagram removal and installation chart.
Page 120
Service points trim control cable inspection grip guide inspection trim grip assembly installation trim cable adjustment.
Page 121
Engine hood cover exploded diagram removal and installation chart.
Page 122
Handle column exploded diagram removal and installation chart.
Page 123
Service points handle column inspection bearing inspection seal packing installation bushing joint installation.
Page 124
Engine hood exploded diagram removal and installation chart.
Page 125
Service points hood support inspection engine hood inspection.
Page 126
Steering cable exploded diagram removal and installation chart.
Page 127
Service points cable inspection jet pump side cable joint installation steering cable adjustment spiral tube installation.
Page 128
Throttle cable and choke cable exploded diagram removal and installation chart.
Page 129
Service points cable inspection cable installation.
Page 130
Trim cable exploded diagram removal and installation chart.
Page 131
Service points cable inspection jet pump side cable joint installation trim cable adjustment.
Page 132
Seat, storage box and battery case exploded diagram removal and installation chart.
Page 133
Service points seat inspection battery case inspection storage box inspection.
Page 134
Exhaust system exploded diagram removal and installation chart.
Page 135
Service points exhaust system inspection.
Page 136
Deck exploded diagram removal and installation chart.
Page 137
Service points ventilation system inspection hood packing inspection hood lock hook inspection hood packing installation.
Page 138
Gunwale exploded diagram removal and installation chart.
Page 139
Service points gunwale inspection.
Page 140
Mat exploded diagram removal and installation chart.
Page 141
Service points mat inspection mat installation.
Page 142
Hull exploded diagram removal and installation chart.
Page 143
Hull repair light scratching deep scratching.
Page 144
Hull damage (punctured).
Page 145
Insert nut.
Page 146
Removing a graphic applying a graphic.
Page 148
Chapter 9 trouble analysis.
Page 149
Trouble analysis trouble analysis chart.