1. DL manuals
  2. Aircommand
  3. Air Conditioner
  4. sandpiper
  5. Owner's Manual

Aircommand sandpiper Owner's Manual

Summary of sandpiper

  • Page 1

    Sandpiper installation guide 28 th may 2013 – revision 7 page 1 of 22 sandpiper owners manual - installation - commissioning of unit - maintenance - specifications - operating instructions - cut out templates - spare parts - wiring diagram - troubleshooting guide.

  • Page 2

    Sandpiper installation guide 28 th may 2013 – revision 7 page 2 of 22 warranty of refrigerated airconditioning warranty within australia we undertake by this warranty to rectify, free of charge, at our nearest authorised service agent, any fault due to faulty workmanship or replacement of any faulty...

  • Page 3: Installation & Operating

    Sandpiper installation guide 28 th may 2013 – revision 7 page 3 of 22 head office aircommand australia pty ltd 954-956 port road albert park, sa 5014 acn 164 415 445 for warranty claims, sales enquires or customer service call: (08) 8345 8444 fax: (08) 8243 0628 email: service@aircommand.Com.A u ins...

  • Page 4: General Unit Information

    Sandpiper installation guide 28 th may 2013 – revision 7 page 4 of 22 general unit information i. Purpose the aircommand sandpiper air conditioning unit was designed as a ducted unit for installation on the floor underneath a seat/bed or inside a cupboard of a caravan or recreational vehicle (rv) to...

  • Page 5: Warning

    Sandpiper installation guide 28 th may 2013 – revision 7 page 5 of 22 installation parts list main components 1. Sandpiper air conditioner 2. Filter 3. Sealing mat 4. Return air grille 5. Ducting spigots 6. Lcd touchscreen and remote (not shown) 7. Power cord (2m long) and separate cable to interfac...

  • Page 6

    Sandpiper installation guide 28 th may 2013 – revision 7 page 6 of 22 installation before beginning, mark out the position of the unit based on the following important requirements: the sandpiper should be placed in the centre of the rv so that the duct lengths are as even as possible and also near ...

  • Page 7: Warning

    Sandpiper installation guide 28 th may 2013 – revision 7 page 7 of 22 figure 4-if the filter of the sandpiper is placed on the opposite side of the return air grille then the air passage must remain unobstructed contact aircommand if your installation differs significantly from that prescribed above...

  • Page 8: Proceed To Commissioning

    Sandpiper installation guide 28 th may 2013 – revision 7 page 8 of 22 cut 65mm diameter holes in the cupboard/wall where the ducting outlets will be positioned then place the inner duct piece on the inner side of the wall and screw the outer duct piece on (leaving only the outer duct piece visible) ...

  • Page 9: Warning

    Sandpiper installation guide 28 th may 2013 – revision 7 page 9 of 22 commissioning of the unit 1. Turn the power on at the circuit breaker. 2. Press the on/off “ ” button and set the time and day (see operating instructions). Then press the mode button “ ” to select fan “ ” . 3. Cycle through the l...

  • Page 10

    Sandpiper installation guide 28 th may 2013 – revision 7 page 10 of 22 if you have a claim please contact aircommand directly on (08) 8345 8444, alternatively you can fax (08) 8243 0628 or email service@aircommand.Com.Au , please have your unit serial number ready (which can be found on the sticker ...

  • Page 11: General Specifications

    Sandpiper installation guide 28 th may 2013 – revision 7 page 11 of 22 general specifications air – conditioner height - 287mm width - 442mm length - 652mm (692mm including hold down brackets) weight - 29kg aircommand australia pty ltd sandpiper model no. 7000001 240v 50hz refrigerant 407c 450g rate...

  • Page 12

    Sandpiper installation guide 28 th may 2013 – revision 7 page 12 of 22 operating instructions this appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or ...

  • Page 13

    Sandpiper installation guide 28 th may 2013 – revision 7 page 13 of 22 cooling cycle mode button to highlight the snowflake icon “ ”. You may select high, med, low or auto fan speeds by pressing the fan button “ ” . Now select the desired room temperature (herein referred to as the “set point”) by p...

  • Page 14

    Sandpiper installation guide 28 th may 2013 – revision 7 page 14 of 22 with “ ”blinking, press “ ” or “ ” to change set time press “ ” for 3 seconds to change between on and off timer setting press “ ” for 3 seconds to cancel on/off timer set for current day press “ ” for 6 seconds to cancel all on/...

  • Page 15

    Sandpiper installation guide 28 th may 2013 – revision 7 page 15 of 22 figure 11-remote control functions fan speed display high / medium / low / auto clock & timer display real time clock timer on / timer off temperature set point display 16 °c – 30 °c mode display cool / dry / heat/ auto / fan sle...

  • Page 16

    Sandpiper installation guide 28 th may 2013 – revision 7 page 16 of 22 sandpiper floor template.

  • Page 17

    Sandpiper installation guide 28 th may 2013 – revision 7 page 17 of 22.

  • Page 18

    Sandpiper installation guide 28 th may 2013 – revision 7 page 18 of 22 sandpiper spare parts number on diagram part number description 1 7001003 inside fan assembly (inc. 1.5 uf capacitor) 2 7001002 filter 3 6102092 return air grille 4 5601069 electronics kit (inc. Touchscreen and remote) 5 7001004 ...

  • Page 19

    Sandpiper installation guide 28 th may 2013 – revision 7 page 19 of 22 sandpiper wiring diagram.

  • Page 20

    Sandpiper installation guide 28 th may 2013 – revision 7 page 20 of 22 sandpiper troubleshooting guide symptom cause correction unit does not operate no power supply to unit check that mains power is plugged into van and that the supply is switched on. Check the van’s air-conditioner power circuit b...

  • Page 21

    Sandpiper installation guide 28 th may 2013 – revision 7 page 21 of 22 maximum ducting lengths. High outside air temperatures in cooling take action to reduce your peak heat load – extend awnings, close blinds, windows & hatches, start air conditioner earlier in the morning. Discuss your expected he...

  • Page 22

    Sandpiper installation guide 28 th may 2013 – revision 7 page 22 of 22 unit will dehumidify air inside the caravan and provide more comfortable living conditions. In humid conditions close doors, windows and hatches. Run the inside fan on high or medium, avoid using low or auto fan speeds in humid c...