- DL manuals
- Audi
- Automobile Electronics
- A6
- Repair Manual
Audi A6 Repair Manual - page 11
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
9 - Camshaft adjustment valve 1 -N205-
❑ Component location
10 - Throttle valve control module -J338-
❑ After replacement, adapt in operating mode “Guided Fault-Finding” in “Adapting throttle valve control
module”
11 - Evaporative emission (EVAP) canister purge solenoid valve -N80-
12 - Intake Air Temperature (IAT) sensor -G42- / Manifold Absolute Pressure (MAP) sensor -G71-
❑ Component location
13 - Intake Manifold Runner Control (IMRC) valve -N316-
14 - Knock sensor 1 -G61- 20 Nm
❑ Component location
❑ Connector location
15 - Intake Manifold Tuning (IMT) valve position sensor -G513-
❑ Component location
16 - Change over valve for intake manifold flap -N239-
❑ Component location
17 - Engine Coolant Temperature (ECT) sensor -G62-
❑ Component location
18 - Actuator for intake manifold change over
19 - Intake manifold runner position sensor -G336-
❑ Component location
❑ After replacing, adapt in “Guided Fault Finding” operating mode under “Adapting intake manifold runner
position sensor”
20 - Fuel injectors, cylinder bank 1
❑ Cylinder 1 fuel injector -N30-
❑ Cylinder 2 fuel injector -N31-
❑ Cylinder 3 fuel injector -N32-
21 - Camshaft Position (CMP) sensor -G40-
❑ Component location
22 - Ignition coils, cylinder bank 1
❑ Ignition coil 1 with power output stage -N70-
❑ Ignition coil 2 with power output stage -N127-
❑ Ignition coil 3 with power output stage -N291-
Engine Compartment, Left
Audi A6 2005 ➤
Fuel Injection and Ignition - Edition 03.2008
2. Description and Operation
7
Summary of A6
Page 1
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Repair manual audi a6 2005...
Page 2
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. List of workshop manual re...
Page 3
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Contents 24 - fuel injecti...
Page 4
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Audi a6 2005 ➤ fuel inject...
Page 5
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 24 – fuel injection system...
Page 6
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Observe the following if t...
Page 7
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – connect vehicle diagnosi...
Page 8
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Display on -vas 5051- : 1 ...
Page 9
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 1.4 fuel system bleeding t...
Page 10
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2 description and operatio...
Page 11
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 9 - camshaft adjustment va...
Page 12
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 1 - fuel injectors, cylind...
Page 13
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 14 - left electro-hydrauli...
Page 14
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of thro...
Page 15
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of left...
Page 16
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of elec...
Page 17
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location on rear...
Page 18
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location under i...
Page 19
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2.2 air filter assembly ov...
Page 20
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 17 - spreader clip 18 - gr...
Page 21
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 19 - 6 nm 20 - washer 21 -...
Page 22
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2.4 lower intake manifold ...
Page 23
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 17 - seal ❑ replace if dam...
Page 24
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 3 specifications ⇒ “3.1 fa...
Page 25
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 4 diagnosis and testing ⇒ ...
Page 26
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove cover for right l...
Page 27
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect fuel line -ar...
Page 28
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – close shut-off valve of ...
Page 29
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ test box -v.A.G 1598/42-...
Page 30
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – connect test box -v.A.G ...
Page 31
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 5 removal and installation...
Page 32
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – open clips -arrows- on u...
Page 33
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect vacuum line -...
Page 34
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove front engine cove...
Page 35
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect vacuum hose -...
Page 36
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove bolts -arrows- an...
Page 37
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove intake manifold u...
Page 38
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – fasten bolts -arrows- fo...
Page 39
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – to fasten high-pressure ...
Page 40
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. If fuel injectors cannot b...
Page 41
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – clip radial adjustment -...
Page 42
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – press sizing sleeve -t10...
Page 43
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove bolts -1 through ...
Page 44
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical co...
Page 45
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – to fasten high-pressure ...
Page 46
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – pry off caps on wiper ar...
Page 47
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – set adjustment on heat g...
Page 48
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Note the threads of both s...
Page 49
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect check valve -...
Page 50
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove oxygen sensor -2-...
Page 51
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical ha...
Page 52
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Removing – remove rear eng...
Page 53
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove oxygen sensor -1-...
Page 54
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove coolant expansion...
Page 55
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 6 special tools special to...
Page 56
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ test box -v.A.G 1598/42-...
Page 57
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ ring spanner 7-piece set...
Page 58
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 28 – ignition system 1 gen...
Page 59
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. (ecm). Dtc memory must the...
Page 60
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2 specifications ⇒ “2.1 te...
Page 61
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 3 removal and installation...
Page 62
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect check valve -...
Page 63
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical co...
Page 64
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 4 special tools special to...
Page 65
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...
Page 66
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...
Page 67
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...